IllustrationSTRUCTURAL FRAME RUST OVER THE ENTIRE FRAME AND FUEL TANK STRAPS.
2007 Toyota Fj Cruiser
Owner reports · Recalls · Investigations
More warning signs than most Fj Cruiser years
Owner complaints for the 2007 Toyota Fj Cruiser are substantially higher than the model-year median of 26.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Fj Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1460–25K
6525–50K
5150–75K
4975–100K
76100–150K
55150K+
442 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports5 fire reports8 injury reports
Unknown Or Other complaints
80 reportsFUEL TANK STRAP RUST. I NOTICED MY FUEL TANK HANGING LOW ONE DAY. TURNS OUT A FUEL TANK STRAP HAD RUSTED IN TWO. I HAD SOMEONE WELD THE STRAP BACK TOGETHER TO HOLD MY FUEL TANK IN PLACE. VEHICLE WAS STATIONARY WHEN NOTICED. IN THE ATTACHED PICTURE YOU CAN SEE THE WELD REPAIR THAT IS NOW HOLDING THE FUEL TANK IN PLACE.
STRUCTURAL FRAME RUST. THE FRAME IS VERY RUSTY AND THIN WITH LOTS OF HOLES IN IT. I FEAR FOR MY SAFETY AND THE SAFETY OF MY PASSENGERS. THE REAR CROSS MEMBER IS EXTREMELY RUSTED AND WOULD NOT HOLD IN A REAR END COLLISION. IN THIS PARTICULAR INCIDENT THE DRIVER'S SIDE REAR LOWER CONTROL ARM BROKE FREE WHILE DRIVING AT 55MPH AN…
Read full complaint
STRUCTURAL FRAME RUST. THE FRAME IS VERY RUSTY AND THIN WITH LOTS OF HOLES IN IT. I FEAR FOR MY SAFETY AND THE SAFETY OF MY PASSENGERS. THE REAR CROSS MEMBER IS EXTREMELY RUSTED AND WOULD NOT HOLD IN A REAR END COLLISION. IN THIS PARTICULAR INCIDENT THE DRIVER'S SIDE REAR LOWER CONTROL ARM BROKE FREE WHILE DRIVING AT 55MPH AND SENT THE TRUCK OUT OF CONTROL IN TO THE NEXT LANE.LUCKILY NO ONE WAS INJURED AND SLOWING DOWN KEPT IT UNDER CONTROL. THIS WAS ON A SMALL HIGHWAY WHILE SLIGHTLY TURNING LEFT.
MY FRAM IS COMPLETELY RUSTED OUT I HAVE NEVER HAD A CAR WITH THIS PROBLEM
MY FRAME HAS AN EXCESSIVE AMOUNT OF RUST AND I AM CONCERNED THAT IT IS GOING TO BEGIN DETERIORATING.
THE FRAME OF MY 2007 TOYOTA FJ CRUISER IS RUSTING UNCONTROLLABLY. IT WAS "DESCALED" AND SPRAYED WITH PROTECTING FLUID. THE DESCALING REVEALED SIGNIFICANT FRAME RUST. MY PASSENGER REAR SHOCK MOUNT HAS RUSTED COMPLETELY AND THE SHOCK HAS BECOME FREE FROM THE FRAME. I HAVE YET TO GET AN ACCURATE ESTIMATE OF THE DAMAGE BUT WILL SOON
FRAME HAS A LOT OF RUST. THE STRAPS TO HOLD THE GAS TANK BROKE DUE TO RUSTING. REAR BUMPER FRAME HAS ALSO RUSTED.
PREVIOUSLY FILED COMPLAINT FOR STRUCTURAL FRAME RUST AND WHILE REMOVING COMPONENTS TO SEE IF THAT'S REPAIRABLE I FOUND 1 OF THE 2 STRAPS THAT HOLD THE FUEL TANK IN PLACE TO BE 90% RUSTED THROUGH AND THE OTHER ONE NOT FAR BEHIND.
FRAME SEEMS VERY RUSTED AS DO SUSPENSION COMPONENTS
FRAME IS ROTTING AWAY JUST AS THE TACOMA FRAMES DID IN THIS TIME FRAME OF MODEL YEAR. AFRAID THE VEHICLE WILL SOON BE UNFIT TO DRIVE DUE TO SAFETY CONCERNS. GAS TANK STRAPS ARE ALSO ROTTING FROM UNDER THE VEHICLE. THIS HAS COME TO LIGHT WHEN I WAS DRIVING DOWN A CITY STREET AND MY GAS TANK STRAP BROKE CAUSING THE TAKE TO DROP FR…
Read full complaint
FRAME IS ROTTING AWAY JUST AS THE TACOMA FRAMES DID IN THIS TIME FRAME OF MODEL YEAR. AFRAID THE VEHICLE WILL SOON BE UNFIT TO DRIVE DUE TO SAFETY CONCERNS. GAS TANK STRAPS ARE ALSO ROTTING FROM UNDER THE VEHICLE. THIS HAS COME TO LIGHT WHEN I WAS DRIVING DOWN A CITY STREET AND MY GAS TANK STRAP BROKE CAUSING THE TAKE TO DROP FROM THE BOTTOM OF THE VEHICLE
Official recalls
816V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
13V163000 · Exterior Lighting
Apr 25, 2013
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
13V098000 · Seat Belts:front:anchorage
Mar 15, 2013
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence & remedy
Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
06V235000 · Tires:bead
Jun 26, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.
Consequence & remedy
Consequence: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.