IllustrationENGINE KNOCK/RATTLE NOISE AT COLD STARTUP. LASTS 2 MINUTES UNTIL THE CAR WARMS UP..
2008 Toyota Camry
Owner reports · Recalls · Investigations
More warning signs than most Camry years
Owner complaints for the 2008 Toyota Camry are substantially higher than the model-year median of 295.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
18025–50K
15450–75K
9975–100K
87100–150K
45150K+
689 reports with mileage · 244 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 186 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 141 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 131 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
87 crash reports13 fire reports48 injury reports
Engine complaints
131 reportsTHIS ENGINE HAS BEEN BURNING WAY TOO MUCH OIL AND AFTER LOOKING AT COMPLAINTS ONLINE ABOUT THE SAME PROBLEM I REALIZED THEY WERE SUPPOSED TO HAVE SENT OUT A LETTER YEARS AGO IN 2016 I BELIEVE BUT I NEVER RECEIVED ANY TYPE OF NOTICE ABOUT THIS SO CALLED EXTENDED WARRANTY TO WHERE THEY WERE SUPPOSED TO FIX THE DEFECT PISTONS IN T…
Read full complaint
THIS ENGINE HAS BEEN BURNING WAY TOO MUCH OIL AND AFTER LOOKING AT COMPLAINTS ONLINE ABOUT THE SAME PROBLEM I REALIZED THEY WERE SUPPOSED TO HAVE SENT OUT A LETTER YEARS AGO IN 2016 I BELIEVE BUT I NEVER RECEIVED ANY TYPE OF NOTICE ABOUT THIS SO CALLED EXTENDED WARRANTY TO WHERE THEY WERE SUPPOSED TO FIX THE DEFECT PISTONS IN THE ENGINE. SO NOW THEY SAY IT IS PAST THE TIME FRAME AND MILES TO FIX IT AT THEIR COST. NOW IT IS BURNING MORE OIL AND GETTING WORSE AND TOYOTA WILL NOT FIX THEIR MISTAKE. BAD BUISNESS!
I HAVE HAD TO ADD OIL IN BETWEEN OIL CHANGES OVER THE PAST 5 YEARS, OFTEN TWICE BETWEEN CHANGES. AFTER BEING TOLD THERE WAS A RECALL OF THIS SPECIFIC ISSUE FROM A MECHANIC, I THEN FOUND OUT THAT IT WAS BEYOND THE LENGTH OF TIME TO GET IT REPAIRED UNDER THE RECALL. I WAS THEN INFORMED THAT I SHOULD HAVE RECEIVED A LETTER FROM TOY…
Read full complaint
I HAVE HAD TO ADD OIL IN BETWEEN OIL CHANGES OVER THE PAST 5 YEARS, OFTEN TWICE BETWEEN CHANGES. AFTER BEING TOLD THERE WAS A RECALL OF THIS SPECIFIC ISSUE FROM A MECHANIC, I THEN FOUND OUT THAT IT WAS BEYOND THE LENGTH OF TIME TO GET IT REPAIRED UNDER THE RECALL. I WAS THEN INFORMED THAT I SHOULD HAVE RECEIVED A LETTER FROM TOYOTA IN THE MAIL STATING THERE WAS A RECALL. I NEVER RECEIVED A LETTER ABOUT THIS RECALL. I TOOK THE CAR INTO THE TOYOTA DEALERSHIP IN TOWN ABOUT THE ISSUE AND THEY SAID THEY COULD PERFORM AN OIL TEST ON IT TO SEE HOW MUCH IT WAS BURNING AFTER 1,500 MILES. UPON BRINGING IT BACK I WAS INFORMED THAT MY CAR HADN'T BURNED ENOUGH TO THEIR REQUIRED AMOUNT (AMOUNT NOT DISCLOSED TO ME) TO DO ANYTHING, BUT TOLD