I OWN A 2005 TOYOTA CAMRY THAT HAS BEEN MAINTAINED TIMELY AND PROPERLY, DRIVEN PROPERLY, WASHED, WAXED, AND BASICALLY TREATED LIKE A NEW BORN BABY. MY COMPLAINT IS AS FOLLOWS: I WAS CLEANING THE INSIDE OF MY CAR AND AS I DUSTED OFF THE SPEAKER COVERS(AS I'VE DONE FOR 2 YEARS NOW), THEY BEGAN TO CRACK AND CRUMBLE INTO SMALL PIECE…
Read full complaint
I OWN A 2005 TOYOTA CAMRY THAT HAS BEEN MAINTAINED TIMELY AND PROPERLY, DRIVEN PROPERLY, WASHED, WAXED, AND BASICALLY TREATED LIKE A NEW BORN BABY. MY COMPLAINT IS AS FOLLOWS: I WAS CLEANING THE INSIDE OF MY CAR AND AS I DUSTED OFF THE SPEAKER COVERS(AS I'VE DONE FOR 2 YEARS NOW), THEY BEGAN TO CRACK AND CRUMBLE INTO SMALL PIECES. THE SMALL PIECES FELL DOWN INTO THE SPEAKERS. I NOW HAVE HOLES IN MY SPEAKER COVERS AND CANNOT RETRIEVE THE PIECES FROM THE SPEAKERS. THE SPEAKERS ARE RATTLING AND ARE DAMAGED DUE TO THE CRUMBLED SPEAKER COVER PIECES. I HAVE NEVER PLACED ANYTHING ON THE SPEAKERS OR TRAVELED WITH ANYTHING ON THE REAR DASH. I UNDERSTAND THIS MAY NOT BE VIEWED AS A SAFETY ISSUE, BUT I FEEL TOYOTA SHOULD DEEM THIS A RECALL AND BE RESPONSIBLE FOR REPLACING THE SPEAKERS AND SPEAKER COVERS AT NO CHARGE TO THE CONSUMER. THIS CANNOT BE PERCEIVED AS A CONSUMER ERROR, THIS IS A MANUFACTURING DEFECT AND THE MANUFACTURER SHOULD BE SOLELY RESPONSIBLE. OWNERS THAT BOUGHT NEW OR USED SHOULD NOT HAVE TO BEAR THE BURDEN OF REPLACING THE PARTS, DEDUCTIBLES, OR SERVICE CHARGES. *TR
NHTSA ODI #10280939
Mileage unknown · Apr 29, 2009
EquipmentStructure
2005 TOYOTA CAMRY. REAR WINDOW SPEAKER GRILLS, BOTH OF THEM. THEY ARE CRACKING AND FALLING APART EVEN THOUGH NO ONE HAS TOUCHED THEM AN NOTHING HAS BEEN PLACED ON THEM. I UNDERSTAND THIS HAS BECOME A COMMON COMPLAINT. TOYOTA SAID I WOULD HAVE TO REPLACE THE WHOLE SECTION FOR ABOUT $500 FOR PARTS. (NOT INCLUDING LABOR) BUT OTHERS…
Read full complaint
2005 TOYOTA CAMRY. REAR WINDOW SPEAKER GRILLS, BOTH OF THEM. THEY ARE CRACKING AND FALLING APART EVEN THOUGH NO ONE HAS TOUCHED THEM AN NOTHING HAS BEEN PLACED ON THEM. I UNDERSTAND THIS HAS BECOME A COMMON COMPLAINT. TOYOTA SAID I WOULD HAVE TO REPLACE THE WHOLE SECTION FOR ABOUT $500 FOR PARTS. (NOT INCLUDING LABOR) BUT OTHERS SAY THE REPLACEMENT PART FALLS APART TOO. *TR
NHTSA ODI #10267269
100,000 miles · Oct 19, 2008
Equipment
2005 TOYOTA CAMRY. REAR WINDOW SPEAKER GRILLS, BOTH OF THEM. THEY ARE CRACKING AND FALLING APART EVEN THOUGH NO ONE HAS TOUCHED THEM AN NOTHING HAS BEEN PLACED ON THEM. I UNDERSTAND THIS HAS BECOME A COMMON COMPLAINT. TOYOTA SAID I WOULD HAVE TO REPLACE THE WHOLE SECTION FOR ABOUT $500 FOR PARTS. (NOT INCLUDING LABOR) BUT OT…
Read full complaint
2005 TOYOTA CAMRY. REAR WINDOW SPEAKER GRILLS, BOTH OF THEM. THEY ARE CRACKING AND FALLING APART EVEN THOUGH NO ONE HAS TOUCHED THEM AN NOTHING HAS BEEN PLACED ON THEM. I UNDERSTAND THIS HAS BECOME A COMMON COMPLAINT. TOYOTA SAID I WOULD HAVE TO REPLACE THE WHOLE SECTION FOR ABOUT $500 FOR PARTS. (NOT INCLUDING LABOR) BUT OTHERS SAY THE REPLACEMENT PART FALLS APART TOO. *TR
NHTSA ODI #10246027
Mileage unknown · Sep 17, 2008
EquipmentTires
TL*THE CONTACT OWNS A 2005 TOYOTA CAMRY. THE VEHICLE HAS TECH INTERNATIONAL VALVE STEMS, MODEL TR413. THE CONTACT STATED THAT TWO TIRES WERE FLATTENED DUE TO VALVE STEM FAILURE. HE TOOK THE VEHICLE TO THE REPAIR SHOP AND THE VALVE STEMS WERE REPLACED. THE SERIAL AND PART NUMBERS WERE UNKNOWN. THE FAILURE MILEAGE WAS 71,000 …
Read full complaint
TL*THE CONTACT OWNS A 2005 TOYOTA CAMRY. THE VEHICLE HAS TECH INTERNATIONAL VALVE STEMS, MODEL TR413. THE CONTACT STATED THAT TWO TIRES WERE FLATTENED DUE TO VALVE STEM FAILURE. HE TOOK THE VEHICLE TO THE REPAIR SHOP AND THE VALVE STEMS WERE REPLACED. THE SERIAL AND PART NUMBERS WERE UNKNOWN. THE FAILURE MILEAGE WAS 71,000 AND CURRENT MILEAGE WAS 72,000. UPDATED 10/16/08.*LJ UPDATED 10/17/08. *JB
NHTSA ODI #10242686
28,000 miles · Sep 15, 2008
Equipment
JUST PRIOR TO END OF 36 MONTH WARRANTY REAR SPEAKER COVERS DISINTEGRATED, AT THE SAME TIME DAMAGING THE SPEAKERS. BOTH WERE REPLACED UNDER WARRANTY. *TR
NHTSA ODI #10242227
Mileage unknown · Sep 11, 2008
Equipment
THE REAR SPEAKER COVERS ON MY 2005 TOYOTA CAMRY DISINTEGRATED. THERE ARE HUNDREDS OF OTHER 2003-2005 CAMRY OWNERS REPORTING THE SAME PROBLEM. INITIALLY YOU SEE CRACKS ON THE SPEAKER COVERS, BUT WHEN YOU TOUCH THEM THE PLASTIC LITERALLY CRUMBLES INTO DUST AND FALLS INTO THE SPEAKER CONE. TOYOTA IS AWARE OF THE PROBLEM AND REVI…
Read full complaint
THE REAR SPEAKER COVERS ON MY 2005 TOYOTA CAMRY DISINTEGRATED. THERE ARE HUNDREDS OF OTHER 2003-2005 CAMRY OWNERS REPORTING THE SAME PROBLEM. INITIALLY YOU SEE CRACKS ON THE SPEAKER COVERS, BUT WHEN YOU TOUCH THEM THE PLASTIC LITERALLY CRUMBLES INTO DUST AND FALLS INTO THE SPEAKER CONE. TOYOTA IS AWARE OF THE PROBLEM AND REVISED THEIR PARTS POLICY; BEFORE THEY ONLY SOLD COMPLETE SPEAKER & COVER KIT FOR AROUND $600, NOW THEY SELL COVERS ONLY FOR $25. HOWEVER, THE PROCEDURE TO INSTALL THEM IS LABOR INTENSIVE AND PEOPLE REPORT BEING CHARGED $100-$250 FOR LABOR. MY LOCAL DEALER WANTED $100. THE CAR IS A COUPLE OF MONTHS OUT OF WARRANTY. THIS SHOULD BE A RECALL. *TR
NHTSA ODI #10241900
55,953 miles · Aug 19, 2008
EquipmentStructure
REAR SPEAKER COVERS CRACKED AND FELL APART WHEN TOUCHED. *TR
NHTSA ODI #10238880
48,000 miles · Aug 11, 2008
Equipment
BACK SPEAKERS FALL APART AFTER TWO YEARS AND COST $500.00 TO REPLACE. *TR
NHTSA ODI #10237704
25,000 miles · Aug 6, 2008
Equipment
REAR SPEAKER COVERS BECOME BRITTLE AND FAIL AFTER 2 YRS OF USE, DAMAGE SPEAKERS AND REQUIRE REPLACEMENT AT A COST OF OVER $500. NOT COVERED UNDER WARRANTY. *TR
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A FRONT PASSENGER POWER SEAT, WHEN INSTALLING CERTAIN REAR-FACING INFANT CHILD SEAT BASES ONTO THE SEAT WITH AN EXCESSIVELY HIGH SEATBELT TENSION, IT MAY BE POSSIBLE TO UNSEAT A COMPONENT CALLED THE BUCKLE STATUS SWITCH FROM THE SEAT BELT BUCKLE.
Consequence & remedy
Consequence: IF THE SWITCH BECOMES UNSEATED, THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM MAY MISTAKE THE REAR-FACING CHILD RESTRAINT FOR AN UNBELTED ADULT OCCUPANT, AND MAY NOT SUPPRESS THE DEPLOYMENT OF THE FRONT PASSENGER AIRBAG.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SEATBELT BUCKLE STATUS SWITCH. THIS SAFETY IMPROVEMENT CAMPAIGN (SSC 40M) BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987..
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
Illustration