NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
80 reportsClear category filter122,000 miles · Oct 20, 2019
Unknown Or Other
WHILE UPGRADING TO STEEL BUMPERS FROM THE FLIMSY PLASTIC CRAP MOST VEHICLES COME WITH THESE DAYS, FOUND SIGNIFICANT FRAME ROT. SOMEHOW THE FJ CRUISER IS NOT PART OF THE PREVIOUS TOYOTA RECALLS. I CAN ASSURE YOU THEY'RE AT LEAST AS SUSCEPTIBLE AS THE TACOMAS ET AL. I'M NOW ON THE HUNT FOR AN AFFORDABLE REPLACEMENT FRAME, WHICH SE…
Read full complaint
WHILE UPGRADING TO STEEL BUMPERS FROM THE FLIMSY PLASTIC CRAP MOST VEHICLES COME WITH THESE DAYS, FOUND SIGNIFICANT FRAME ROT. SOMEHOW THE FJ CRUISER IS NOT PART OF THE PREVIOUS TOYOTA RECALLS. I CAN ASSURE YOU THEY'RE AT LEAST AS SUSCEPTIBLE AS THE TACOMAS ET AL. I'M NOW ON THE HUNT FOR AN AFFORDABLE REPLACEMENT FRAME, WHICH SEEMS TO BE MERELY A PIPE DREAM. I LOVE THIS VEHICLE AND WILL DO WHATEVER IT TAKES TO REPAIR IT BUT, COME ON TOYOTA. THIS IS NOT WHAT THE MARKET EXPECTS FROM YOU!
NHTSA ODI #11269592
Mileage unknown · Oct 17, 2019
StructureUnknown Or Other
ROTTED RUST ISSUE ALL OVER THE UNDERCARRIAGE.
NHTSA ODI #11269080
98,000 miles · Oct 9, 2019
Service BrakesSuspensionUnknown Or Other
CHASSIS HAS EXCESSIVE RUST. UPPER REAR CONTROL ARM MOUNT ON CHASSIS RUSTED OFF. CAUSING LOSS OF CONTROL WHEN BRAKING. REAR BUMPER SUPPORT HAS HOLE IN FRAME FROM RUST. BODY MOUNTS ARE RUSTING OFF FRAME. BRAKE LINES HAVE RUSTED AND LEAKED FLUID. GAS TANK STRAP MOUNT IS VERY COMPROMISED BY RUST. FRONT RADIATOR SUPPORT EXCESSIVE RUS…
Read full complaint
CHASSIS HAS EXCESSIVE RUST. UPPER REAR CONTROL ARM MOUNT ON CHASSIS RUSTED OFF. CAUSING LOSS OF CONTROL WHEN BRAKING. REAR BUMPER SUPPORT HAS HOLE IN FRAME FROM RUST. BODY MOUNTS ARE RUSTING OFF FRAME. BRAKE LINES HAVE RUSTED AND LEAKED FLUID. GAS TANK STRAP MOUNT IS VERY COMPROMISED BY RUST. FRONT RADIATOR SUPPORT EXCESSIVE RUSTING NUMEROUS SOFT SPOTS AND HOLES. MAJOR FLAKING , AND DELAMINATION OF FRAME ALL OVER. TRUCK HAS 98,000 MILE ON IT IT IS A MANUAL 4WD. LOCATED IN MICHIGAN.
NHTSA ODI #11267519
82,000 miles · Sep 26, 2019
Unknown Or Other
STRUCTURAL FRAME FAILURE FROM RUST
NHTSA ODI #11258407
110,000 miles · Sep 22, 2019
StructureUnknown Or Other
RUST FOUND IN THE FRAME THROUGHOUT, TANK STRAPS AS WELL
NHTSA ODI #11257177
75,000 miles · Sep 18, 2019
SteeringSuspensionUnknown Or Other
2007 TOYOTA FJ CRUISER. THERE IS WIDESPREAD AND SIGNIFICANT RUSTING ON THE FRAME AND DRIVETRAIN COMPONENTS. WELL-MAINTAINED, AND NOT LOCATED IN A SALTY ENVIRONMENT, NOR AN ENVIRONMENT WHERE THE ROADS ARE EVER SALTED. THIS VEHICLE IS UTILIZES THE SAME FRAME AS ANOTHER TOYOTA VEHICLE (4RUNNER), AND THAT VEHICLE WAS INVOLVED WI…
Read full complaint
2007 TOYOTA FJ CRUISER. THERE IS WIDESPREAD AND SIGNIFICANT RUSTING ON THE FRAME AND DRIVETRAIN COMPONENTS. WELL-MAINTAINED, AND NOT LOCATED IN A SALTY ENVIRONMENT, NOR AN ENVIRONMENT WHERE THE ROADS ARE EVER SALTED. THIS VEHICLE IS UTILIZES THE SAME FRAME AS ANOTHER TOYOTA VEHICLE (4RUNNER), AND THAT VEHICLE WAS INVOLVED WITH THE FRAME-RUSTING RECALL DURING THE SAME TIME PERIOD THIS VEHICLE WAS MANUFACTURED.