ME THAT I COULD ALWAYS COME BACK AND HAVE ANOTHER OIL TEST DONE. I FIND IT VERY DISTURBING THAT THIS HAS BEEN AN ONGOING ISSUE AND THAT THERE IS A CLAIM OF A LETTER BEING SENT TO ME WHEN I NEVER RECEIVED ONE. IT ALSO APPEARS THAT THERE ARE NUMEROUS INDIVIDUALS WITH THIS SAME YEAR HAVE HAD THE SAME PROBLEMS AND NOTHING HAS BEEN DONE ABOUT IT. I AM WONDERING IF THERE HAS BEEN AN INVESTIGATION TO ANYTHING ABOUT THE SUPPOSED LETTERS THAT TOYOTA HAS CLAIMED TO MAIL OUT? IT IS OVERALL BAD BUSINESS ON TOYOTA'S PART TO NOT ENSURE THAT THEIR CUSTOMERS ARE TAKEN CARE OF ENOUGH TO WANT TO CONTINUE BUYING THEIR VEHICLES. WILL THINK TWICE BEFORE BUYING TOYOTA AGAIN. *TR
VEHICLE NOTED TO BURN A TREMENDOUS AMOUNT OF OIL DRIVING LESS THAN 1,200 MILES. CONTACTED TOYOTA WHO INDICATED THEY DID DO AN EXTENSION TO FIX THE ISSUE BUT I WAS TOO LATE. I NEVER RECEIVED THE NOTIFICATION TO LEARN THEY HAD AN OLD ADDRESS FOR ME. I AM NOW HAVING TO DRIVE THE VEHICLE CANNOT AFFORD A NEW ONE AND HAVING TO PUT …
Read full complaint
VEHICLE NOTED TO BURN A TREMENDOUS AMOUNT OF OIL DRIVING LESS THAN 1,200 MILES. CONTACTED TOYOTA WHO INDICATED THEY DID DO AN EXTENSION TO FIX THE ISSUE BUT I WAS TOO LATE. I NEVER RECEIVED THE NOTIFICATION TO LEARN THEY HAD AN OLD ADDRESS FOR ME. I AM NOW HAVING TO DRIVE THE VEHICLE CANNOT AFFORD A NEW ONE AND HAVING TO PUT OIL IN EVERY 7-10 DAYS.
THE OIL CONSUMPTION IS WAY TOO HIGH! MANY SIMILAR COMPLAINTS HAVE BEEN DOCUMENTED ON OTHER ONLINE FORUM. I HAVE TO REFILL MY OIL EVERY 2-3 DAYS. I NOTICED THIS ISSUE SIGNIFICANTLY WHEN MY CAR BEGAN DRIVING WIERD ONLY 2 WEEKS AFTER AN OIL CHANGE & WHEN I WENT TO MY MECHANIC, HE SAID THERE WAS NO MORE OIL IN MY CAR. MY CAR COULD H…
Read full complaint
THE OIL CONSUMPTION IS WAY TOO HIGH! MANY SIMILAR COMPLAINTS HAVE BEEN DOCUMENTED ON OTHER ONLINE FORUM. I HAVE TO REFILL MY OIL EVERY 2-3 DAYS. I NOTICED THIS ISSUE SIGNIFICANTLY WHEN MY CAR BEGAN DRIVING WIERD ONLY 2 WEEKS AFTER AN OIL CHANGE & WHEN I WENT TO MY MECHANIC, HE SAID THERE WAS NO MORE OIL IN MY CAR. MY CAR COULD HAVE STALLED ANYWHERE. THE FACT THAT THIS IS A WELL KNOWN BUT IGNORED ISSUE IS ABSURD
ENGINE IS BURNING TO MUCH OIL, LAST THREE OIL CHANGES I HAVE BEEN COMPLAINING TO TOYOTA DEALER THAT CAR IS GETTING LOW ON OIL ON AVERAGE EVERY TWO WEEKS, I NEVER RECEIVED ANY LETTER FROM TOYOTA REGARDING OIL CONSUMPTION. ON LAST OIL CHANGE IN JUNE 2019 ENGINE LIGHT CAME ON AND I TOOK CAR BACK TO THE DEALER THEY DIAGNOSED EXHAUST…
Read full complaint
ENGINE IS BURNING TO MUCH OIL, LAST THREE OIL CHANGES I HAVE BEEN COMPLAINING TO TOYOTA DEALER THAT CAR IS GETTING LOW ON OIL ON AVERAGE EVERY TWO WEEKS, I NEVER RECEIVED ANY LETTER FROM TOYOTA REGARDING OIL CONSUMPTION. ON LAST OIL CHANGE IN JUNE 2019 ENGINE LIGHT CAME ON AND I TOOK CAR BACK TO THE DEALER THEY DIAGNOSED EXHAUST MANIFOLD NEEDS TO BE REPLACED BUT NEVER DISCLOSED IT IS DUE TO THE TOO MUCH OIL CONSUMPTION. RECENTLY, CAR IS CONSUMING TOO MUCH OIL AND CAR IS JERKING WHEN GAS IS PUSHED. FINALLY, I SEARCHED ONLINE AND FOUND OUT THAT THERE IS AN OIL CONSUMPTION ISSUE WITH 2008 TOYOTA CAMRY. PLEASE WATCH THIS VIDEO ON YOUTUBE HTTPS://WWW.YOUTUBE.COM/WATCH?V=ZBQXCQA_PJK I EMAILED TOYOTA COMPANY ABOUT THIS ISSUE THEY NEVER REPLIED IN WRITING. THEY CALLED ME ON PHONE AND SAID SINCE THIS CAR IS OLDER THAN 10 YEARS AND HAS MORE THAN 150,000 MILES, SO THIS ISSUE IS NO MORE COVERED BY TOYOTA. THEY ALSO CLAIM THAT THEY MAILED ME A LETTER IN 2015 WHICH I NEVER RECEIVED., RECEIVED OTHER THREE LETTERS ABOUT OTHER RECALLS FROM TOYOTA AND THESE LETTERS ARE ONLINE IN MY CAR PROFILE, NOT THE ONE ABOUT OIL CONSUMPTION. I ALWAYS TOOK MY CARE TO TOYOTA DEALER FOR OIL CHANGE. I HAVE BEEN TELLING THEM THAT EITHER YOU ALL ARE NOT PUTTING ENOUGH OIL, OR IT IS BURNING TOO MUCH OIL, BUT THEY NEVER DISCLOSED OIL CONSUMPTION ISSUE WITH MY CAR MODEL. I REQUEST NTSHA TO PLEASE INVESTIGATE WHY 1.TOYOTA NEVER SEND ME A LETTER VIA MAIL REGARDING THIS OIL CONSUMPTION? 2.WHY THIS LETTER IS NOT SHOWING IN THE CAR PROFILE ONLINE BUT ALL OTHERS ARE. 3.WHY DEALER NEVER DISCLOSED ME REGARDING THIS ISSUE, EVEN CAR IS CONSUMING TOO MUCH OIL? TOYOTA IS A BIG COMPANY AND SHOULD NOT GET BY FROM THEIR RESPONSIBILITY OF CUSTOMER SERVICE THAT EASILY ESPECIALLY WHEN THEY ADMITTED THERE IS A DEFECT WITH THESE CARS. I REQUEST NTSHA PLEASE HAVE TOYOTA COMPANY FIX MY CAR. THANKS FOR YOUR HELP!
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY. THE CONTACT STATED THAT THE VEHICLE USED AN EXCESSIVE AMOUNT OF OIL AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO WEST COAST TOYOTA (3399 E WILLOW ST, LONG BEACH, CA 90806, (562) 304-9422) WHO STATED THAT THE VEHICLE WAS NOT COVERED UNDER A WARRANTY. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY. THE CONTACT STATED THAT THE VEHICLE USED AN EXCESSIVE AMOUNT OF OIL AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO WEST COAST TOYOTA (3399 E WILLOW ST, LONG BEACH, CA 90806, (562) 304-9422) WHO STATED THAT THE VEHICLE WAS NOT COVERED UNDER A WARRANTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 1909231445. THE CONTACT WAS REFERRED TO NHTSA. THE FAILURE MILEAGE WAS 140,000.
I PURCHASED A 2008 TOYOTA CAMRY ALMOST TWO YEARS AGO WITH 100,000 THOUSAND MILES. THE CAR WAS RUNNING GREAT UNTIL NOW, IT HAS 120,000 MILES NOW AND IS STARTING TO BURN A LOT OF OIL BETWEEN OIL CHANGES, IT BURNS ABOUT ONE QUART EVERY 800 TO 1000 MILES.
S10 APPROPRIATE HANDLING - COPY OF LETTER ADDRESSED TO TOYOTA MOTOR SALES USA PRESIDENT AND CHIEF OF EXECUTIVE OFFICER JAMES LENTZ REGARDING CONCERNS WITH HIS 2008 CAMRY. *LD THE CONSUMER WAS NOT NOTIFIED OF THE EXTENDED WARRANTY FOR THE ENGINE OIL CONSUMPTION. *JS
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY. THE CONTACT STATED THAT THE OIL AND CHECK ENGINE WARNING INDICATORS KEPT ILLUMINATING. THE CONTACT STATED THAT THERE WAS A CONSTANT LOSS OF ENGINE OIL, WHICH SOMETIMES OCCURRED WITHOUT A WARNING INDICATOR FLASHING. THERE WAS NO PRESENCE OF AN OIL LEAK. AUTONATION TOYOTA MALL OF GEORGIA (…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY. THE CONTACT STATED THAT THE OIL AND CHECK ENGINE WARNING INDICATORS KEPT ILLUMINATING. THE CONTACT STATED THAT THERE WAS A CONSTANT LOSS OF ENGINE OIL, WHICH SOMETIMES OCCURRED WITHOUT A WARNING INDICATOR FLASHING. THERE WAS NO PRESENCE OF AN OIL LEAK. AUTONATION TOYOTA MALL OF GEORGIA (3505 BUFORD DR, BUFORD, GA 30519, (770) 674-6083) STATED THAT THERE WAS AN EXCESSIVE OIL CONSUMPTION FAILURE. THE OIL CONSUMPTION TEST WAS PERFORMED TWICE, BUT IT DID NOT PROVIDE A PERMANENT REMEDY. THE DEALER WAS ASKED SEVERAL TIMES TO PROVIDE FURTHER DIAGNOSTIC TESTING. AFTER ADDING OIL TO THE VEHICLE, THE DEALER RECOMMENDED THAT THE ENGINE BE REBUILT. THE ENGINE HEAD WAS SENT FOR TESTING AND CHECKED FOR A VALVE STEM SEAL THAT MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Official recalls
716V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
12V491000 · Visibility:power Window Devices And Controls
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
10V017000 · Vehicle Speed Control:accelerator Pedal
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
EA07010 · Unwanted Acceleration, Floor Mat
Opened Aug 8, 2007 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE DRIVER SIDE FLOOR MAT WILL NOT INTERFERE WITH THE THROTTLE PEDAL IF PROPERLY SECURED USING THE RETAINING HOOKS PROVIDED BY TOYOTA.HOWEVER, IF THE ALL WEATHER MAT IS UNSECURED AND MOVES FORWARD FROM ITS INTENDED POSITION IT CAN ENTRAP THE THROTTLE PEDAL AT THE FULLY OPEN POSITION AFTER IT HAS BEEN DEPRESSED.THIS CAN HAPPEN REGARDLESS OF WHETHER OR NOT ANOTHER MAT (CARPET) IS UNDERNEATH.WHEN THIS OCCURS, SOME OPERATORS REACT BY APPLYING THE BRAKE PEDAL MULTIPLE TIMES, DEPLETING THE BRAKING SYSTEM'S (VACUUM BASED) POWER ASSIST.STOPPING THE VEHICLE WITH UNASSISTED BRAKING WHILE THE THROTTLE IS FULLY OPEN REQUIRES SIGNIFICANT PEDAL FORCE, WHICH SOME OPERATORS DID NOT, OR WERE UNABLE TO, APPLY FOR THE REQUIRED DURATION.CONTINUED DRIVING IN THIS CONDITION RESULTS IN OVERHEATED BRAKES, WHICH FURTHER DIMINISHES THE BRAKING EFFECTIVENESS.SOME OPERATORS ATTEMPTED TO TURN THE VEHICLE OFF BY DEPRESSING THE ENGINE CONTROL BUTTON, HOWEVER THEY WERE UNAWARE THE BUTTON HAD TO BE DEPRESSED FOR THREE SECONDS TO STOP THE ENGINE WHEN THE VEHICLE IS IN MOTION; THIS FUNCTIONALITY WAS NOT EXPLAINED ADEQUATELY IN THE OWNER'S MANUAL.IN ODI INTERVIEWS, OWNER'S REPORTED THEY WERE UNAWARE THE ALL WEATHER MAT HAD THE POTENTIAL TO INTERFERE WITH THE THROTTLE PEDAL, ADVISING THAT THIS WAS NEVER PROPERLY EXPLAINED GIVEN THE SIGNIFICANT HAZARD IT REPRESENTED.OWNERS REPORTED SEVERAL EXPLANATIONS FOR WHY THE MAT WAS UNSECURED, INCLUDING THAT THE VEHICLE WAS DELIVERED IN THIS CONDITION (MOST COMMON REASON), OR THAT THEY HAD (UNWITTINGLY) INSTALLED THE MAT THEMSELVES, OR THAT ANOTHER PARTY, SUCH AS A CAR WASH ATTENDANT, HAD DISTURBED THE MAT WITHOUT THE OWNER'S KNOWLEDGE.ONE CONSUMER REPORTED THAT THEIR VEHICLE WAS DELIVERED WITHOUT THE RETAINING DEVICES INSTALLED.IN A SEPTEMBER 26, 2007 LETTER TO NHTSA, TOYOTA INDICATED THAT THEY WOULD CONDUCT A SAFETY RECALL TO REPLACE THE ALL WEATHER MAT WITH A REDESIGNED MAT.ACCORDING TO TOYOTA, THE NEW MAT DESIGN WILL REDUCE THE POTENTIAL FOR MAT INTERFERENCE WITH THE THROTTLE PEDAL.THE POPULATION NOTED ABOVE REPRESENTS THE NUMBER OF SUBJECT MATSTHAT HAVE BEEN SOLD IN THE UNITED STATES.SINCE TOYOTA CANNOT IDENTIFY WHICH VEHICLES MAY HAVE THE SUBJECT MATS, THEY WILL SEND A LETTER TO ALL REGISTERED OWNERS OF THE SUBJECT VEHICLES (ESTIMATED 750K) ADVISING THEM OF THE CONCERN AND REMEDY.A COPY OF THAT LETTER WILL BE POSTED TO NHTSA'S WEB SITE UNDER RECALL 07E-082; IT CONTAINS A DESCRIPTION OF THE CONDITION AND THE ACTIONS AN OPERATOR SHOULD TAKE IN THE EVENT THROTTLE ENTRAPMENT OCCURS WHILE DRIVING.THE FATALITY INCIDENT NOTED ABOVE OCCURRED IN JULY 2007 AND WAS INVESTIGATED BY NHTSA'S SPECIAL CRASH INVESTIGATIONS OFFICE.IT HAS NOT BEEN REPORTED ON A VEHICLE OWNER QUESTIONNAIRE.THE OPERATOR REPORTEDLY TRAVELLED AT SPEEDS IN EXCESS OF 100 MPH FOR AN ESTIMATED EIGHT MILES ON AN INTERSTATE IN CALIFORNIA BEFORE IT STRUCK TWO OTHER VEHICLES.ONE OF THE STRUCK VEHICLES AND THE SUBJECT VEHICLE CAUGHT FIRE.THE OCCUPANT OF THE STRUCK VEHICLE DID NOT EVACULATE AND DIED AT THE SCENE.THE SUBJECT VEHICLE DRIVER SUFFERED A BROKEN BONE.THE CALIFORNIA HIGHWAY PATROL IS INVESTIGATING THE INCIDENT ALSO.ODI DID NOT ISSUE AN INFORMATION REQUEST LETTER DURING THIS INVESTIGATION.THE TOYOTA REPORTS NOTED ABOVE WERE REPORTED DURING PRELIMINARY EVALUATION PE07-016 AND ARE CURRENT THROUGH APRIL 2007 FOR MY 2007 LEXUS ES350 ONLY.ODI DOES NOT HAVE FIELD EXPERIENCE DATA FROM TOYOTA FOR CAMRY VEHICLES.THROTTLE ENTRAPMENT DUE TO IMPROPERLY INSTALLED FLOOR MATS COULD BE A CONCERN IN ALL VEHICLES.THEREFORE, DRIVERS SHOULD ALWAYS ENSURE THEIR FLOOR MATS ARE PROPERLY AND SAFELY INSTALLED.THIS INCL
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE DRIVER SIDE FLOOR MAT WILL NOT INTERFERE WITH THE THROTTLE PEDAL IF PROPERLY SECURED USING THE RETAINING HOOKS PROVIDED BY TOYOTA.HOWEVER, IF THE ALL WEATHER MAT IS UNSECURED AND MOVES FORWARD FROM ITS INTENDED POSITION IT CAN ENTRAP THE THROTTLE PEDAL AT THE FULLY OPEN POSITION AFTER IT HAS BEEN DEPRESSED.THIS CAN HAPPEN REGARDLESS OF WHETHER OR NOT ANOTHER MAT (CARPET) IS UNDERNEATH.WHEN THIS OCCURS, SOME OPERATORS REACT BY APPLYING THE BRAKE PEDAL MULTIPLE TIMES, DEPLETING THE BRAKING SYSTEM'S (VACUUM BASED) POWER ASSIST.STOPPING THE VEHICLE WITH UNASSISTED BRAKING WHILE THE THROTTLE IS FULLY OPEN REQUIRES SIGNIFICANT PEDAL FORCE, WHICH SOME OPERATORS DID NOT, OR WERE UNABLE TO, APPLY FOR THE REQUIRED DURATION.CONTINUED DRIVING IN THIS CONDITION RESULTS IN OVERHEATED BRAKES, WHICH FURTHER DIMINISHES THE BRAKING EFFECTIVENESS.SOME OPERATORS ATTEMPTED TO TURN THE VEHICLE OFF BY DEPRESSING THE ENGINE CONTROL BUTTON, HOWEVER THEY WERE UNAWARE THE BUTTON HAD TO BE DEPRESSED FOR THREE SECONDS TO STOP THE ENGINE WHEN THE VEHICLE IS IN MOTION; THIS FUNCTIONALITY WAS NOT EXPLAINED ADEQUATELY IN THE OWNER'S MANUAL.IN ODI INTERVIEWS, OWNER'S REPORTED THEY WERE UNAWARE THE ALL WEATHER MAT HAD THE POTENTIAL TO INTERFERE WITH THE THROTTLE PEDAL, ADVISING THAT THIS WAS NEVER PROPERLY EXPLAINED GIVEN THE SIGNIFICANT HAZARD IT REPRESENTED.OWNERS REPORTED SEVERAL EXPLANATIONS FOR WHY THE MAT WAS UNSECURED, INCLUDING THAT THE VEHICLE WAS DELIVERED IN THIS CONDITION (MOST COMMON REASON), OR THAT THEY HAD (UNWITTINGLY) INSTALLED THE MAT THEMSELVES, OR THAT ANOTHER PARTY, SUCH AS A CAR WASH ATTENDANT, HAD DISTURBED THE MAT WITHOUT THE OWNER'S KNOWLEDGE.ONE CONSUMER REPORTED THAT THEIR VEHICLE WAS DELIVERED WITHOUT THE RETAINING DEVICES INSTALLED.IN A SEPTEMBER 26, 2007 LETTER TO NHTSA, TOYOTA INDICATED THAT THEY WOULD CONDUCT A SAFETY RECALL TO REPLACE THE ALL WEATHER MAT WITH A REDESIGNED MAT.ACCORDING TO TOYOTA, THE NEW MAT DESIGN WILL REDUCE THE POTENTIAL FOR MAT INTERFERENCE WITH THE THROTTLE PEDAL.THE POPULATION NOTED ABOVE REPRESENTS THE NUMBER OF SUBJECT MATSTHAT HAVE BEEN SOLD IN THE UNITED STATES.SINCE TOYOTA CANNOT IDENTIFY WHICH VEHICLES MAY HAVE THE SUBJECT MATS, THEY WILL SEND A LETTER TO ALL REGISTERED OWNERS OF THE SUBJECT VEHICLES (ESTIMATED 750K) ADVISING THEM OF THE CONCERN AND REMEDY.A COPY OF THAT LETTER WILL BE POSTED TO NHTSA'S WEB SITE UNDER RECALL 07E-082; IT CONTAINS A DESCRIPTION OF THE CONDITION AND THE ACTIONS AN OPERATOR SHOULD TAKE IN THE EVENT THROTTLE ENTRAPMENT OCCURS WHILE DRIVING.THE FATALITY INCIDENT NOTED ABOVE OCCURRED IN JULY 2007 AND WAS INVESTIGATED BY NHTSA'S SPECIAL CRASH INVESTIGATIONS OFFICE.IT HAS NOT BEEN REPORTED ON A VEHICLE OWNER QUESTIONNAIRE.THE OPERATOR REPORTEDLY TRAVELLED AT SPEEDS IN EXCESS OF 100 MPH FOR AN ESTIMATED EIGHT MILES ON AN INTERSTATE IN CALIFORNIA BEFORE IT STRUCK TWO OTHER VEHICLES.ONE OF THE STRUCK VEHICLES AND THE SUBJECT VEHICLE CAUGHT FIRE.THE OCCUPANT OF THE STRUCK VEHICLE DID NOT EVACULATE AND DIED AT THE SCENE.THE SUBJECT VEHICLE DRIVER SUFFERED A BROKEN BONE.THE CALIFORNIA HIGHWAY PATROL IS INVESTIGATING THE INCIDENT ALSO.ODI DID NOT ISSUE AN INFORMATION REQUEST LETTER DURING THIS INVESTIGATION.THE TOYOTA REPORTS NOTED ABOVE WERE REPORTED DURING PRELIMINARY EVALUATION PE07-016 AND ARE CURRENT THROUGH APRIL 2007 FOR MY 2007 LEXUS ES350 ONLY.ODI DOES NOT HAVE FIELD EXPERIENCE DATA FROM TOYOTA FOR CAMRY VEHICLES.THROTTLE ENTRAPMENT DUE TO IMPROPERLY INSTALLED FLOOR MATS COULD BE A CONCERN IN ALL VEHICLES.THEREFORE, DRIVERS SHOULD ALWAYS ENSURE THEIR FLOOR MATS ARE PROPERLY AND SAFELY INSTALLED.THIS INCL
Vehicle Speed Control
THE DRIVER SIDE FLOOR MAT WILL NOT INTERFERE WITH THE THROTTLE PEDAL IF PROPERLY SECURED USING THE RETAINING HOOKS PROVIDED BY TOYOTA.HOWEVER, IF THE ALL WEATHER MAT IS UNSECURED AND MOVES FORWARD FROM ITS INTENDED POSITION IT CAN ENTRAP THE THROTTLE PEDAL AT THE FULLY OPEN POSITION AFTER IT HAS BEEN DEPRESSED.THIS CAN HAPPEN REGARDLESS OF WHETHER OR NOT ANOTHER MAT (CARPET) IS UNDERNEATH.WHEN THIS OCCURS, SOME OPERATORS REACT BY APPLYING THE BRAKE PEDAL MULTIPLE TIMES, DEPLETING THE BRAKING SYSTEM'S (VACUUM BASED) POWER ASSIST.STOPPING THE VEHICLE WITH UNASSISTED BRAKING WHILE THE THROTTLE IS FULLY OPEN REQUIRES SIGNIFICANT PEDAL FORCE, WHICH SOME OPERATORS DID NOT, OR WERE UNABLE TO, APPLY FOR THE REQUIRED DURATION.CONTINUED DRIVING IN THIS CONDITION RESULTS IN OVERHEATED BRAKES, WHICH FURTHER DIMINISHES THE BRAKING EFFECTIVENESS.SOME OPERATORS ATTEMPTED TO TURN THE VEHICLE OFF BY DEPRESSING THE ENGINE CONTROL BUTTON, HOWEVER THEY WERE UNAWARE THE BUTTON HAD TO BE DEPRESSED FOR THREE SECONDS TO STOP THE ENGINE WHEN THE VEHICLE IS IN MOTION; THIS