NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
9 reportsClear category filter92,000 miles · Oct 13, 2015
Engine And Engine CoolingSuspension
TL* THE CONTACT OWNS A 2009 TOYOTA CAMRY. WHILE DRIVING 35 MPH AND MAKING A RIGHT TURN, THERE WAS A LOUD SCREECHING SOUND COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. ALSO, WHILE MAKING A RIGHT TURN, THERE WAS A LOUD CLICKING SOUND. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE CV…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA CAMRY. WHILE DRIVING 35 MPH AND MAKING A RIGHT TURN, THERE WAS A LOUD SCREECHING SOUND COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. ALSO, WHILE MAKING A RIGHT TURN, THERE WAS A LOUD CLICKING SOUND. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE CV AXLE BOOT AND THE RADIATOR NEEDED TO BE REPLACED. THE REPAIRS WERE DONE; HOWEVER, THE VEHICLE STILL DROVE ROUGHLY AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10781802
136,000 miles · Feb 16, 2011
Engine And Engine CoolingFire
TL* THE CONTACT OWNS A 2006 TOYOTA CAMRY. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT SMELLED AN ABNORMAL BURNING ELECTRICAL ODOR. THE CONTACT WAS MOTIONED TO PULL OVER BY ANOTHER DRIVER BECAUSE THE VEHICLE WAS ON FIRE. THE CONTACT WAS UNINJURED. THE VEHICLE WAS TOWED BY THE CONTACTS INSURANCE COMPANY WHO DETERMINED THAT THE…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA CAMRY. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT SMELLED AN ABNORMAL BURNING ELECTRICAL ODOR. THE CONTACT WAS MOTIONED TO PULL OVER BY ANOTHER DRIVER BECAUSE THE VEHICLE WAS ON FIRE. THE CONTACT WAS UNINJURED. THE VEHICLE WAS TOWED BY THE CONTACTS INSURANCE COMPANY WHO DETERMINED THAT THE FIRE WAS CAUSED BY A SPONTANEOUS ENGINE FIRE AND NOT A MECHANICAL FAILURE. THE VEHICLE WAS DESTROYED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 136,000.
NHTSA ODI #10382955
56,609 miles · Sep 18, 2010
Engine And Engine Cooling
2006 TOYOTA CAMRY 56K MILES REGULAR SERVICE STRIPPED HEAD GASKET BOLTS CAUSE COOLANT LEAK. ONLY RECOURSE REPAIR FOR $2000 +. TOYOTA SHOULD REPAIR UNDER WARRANTY. *TR
NHTSA ODI #10356276
Mileage unknown · Jun 23, 2010
Electrical SystemEngine And Engine CoolingFire
2006 TOYOTA CAMRY. CONSUMER WRITES IN REGARDS TO A VEHICLE FIRE *TGW THE CONSUMER STATED PRIOR TO THE FIRE, THE ENGINE LIGHT ILLUMINATED. HE LOOKED OUT THE WINDOW AND SAW A WOMAN SCREAMING THAT HIS VEHICLE WAS ON FIRE. HE IMMEDIATELY PULLED OVER TO THE SHOULDER, JUMPED OUT OF THE VEHICLE AND THEN IT BURST INTO FLAMES. THE CAUS…
Read full complaint
2006 TOYOTA CAMRY. CONSUMER WRITES IN REGARDS TO A VEHICLE FIRE *TGW THE CONSUMER STATED PRIOR TO THE FIRE, THE ENGINE LIGHT ILLUMINATED. HE LOOKED OUT THE WINDOW AND SAW A WOMAN SCREAMING THAT HIS VEHICLE WAS ON FIRE. HE IMMEDIATELY PULLED OVER TO THE SHOULDER, JUMPED OUT OF THE VEHICLE AND THEN IT BURST INTO FLAMES. THE CAUSE OF THE FIRE HAD NOT BEEN DETERMINED. *JB
NHTSA ODI #10340063
2,370 miles · Mar 17, 2010
Electronic Stability Control (esc)Engine And Engine CoolingCrash
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). I PURCHASE A 2006 CAMRY IN DEC. 2005. WITHIN WEEKS THE OXYGEN SENSOR NEEDED REPLACEMENT. JAN 2006 AS I ENTERED 290W IN NORTHBORO MA THE CAR ACCELERATED FROM 10MPH TO 80 +MPH WITHOUT WARNING. AS TRAFFIC WAS BUMPER TO BUMPER THE CAR S…
Read full complaint
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). I PURCHASE A 2006 CAMRY IN DEC. 2005. WITHIN WEEKS THE OXYGEN SENSOR NEEDED REPLACEMENT. JAN 2006 AS I ENTERED 290W IN NORTHBORO MA THE CAR ACCELERATED FROM 10MPH TO 80 +MPH WITHOUT WARNING. AS TRAFFIC WAS BUMPER TO BUMPER THE CAR SLAMMED INTO THE BACK OF A SEMI TRAILER. WHEN THE CAR WAS REPAIRED OF COURSE I WAS TOLD I HAD STEPPED ON THE GAS NOT THE BRAKE. THIS WAS NOT TRUE!!! HOWEVER, HAVING NO OTHER EXPLANATION I ACCEPTED THE CAUSE. HOWEVER, AS MANY AS 2 DOZEN TIMES THE CAR ACCELERATED WHEN PARKING INTO A SPOT. I HAD BEEN INSTRUCTED TO SHIFT THE CAR INTO NEUTRAL IF THIS EVER HAPPENED AGAIN, AND I DID. I DROVE THE CAR FOR 3 YEARS, TOOK IT TO DEALERS, TRIED TO FILE A LEMON LAW COMPLAINT, BUT TO NO AVAIL. I HAVE FINALLY TRADED IN THE AUTO AND WANT TO RECOUP MY $4000.00 OF DEDUCTIBLES AND SURCHARGES THAT I PAID FOR NO FAULT OF MINE. HOW DO I DO THIS. [XXX] *TR
NHTSA ODI #10320371
14,686 miles · Feb 5, 2010
Engine And Engine Cooling
WHEN APPLYING BRAKES,ENGINE SURGES AND CONTINUES TO SURGE UNTIL BRAKES ARE RELEASED. *TR
NHTSA ODI #10306471
5,000 miles · Sep 30, 2009
Electronic Stability Control (esc)Engine And Engine CoolingEquipment Adaptive/mobilityInjury
MY 2006 CAMRY RANAWAY ON RT 290 WEST WHEN IT WAS A FEW MONTHS OLD FOLLOWING THE REPLACEMENT OF AN OXYSENDOR AND INSTALLATION OF TOYOTA FLOOR MATS. I COULD NOT STOP THE CAR AS IT ENTERED THE HIGHWAY AND THUS I REARENDED A SEMI WHO NEVER EVEN KNEW THAT I HIT HIM. YET, GREATER THAN 2000.00 OF DAMAGE HAPPENED TO MY AUTO. I HAVE P…
Read full complaint
MY 2006 CAMRY RANAWAY ON RT 290 WEST WHEN IT WAS A FEW MONTHS OLD FOLLOWING THE REPLACEMENT OF AN OXYSENDOR AND INSTALLATION OF TOYOTA FLOOR MATS. I COULD NOT STOP THE CAR AS IT ENTERED THE HIGHWAY AND THUS I REARENDED A SEMI WHO NEVER EVEN KNEW THAT I HIT HIM. YET, GREATER THAN 2000.00 OF DAMAGE HAPPENED TO MY AUTO. I HAVE PAID NEARLY 3000.00 IN PENALTIES FOR AN ACCIDENT WHICH I HAD NO CONTROL OVER. FROM THENCE, I WAS TOLD TO PUT MY CAR IN NEUTRAL WHEN I STOPPED AT LIGHTS ETC. IT TRIED TO RUNAWAY AT LEAST 20 TIMES SPORADICALLY.. I TOOK IT TO TOYOTA DEALERS WHO TOLD ME THAT NOTHING WAS WRONG WITH THE CAR. I TRIED TO FILE A LEMON LAW. IT WAS 3 YRS OF DRIVING IN ?!@#$% NEVER KNOWING WHAT COULD HAPPEN NEXT. I HAVE WITNESSES. *TR
NHTSA ODI #10285853
30,000 miles · Sep 25, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 2006 TOYOTA CAMRY. THE CONTACT STATED THAT THERE WAS A FIRE UNDER THE HOOD OF THE VEHICLE WHILE IT WAS PARKED IN THE GARAGE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WE…
Read full complaint
TL*THE CONTACT OWNS A 2006 TOYOTA CAMRY. THE CONTACT STATED THAT THERE WAS A FIRE UNDER THE HOOD OF THE VEHICLE WHILE IT WAS PARKED IN THE GARAGE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 30,000.
NHTSA ODI #10285221
73,000 miles · Jul 20, 2009
Engine And Engine Cooling
LEAKING HEAD GASKET-CAR BEGAN MAKING INTERMITTENT CLICKING NOISE. DEALER CHECKED AND SAID NOTHING TO WORRY ABOUT-PROBABLY LOOSE FUEL PUMP. THEY TIGHTENED THAT. STILL NOISE. TOOK IT BACK-"OOPS" IT'S A LEAKING HEAD GASKET THEY SAID HAD BEEN DEFECTIVE SINCE MANUFACTURE. HAD I CONTINUED TO DRIVE I COULD HAVE EXPERIENCED COMPLETE ENG…
Read full complaint
LEAKING HEAD GASKET-CAR BEGAN MAKING INTERMITTENT CLICKING NOISE. DEALER CHECKED AND SAID NOTHING TO WORRY ABOUT-PROBABLY LOOSE FUEL PUMP. THEY TIGHTENED THAT. STILL NOISE. TOOK IT BACK-"OOPS" IT'S A LEAKING HEAD GASKET THEY SAID HAD BEEN DEFECTIVE SINCE MANUFACTURE. HAD I CONTINUED TO DRIVE I COULD HAVE EXPERIENCED COMPLETE ENGINE FAILURE AT ANY SPEED. *TR
NHTSA ODI #10277455
Official recalls
5Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Nov 22, 2005
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS" THE VEHICLES' TIRE AND LOADING INFORMATION LABEL OR PLACARD ON THE DRIVER'S SIDE B-PILLAR INCORRECTLY INDICATES THE SPARE TIRE SIZE.
Consequence & remedy
Consequence: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON DECEMBER 28, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration