2007 Toyota Fj Cruiser

DURING 2019-2020 STATE INSPECTION OF 2007 FJ CRUISER WITH 78000 MILES BY DEALER WAS TOLD THAT FRAME IS SO RUSTED THAT IT PROBABLY WOULD NOT PASS THE NEXT INSPECTION. EXPLANATION GIVEN WAS THAT TOYOTA DOES NOT MAKE THEIR FRAMES AS THICK AS OTHER MAKES. THIS VEHICLE WAS USED AS A DAILY DRIVER, NOT MUCH OFF-ROAD AND NO SERIOUS OFF-ROADING. I WORK FROM HOME, SO MOST YEARS LESS THAN 5000 MILES DRIVEN. ALSO HAVE HAD TO REPLACE FRONT BRAKE CALIPERS FOR THE PAST 3 YEARS.

WHILE DRIVING NORMALLY AND LESS THAN 10 MILES PER HOUR, THANKFULLY ON A REGULAR, PAVED, LOCAL ROAD WITH LITTLE TRAFFIC, THE DRIVER SIDE REAR SUSPENSION SPRING SEAT AND STABILIZER BAR ATTACHMENT POINT ON REAR AXLE SUDDENLY, UNEXPECTEDLY, AND WITHOUT WARNING JUST TORE APART AND OFF OF THE AXLE HOUSING TO WHICH IT WAS MOUNTED AND THE RESULTING SHARP AND HEAVY METAL EDGED PARTS COMPLETELY SHEARED OFF A BRAKE LINE RELEASING ALL HYDRAULIC BRAKE FLUID AND CAUSING THE IMMEDIATE LOSS OF ALL NORMAL BRAKING ABILITY. THANKFULLY NOBODY WAS INJURED, BUT THE CAR CAN'T BE DRIVEN AT ALL NOW, BECAUSE IT HAS NO BRAKES AT ALL, OTHER THAN THE MECHANICAL EMERGENCY BRAKE, AND BY USING TRANSMISSION "BRAKING." LOTS OF RUST UNDER CAR SINCE WE BOUGHT IT USED FROM DEALER IN MORRISTOWN NJ, APPARENTLY DUE TO LOW QUALITY STEEL USED IN INITIAL CONSTRUCTION AND APPARENT LACK OF ADEQUATE FACTORY ANTI-RUST TREATMENT OF FRAME AND OTHER UNDERCARRIAGE PARTS. INTERIOR AND PAINTED TOP BODY PARTS SHOW NO RUST ISSUES. HOWEVER, THE UNDERSIDE, IS FULL OF LOTS OF RUST. THIS IS APPARENTLY A WELL-KNOWN, VERY COMMON PROBLEM WITH TOYOTA FJ MODELS. IT IS VERY DANGEROUS, AND IT SHOULD BE ADDRESSED BY TOYOTA IMMEDIATELY! I'M MAKING PLANS TO HAVE THE CAR TOWED TO A LOCAL TOYOTA DEALERSHIP FOR INSPECTION AND POSSIBLE REPAIRS. FINALLY, AS FAR AS I AM AWARE, THIS CAR HAS NEVER DONE ANY SIGNIFICANT OR TAXING "OFF-ROADING."

CHASSIS HAS EXCESSIVE RUST. UPPER REAR CONTROL ARM MOUNT ON CHASSIS RUSTED OFF. CAUSING LOSS OF CONTROL WHEN BRAKING. REAR BUMPER SUPPORT HAS HOLE IN FRAME FROM RUST. BODY MOUNTS ARE RUSTING OFF FRAME. BRAKE LINES HAVE RUSTED AND LEAKED FLUID. GAS TANK STRAP MOUNT IS VERY COMPROMISED BY RUST. FRONT RADIATOR SUPPORT EXCESSIVE RUSTING NUMEROUS SOFT SPOTS AND HOLES. MAJOR FLAKING , AND DELAMINATION OF FRAME ALL OVER. TRUCK HAS 98,000 MILE ON IT IT IS A MANUAL 4WD. LOCATED IN MICHIGAN.

TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. WHILE DRIVING 62 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. IN ADDITION, THE BRAKE PEDAL WAS APPLIED, BUT THE BRAKES FAILED TO RESPOND AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO RIDGEWAY SUNOCO SERVICE CENTER BUT WAS NOT DIAGNOSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT UNKNOWN PARTS NEEDED TO BE REPLACED. THE DEALER WAS CONTACTED (T J TOYOTA INC, 6698 NY-56, POTSDAM, NY 13676, (315) 265-3350). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE WARRANTY HAD EXPIRED. THE FAILURE MILEAGE WAS 105,000.

MASTER CYLINDER FAILED - HAVE TO SLAM THE BRAKE PEDAL ALL THE WAY TO THE FLOOR AND THEN I WAS STILL UNSURE IF THE CAR WOULD ACTUALLY STOP. HAD TWIN 3 YEAR OLD BOYS IN THE CAR, SCARED FOR OUR LIVES. DASHBOARD LITE UP LIKE A CHRISTMAS TREE. SECOND SHOP DIAGNOSED IT AS A FAILED MASTER CYLINDER. PARTS PLUS LABOR = $3,066. I WORK FOR THE SCHOOL SYSTEM AND WE DON'T HAVE THAT SORT OF MONEY. WILL TOW IT HOME, HOPEFULLY FIND A USED PART, AND TRY TO REPLACE IT OURSELVES. THE ONLY REASON I'M LOGGING A COMPLAINT (BECAUSE CARS NEED REPAIRS AND I UNDERSTAND THAT) IS BECAUSE I'M SEEING THE EXACT SAME COMPLAINT OVER AND OVER AGAIN "MASTER CYLINDER TOYOTA FJ CRUISER 2007". HOW CAN SO MANY OF THE SAME COMPLAINTS ON THE EXACT SAME VEHICLE GO UNHEARD? PLEASE HELP, MAKE THE MASTER CYLINDER RECALL APPLY TO THE FJ CRUISER. IT OBVIOUSLY SHOULD BE INCLUDED. THANK YOU FOR YOUR TIME.

THE SEAT BELT RETRACTOR IN MY 2007 FJ CRUISER HAS FAILED TO FUNCTION. SOMETHING AS IMPORTANT TO THE SAFETY OF THE DRIVER OF THE VEHICLE IS SOMETHING THAT SHOULD BE COVERED UNDER THE LIFETIME WARRANTY OF THE VEHICLE. INSTEAD, BAYRIDGE TOYOTA IS TELLING ME THAT I WILL HAVE TO PAY TO HAVE THESE PARTS REPLACED. I'M HORRIFIED THAT TOYOTA HAS NOT ISSUED A RECALL FOR THIS ISSUE TO CORRECT, TOYOTA SHOULD ASSUME RESPONSIBILITY FOR FIXING AN IMPORTANT SAFETY FEATURE. EMERGENCY BRAKES WOULDN'T GO ON

IT SEEMS TO ME THAT MY ANTI-LOCK BREAKS ARE ENGAGING WHEN THEY SHOULDN'T BE. WHEN I TRY TO STOP, IT JERKS SO HARD THAT IT SEEMS AS THOUGH I'VE BEEN HIT FROM BEHIND. IT WILL TRY TO STOP WHILE I'M DRIVING AND STARTS JERKING. THIS HAS HAPPENED MULTIPLE TIMES WHEN I'M DRIVING ON THE HIGHWAY. MY SON IS 20 YEARS OLD AND HAS THIS VEHICLE NOW AND I AM LETTING YOU KNOW, THAT I WILL HOLD TOYOTA AND NHTSA PERSONALLY RESPONSIBLE SHOULD ANYTHING HAPPEN TO HIM. I HAVE READ SO ABOUT SO MANY ISSUES REGARDING THE 2007 TOYOTA FJ BREAKING SYSTEM THAT IT'S UNBELIEVABLE THAT A RECALL HASN'T BEEN ISSUED. YOU ARE PLAYING WITH PEOPLES LIVES.