2007 Toyota Fj Cruiser

I was driving down the street after filling up my fuel tank. I drove approximately 1/2 mile when I heard a sound, felt a clunk and stopped immediately. My fuel tank was hanging down on the ground. I called AAA and requested a flatbed and to bring a strap. He did not bring a strap and when my truck arrived at the mechanic the fuel tank had completely separated from the vehicle. The other complaint I have is the rusted frame. I purchased this vehicle used. I did not notice that the tube before the rear axle which holds suspension supports to the frame were completely broken off and separated from the rusted out frame that has failed. It has been welding but the rusted frame is very difficult to weld to.

I recently purchased the used 2007 Toyota FJ with 101,000 miles. During maintenance and inspection, it was found that the fuel tank straps are rusted out and need to be replaced. The rear brake lines are rusted out and need to be replaced. The frame is severely rusted out and failing at the factory welds. I was referred to submit a report and investigate filing a class action lawsuit against the manufacturer for negligence, as this is apparently a known issue. I am hoping that the will reach someone that is able to help all the owners with the same issues as this should be recalled and repaired to prevent unnecessary injury or death. This is a huge financial burden for those expecting a quality vehicle that will be safe. Failing brakes, loose gas tanks and weakened frames are recipe for disaster.

Serviced 99% of the time at Toyota dealer. Within a week of having the vehicle serviced by the dealer, I noticed a rattling/banging. One gas strap had completely rusted through, and the other was hanging on by about a quarter inch of material. I always ask the dealer to inspect the frame due to the history of rust problems on FJs—they have never flagged anything but I inspect it as I can myself, but have no way to lift the vehicle up thoroughly. I also have the service fluid applied by Rust Check to prevent/inhibit deterioration. On a sidebar, this summer I was traveling on the interstate when the rear-most crossmember rusted out while I was using a hitch haul to move a dresser to South Carolina.

I filled up my truck with gas. Upon driving to work I noticed a loud clank. I looked under the vehicle but it was dark and saw nothing obvious. I continued down the road and heard knocking only when braking hard. When examined in daylight, I could see that the Fuel Tank Support Strap (Rear) rusted thru and the weight of the tank/fuel caused it to shift toward and rub against the Drive Shaft. The loud clank I would hear was caused by the tank being struck by the Drive Shaft balancing weight. The more I research, the more I see others have experienced the same thing. I made it safe until I could procure parts and make the repair. I examined the area and the replaced straps. The rear strap is doomed to fail. The OEM part is painted but exposed in the left rear tire well. Basically, the strap is doomed to be sandblasted by road debris, salt, sand and plain old dirt. Photos and descriptions of others with similar problems are always in the same location. I feel Toyota should make the Straps from a better quality material not as susceptible to corrosive properties of Salt. This is a serious fuel tank issue. If there was a problem with the front strap the rear strap failure could have dropped the tank on the road. Will it take the death(s) of the occupants of affected vehicle should a fire or explosion occur for Toyota to step up and assume responsibility? Or maybe if the tank falls out of the vehicle and car that runs over it then it explodes and kills those occupants will get Toyota's attention? I have retained the failed part should it be needed at a future date for inspection, etc.