IllustrationPer mechanic who put a new muffler on said the frame is so rusted it wouldn’t pass inspection!
2007 Toyota Fj Cruiser
Owner reports · Recalls · Investigations
More warning signs than most Fj Cruiser years
Owner complaints for the 2007 Toyota Fj Cruiser are substantially higher than the model-year median of 26.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Fj Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1460–25K
6525–50K
5150–75K
4975–100K
76100–150K
55150K+
442 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports5 fire reports8 injury reports
Unknown Or Other complaints
80 reportsTook the vehicle in for maintenance at a service center. The mechanic expressed his concern with the amount of rust on the frame on the passenger side and told me that it will soon be a safety concern. He showed me by pulling chunks off of frame with his fingers. The vehicle now sits in the garage.
Structural Frame Rust making vehicle unsafe to drive. Gas tank straps rusted completely through as well.
Undercarriage of vehicle was not properly rust coated by manufacturer. Undercarriage is so rusted that my mechanic advised it may need a new frame.
My recently purchased Toyota FJ Cruiser was found to have severe rust underneath the car . Nuts and bolts have rotted away with the part now held together by rust weld. New straps are holding up a dented gas tank which my mechanic thinks fell when the original straps failed. Is it a safety issue when a gas tank falls off a trave…
Read full complaint
My recently purchased Toyota FJ Cruiser was found to have severe rust underneath the car . Nuts and bolts have rotted away with the part now held together by rust weld. New straps are holding up a dented gas tank which my mechanic thinks fell when the original straps failed. Is it a safety issue when a gas tank falls off a traveling vehicle? I don’t know what other problems may arise from this, but I have been online and there seems to be complaints of this nature all over the internet. Toyota ordered a recall on several models for this problem, but not the FJ. This many people can’t be making this stuff up. At some point it is going to lead to a death, if it hasn’t already . Have only had this vehicle 2 weeks, and I find it hard to believe Toyota can’t address this problem like it did with other models of their fleet. One lady’s pickup bed almost separated from the front of the truck. Please use whatever tools you have to see that Toyota does the right thing, and takes care of the customers who are driving their vehicles.
Frame is failing and fully corroded/compromised. Combination of very poor steel Toyota used in manufacturing (during these model years) combined with Toyota’s placement of air conditioning condensation drain above frame on passenger side has resulted in a corroded and corrupted frame with dangerous and deadly loss of structural …
Read full complaint
Frame is failing and fully corroded/compromised. Combination of very poor steel Toyota used in manufacturing (during these model years) combined with Toyota’s placement of air conditioning condensation drain above frame on passenger side has resulted in a corroded and corrupted frame with dangerous and deadly loss of structural integrity.
recently purchased used from dealership. Excessive rust on lower frame and other components (transmission and power steering lines) as well as suspension. This is not a flood vehicle. Initially took it to Toyota for repairs of the lines and trans. The quote was too high, so I took it to local shops for repair. The local sho…
Read full complaint
recently purchased used from dealership. Excessive rust on lower frame and other components (transmission and power steering lines) as well as suspension. This is not a flood vehicle. Initially took it to Toyota for repairs of the lines and trans. The quote was too high, so I took it to local shops for repair. The local shops were surprised by the amount of rust. Trans was fixed but the shops refused to fix other components that attached to the frame because they fear they will cause more damage. Visited several FJ Cruiser forums and frame rust issues are incredibly common with the FJ, to the point where there are class action lawsuits. Toyota needs to step up and fix this issue for FJ owners!
Frame rust and fuel tank strap rust
Our 2007n Toyota FJ only has 135, 000 miles on it and runs well. We love the vehicle and have a severely rusted out frame. the truck has been adequately maintained but is now unsafe to drive. There are several large areas of rusted frame that are gone, motor mounts have fallen off the frame, the rear axle is barely hanging on be…
Read full complaint
Our 2007n Toyota FJ only has 135, 000 miles on it and runs well. We love the vehicle and have a severely rusted out frame. the truck has been adequately maintained but is now unsafe to drive. There are several large areas of rusted frame that are gone, motor mounts have fallen off the frame, the rear axle is barely hanging on because the rear frame is brittle. on the passenger side almost 3 feet of frame is gone from the underside of the vehicle. There is very little metal left to weld to making repairs not possible. Toyota Corperate refuses to assist us and we are stuck with a vehicle that is near total failure.
Frame has very premature rust issues. Structure of the vehicle is comprised due to well known issue of poor frame coating during manufacture of vehicle.
Official recalls
816V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
13V163000 · Exterior Lighting
Apr 25, 2013
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
13V098000 · Seat Belts:front:anchorage
Mar 15, 2013
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Consequence & remedy
Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
06V235000 · Tires:bead
Jun 26, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.
Consequence & remedy
Consequence: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.