NHTSA ODI #11256485
120,000 miles · Aug 25, 2019
Unknown Or Other
MY VEHICLE HAS SUBSTANTIAL FRAME ROT IN THE REAR SECTION OF THE FRAME AND THE REAR BUMPER REINFORCEMENT. I HAVE ATTEMPTED TO CUT OUT ROTTEN SECTIONS OF THE FRAME AND WELDED IN STEEL PLATES TO KEEP THE FRAME FROM COLLAPSING. I HAVE ALSO BOUGHT A NEW SECTION OF FRAME FROM TOYOTA TO REPLACE THE BUMPER REINFORCEMENT. I WAS TOLD BY T…
Read full complaint
MY VEHICLE HAS SUBSTANTIAL FRAME ROT IN THE REAR SECTION OF THE FRAME AND THE REAR BUMPER REINFORCEMENT. I HAVE ATTEMPTED TO CUT OUT ROTTEN SECTIONS OF THE FRAME AND WELDED IN STEEL PLATES TO KEEP THE FRAME FROM COLLAPSING. I HAVE ALSO BOUGHT A NEW SECTION OF FRAME FROM TOYOTA TO REPLACE THE BUMPER REINFORCEMENT. I WAS TOLD BY TOYOTA THAT THERE ARE CURRENTLY NO RECALLS ON FJ CRUISER FRAMES AND THAT THE FRAMES ARE NOT FAULTY. BUT THE AMOUNT OF FRAME ROT ON THIS 12 YEAR OLD VEHICLE SEEMS EXCESSIVE. I AM AFRAID THAT THE VEHICLE WOULD COLLAPSE IN THE EVENT OF A REAR END COLLISION. SO FAR, NO COMPONENTS HAVE FAILED OR FALLEN OFF DURING DRIVING.
NHTSA ODI #11246276
285,000 miles · Jul 23, 2019
Unknown Or Other
THE FUEL TANK STRAPS WE'RE COMPLETELY RUSTED OUT . I FOUND THIS OUT WHEN I NOTICED MY TANK WAS HANGING DOWN AFTER ARRIVING AT A DESTINATION . I DROVE HOME CAREFULLY AND JACKED THE VEHICLE UP CLIMBED UNDER TO SEE WHAT THE PROBLEM WAS IN THE STRAPS WERE DISINTEGRATED. I NOTICED HOW RUSTY THE FRAME WAS LOOKING SO I POKED IT W…
Read full complaint
THE FUEL TANK STRAPS WE'RE COMPLETELY RUSTED OUT . I FOUND THIS OUT WHEN I NOTICED MY TANK WAS HANGING DOWN AFTER ARRIVING AT A DESTINATION . I DROVE HOME CAREFULLY AND JACKED THE VEHICLE UP CLIMBED UNDER TO SEE WHAT THE PROBLEM WAS IN THE STRAPS WERE DISINTEGRATED. I NOTICED HOW RUSTY THE FRAME WAS LOOKING SO I POKED IT WITH MY FINGER AND MY FINGER WENT RIGHT THROUGH . I HAVE TAKEN EXCEPTIONALLY GOOD CARE OF THIS VEHICLE BUT NOTHING COULD HAVE PREVENTED THIS PROBLEM BECAUSE THE FRAME RUSTED FROM THE INSIDE OUT AND IS MOST LIKELY A DESIGN FLAW IN ENGINEERING BY TOYOTA .
NHTSA ODI #11234176
103,000 miles · Jul 16, 2019
Fuel/propulsion SystemUnknown Or Other
WHILE INSPECTING EXCESSIVE RUST FROM MY FRAME AND THE PARTS OF THE FRAME THAT HAVE FAILED (ALREADY REPORTED), WE NOTICED THE GAS STRAPS. THEY ARE COMPLETELY RUSTED AND OVER 3/4 BROKEN BECAUSE OF THE RUST.
NHTSA ODI #11232514
178,000 miles · Jul 15, 2019
StructureUnknown Or Other
EXCESSIVE RUST OF THE FRAME. HAVE FOUND MULTIPLE HOLES IN STRUCTURAL AREAS SUCH AS THE TRANSMISSION CROSS MEMBER WELDS MEETING THE FRAME. FAILURE OF THE FRAME COATING ALL OVER. FRAME ROT FROM THE INSIDE CAUSING HOLES FROM THE INSIDE OUT. ALSO RUSTING FROM AREAS SUCH AS CONTROL ARMS, REAR END LINKS, AND DIFFERENTIAL MOUNTS. WILL …
Read full complaint
EXCESSIVE RUST OF THE FRAME. HAVE FOUND MULTIPLE HOLES IN STRUCTURAL AREAS SUCH AS THE TRANSMISSION CROSS MEMBER WELDS MEETING THE FRAME. FAILURE OF THE FRAME COATING ALL OVER. FRAME ROT FROM THE INSIDE CAUSING HOLES FROM THE INSIDE OUT. ALSO RUSTING FROM AREAS SUCH AS CONTROL ARMS, REAR END LINKS, AND DIFFERENTIAL MOUNTS. WILL PROVIDE MORE PICTURES WHEN I HAVE THE AVAILABILITY TO DO SO.
NHTSA ODI #11232065
Official recalls
8Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 25, 2013
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
Mar 15, 2013
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence & remedy
Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 26, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.
Consequence & remedy
Consequence: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration