2019 Toyota Camry

Two weeks prior, car began rough idling at stop-lights, intermittently. Then one morning, after refueling, the car sputtered and failed to start. The MIL light came on, with display warnings: “Charging System Malfunction” and Steering Power Low”. Car eventually started and barely made it to Carlsbad (CA) Toyota. DTC code pulled was P0171: “System Too Lean Bank 1”. It was diagnosed with low or leaking high-pressure reading for the high-pressure fuel rail. They replaced all four high-pressure direct injectors. However, idle roughness persisted until they replaced the canister purge valve. Car has only used Costco top-tier fuel. Injectors should not have failed at 47,000 miles; likely defective. Fuel pump was replaced years ago under recall, and I was told that fuel pump pressure was fine.

2019 Toyota Camry VIN: [XXX] Issue: Blown head gasket and required engine replacement Mileage at failure: 116,598 approximately Mileage I am filing this complaint due to a sudden and significant engine failure in my 2019 Toyota Camry. Despite regular service at certified Toyota dealerships only things wasn’t serviced at the dealership was my brakes and tires, and a transmission flush in September 27, 2024. Other than that my recent visit to Bulter Toyota was March 21st 2025 which included a $334.17 maintenance visit in March 2025 and my car was good at the time I was told. Now a month later [XXX] my vehicle experienced a blown head gasket with no prior warning or indication of trouble just a check engine light one day [XXX] it never overheated. The issue was diagnosed on April 21, 2025 at Bulter Toyota. Currently renting a car from Bulter Toyota for $42.00 a day my car has been there for 9days The dealership has stated that the engine must be replaced at a cost of $5,335. Additionally, the technician made a concerning statement suggesting my car “looked like it had been in an accident,” even though the vehicle has never been in any collision. This further raised questions about internal defects or manufacturing issues. Toyota Corporate has been contacted, is currently conducting an internal investigation into this matter. However, I am submitting this complaint to NHTSA to ensure it is formally documented outside of Toyota’s internal review process. This is especially important given the pattern of similar complaints involving 2019 Toyota Camrys with the 2.5L 4-cylinder engine, including reports of overheating, coolant leaks, and head gasket failures. I am requesting a full investigation into potential defects related to engine performance and safety in 2019 Toyota Camry models. If a recall is later issued, I respectfully request to be included for possible reimbursement or remedy. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

when I accelerate anywhere between 0-55 there is a whining noise that kind of sounds like a jet engine starting up that progressively raises in pitch the faster I go. This noise is only made while my foot is at any position on the gas. Even just the lightest pushing of the throttle will cause this whining to start. The second I take my foot off it’s completely silent. Many people also Toyota technician reports that it is an ongoing transmission issue with the 8th gen Toyota Camrys.

2019 Camry --> Toyota has customer support program 24TE04 notification for problem with bad flow shut off valve. Problems are engine maintenance light and A/C not functioning properly. This vehicle was purchased new and currently has 3350 miles. The A/C has not functioned properly since purchased. Bredeman Toyota in Park Ridge, IL contacted and appt. scheduled for 4/12/25. The service dept. advised a diagnostic fee of $170.000 would be charge. Toyota contacted about this since the vehicle should be under recall for this problem that could cause the vehicle to overheat. Case #[XXX] provided. I rec'd a call back 4/04/25 from dealership Serv. Mgr. Mike Cooper. Diagnostic charge would not be waived even though I was told they have replaced this part on numerous vehicles for the past three (3) years. I don't understand why Toyota hasn't been told to recall for this problem. Please consider taking this action against the Mfg. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The transaxle (transmission) failed on my 2019 Toyota Camry, causing a complete loss of power while driving. This is part of the power train system. The vehicle is currently at Toyota of North Austin for inspection and repair. 2. How was your safety or the safety of others put at risk? While driving, my car suddenly lost power and stalled in the middle of an intersection. I was unable to pull over, leaving my vehicle stranded in traffic. Other cars almost hit me, creating a major safety hazard. I was panicked and scared, and the failure could have resulted in a serious accident. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Toyota of North Austin diagnosed the issue and confirmed a transmission (transaxle) failure, recommending a full replacement. Toyota has refused goodwill assistance, leaving me with an expensive repair bill. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by Toyota of North Austin, and they confirmed the transmission failure. It has not been inspected by police or insurance representatives. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Shortly before the failure, the check engine light came on. However, there were no other warning signs or messages indicating an immediate issue. The vehicle suddenly lost power while driving. The only related maintenance was a transmission fluid change at Toyota of North Austin on 11/22/24, but there were no immediate signs of failure at that time.

On [XXX], I was involved in a high-speed T-bone collision with a FedEx truck while driving my 2019 Toyota Camry SE (VIN: [XXX] ). Despite the severity of the crash — which totaled my vehicle, caused the windshield to crack, and resulted in my head slamming into the steering wheel — none of the vehicle’s airbags deployed, including the driver’s front airbag. As a direct result of this failure, I sustained head trauma and neurological symptoms. A CT scan taken immediately after the crash revealed a previously undiagnosed 11–12mm partially thrombosed brain aneurysm, which is now causing ongoing vision problems, speech issues, memory loss, and loss of balance. Upon researching known defects, I discovered that my vehicle had a recall for an improperly calibrated Occupant Classification System (OCS) that may prevent airbag deployment — recall #K0M, issued in 2019. I never received any notification of this defect from Toyota. The fact that no airbags deployed in a crash this severe clearly points to a critical safety system failure. I believe this failure greatly worsened my injuries and created long-term health risks that would not exist had the safety systems worked as designed. I am requesting a full investigation and am pursuing a claim for product liability and manufacturer negligence. This complaint is part of a formal record to hold Toyota accountable and protect other drivers from similar harm. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle became extremely hard to steer on curves and when taking turns nearly causing an accident as it wouldn’t return to center without a lot of effort the part that malfunctioned is the Steering Intermediate Shaft, problem has been identified but dealer said only covers vehicles year 2018 and NOT the 2019 models, THE PART IS THE SAME AND THE PROBLEM IS THE SAME yet they only fix one model and not the other , No lights comes up on the dash but the problem is very dangerous and it can Kill someone if problem is identified and noticed