FUNCTIONALITY WAS NOT EXPLAINED ADEQUATELY IN THE OWNER'S MANUAL.IN ODI INTERVIEWS, OWNER'S REPORTED THEY WERE UNAWARE THE ALL WEATHER MAT HAD THE POTENTIAL TO INTERFERE WITH THE THROTTLE PEDAL, ADVISING THAT THIS WAS NEVER PROPERLY EXPLAINED GIVEN THE SIGNIFICANT HAZARD IT REPRESENTED.OWNERS REPORTED SEVERAL EXPLANATIONS FOR WHY THE MAT WAS UNSECURED, INCLUDING THAT THE VEHICLE WAS DELIVERED IN THIS CONDITION (MOST COMMON REASON), OR THAT THEY HAD (UNWITTINGLY) INSTALLED THE MAT THEMSELVES, OR THAT ANOTHER PARTY, SUCH AS A CAR WASH ATTENDANT, HAD DISTURBED THE MAT WITHOUT THE OWNER'S KNOWLEDGE.ONE CONSUMER REPORTED THAT THEIR VEHICLE WAS DELIVERED WITHOUT THE RETAINING DEVICES INSTALLED.IN A SEPTEMBER 26, 2007 LETTER TO NHTSA, TOYOTA INDICATED THAT THEY WOULD CONDUCT A SAFETY RECALL TO REPLACE THE ALL WEATHER MAT WITH A REDESIGNED MAT.ACCORDING TO TOYOTA, THE NEW MAT DESIGN WILL REDUCE THE POTENTIAL FOR MAT INTERFERENCE WITH THE THROTTLE PEDAL.THE POPULATION NOTED ABOVE REPRESENTS THE NUMBER OF SUBJECT MATSTHAT HAVE BEEN SOLD IN THE UNITED STATES.SINCE TOYOTA CANNOT IDENTIFY WHICH VEHICLES MAY HAVE THE SUBJECT MATS, THEY WILL SEND A LETTER TO ALL REGISTERED OWNERS OF THE SUBJECT VEHICLES (ESTIMATED 750K) ADVISING THEM OF THE CONCERN AND REMEDY.A COPY OF THAT LETTER WILL BE POSTED TO NHTSA'S WEB SITE UNDER RECALL 07E-082; IT CONTAINS A DESCRIPTION OF THE CONDITION AND THE ACTIONS AN OPERATOR SHOULD TAKE IN THE EVENT THROTTLE ENTRAPMENT OCCURS WHILE DRIVING.THE FATALITY INCIDENT NOTED ABOVE OCCURRED IN JULY 2007 AND WAS INVESTIGATED BY NHTSA'S SPECIAL CRASH INVESTIGATIONS OFFICE.IT HAS NOT BEEN REPORTED ON A VEHICLE OWNER QUESTIONNAIRE.THE OPERATOR REPORTEDLY TRAVELLED AT SPEEDS IN EXCESS OF 100 MPH FOR AN ESTIMATED EIGHT MILES ON AN INTERSTATE IN CALIFORNIA BEFORE IT STRUCK TWO OTHER VEHICLES.ONE OF THE STRUCK VEHICLES AND THE SUBJECT VEHICLE CAUGHT FIRE.THE OCCUPANT OF THE STRUCK VEHICLE DID NOT EVACULATE AND DIED AT THE SCENE.THE SUBJECT VEHICLE DRIVER SUFFERED A BROKEN BONE.THE CALIFORNIA HIGHWAY PATROL IS INVESTIGATING THE INCIDENT ALSO.ODI DID NOT ISSUE AN INFORMATION REQUEST LETTER DURING THIS INVESTIGATION.THE TOYOTA REPORTS NOTED ABOVE WERE REPORTED DURING PRELIMINARY EVALUATION PE07-016 AND ARE CURRENT THROUGH APRIL 2007 FOR MY 2007 LEXUS ES350 ONLY.ODI DOES NOT HAVE FIELD EXPERIENCE DATA FROM TOYOTA FOR CAMRY VEHICLES.THROTTLE ENTRAPMENT DUE TO IMPROPERLY INSTALLED FLOOR MATS COULD BE A CONCERN IN ALL VEHICLES.THEREFORE, DRIVERS SHOULD ALWAYS ENSURE THEIR FLOOR MATS ARE PROPERLY AND SAFELY INSTALLED.THIS INCL