NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
79 reportsClear category filter25,000 miles · Sep 22, 2017
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2004 TOYOTA CAMRY. WHILE DRIVING APPROXIMATELY 2 MPH AND ATTEMPTING TO MAKE A LEFT TURN, A TRUCK STRUCK THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DAMAGED AND TOWED TO A…
Read full complaint
TL* THE CONTACT OWNS A 2004 TOYOTA CAMRY. WHILE DRIVING APPROXIMATELY 2 MPH AND ATTEMPTING TO MAKE A LEFT TURN, A TRUCK STRUCK THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DAMAGED AND TOWED TO A POLICE IMPOUND. THE VEHICLE WAS NOT TOTALED. THE VEHICLE WAS RETRIEVED BY THE INSURANCE COMPANY. THE CONTACT WAS NOT SURE IF THE DEALER AND MANUFACTURER WERE CONTACTED. APPROXIMATELY EIGHT MONTHS LATER, WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT ATTEMPTED TO AVOID BEING STRUCK BY ANOTHER VEHICLE, LOST CONTROL, DROVE ACROSS FOUR LANES, AND CRASHED INTO A DITCH. THE CONTACT STATED THAT NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DAMAGED AND WAS TOWED TO A POLICE IMPOUND. THE VEHICLE WAS RETRIEVED BY THE INSURANCE COMPANY. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000.
NHTSA ODI #11025100
Mileage unknown · Aug 1, 2017
Air BagsUnknown Or Other
I HAVE A 2004 TOYOTA SOLARA, DASH IS CRACKED AND STICKY RIGHT WHERE AIRBAG IS. I CALLED TOYOTA AND ASK BECAUSE I WAS TOLD THAT THEY WERE FIXING THIS DEFAULT. I NEVER RECEIVED NOTICE OF THESE FIXES. I CALLED TOYOTA AND THEY REFUSED TO HELP OR ANSWER WHY I NEVER RECEIVED NOTICE OF THESE FIXES. THEY ARE REFUSING ANY HELP. I PURCHAS…
Read full complaint
I HAVE A 2004 TOYOTA SOLARA, DASH IS CRACKED AND STICKY RIGHT WHERE AIRBAG IS. I CALLED TOYOTA AND ASK BECAUSE I WAS TOLD THAT THEY WERE FIXING THIS DEFAULT. I NEVER RECEIVED NOTICE OF THESE FIXES. I CALLED TOYOTA AND THEY REFUSED TO HELP OR ANSWER WHY I NEVER RECEIVED NOTICE OF THESE FIXES. THEY ARE REFUSING ANY HELP. I PURCHASED THIS CAR NEW AND IT HAS LESS THEN A 100,000 MILE. REP VERY RUDE AND REFUSED TO GIVE ME HER NAME AND REFUSED TO GIVE ME HER MANAGER. PLEASE HELP I AM DISABLE AND NEED MY CAR. THEY NEVER SENT ME ANY NOTICE OF FIXING THESE PROBLEMS. CRACK IS SO CLOSE TO WERE AIRBAG IS AND SHE SAID NOT HER PROBLEM. PLEASE HELP!
NHTSA ODI #11012049
Mileage unknown · Jun 23, 2017
Air BagsVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNED A 2004 TOYOTA CAMRY. AFTER THE CONTACT PLACED THE VEHICLE IN REVERSE, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE CRASHED INTO A FENCE AND A BUILDING. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT INJURED HER BACK AND UPPER NECK, WHICH REQUIRED MEDICAL ATTENTIO…
Read full complaint
TL* THE CONTACT OWNED A 2004 TOYOTA CAMRY. AFTER THE CONTACT PLACED THE VEHICLE IN REVERSE, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE CRASHED INTO A FENCE AND A BUILDING. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT INJURED HER BACK AND UPPER NECK, WHICH REQUIRED MEDICAL ATTENTION. THE CONTACT'S NECK INJURY WAS DIAGNOSED AS AN UPPER SPRAIN. THE VEHICLE WAS TOWED TO AN UNKNOWN LOCAL DEALER WHERE IT WAS DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11000891
104,000 miles · Mar 3, 2017
Air BagsUnknown Or Other
TOP OF DASHBOARD AROUND PASSENGER SIDE AIRBAG IS SPLITTING OPEN. OTHER TOYOTA;S FROM THE SAME YEAR HAVE A DASHBOARD FIX THRU TOYOTA. NOT CAMRY'S. CONCERNED THAT AIRBAG MAY NOT WORK CORRECTLY. OR COME OUT OF DASHBOARD.
NHTSA ODI #10958411
200,000 miles · Nov 9, 2016
Air BagsCrashInjury
I WAS TRAVELING AT A RATE OF 30 MPH AND FAILED TO STOP AT A TRAFFIC LIGHT HITTING AN EQUINOX. MY TOYOTA CAMRY AIRBAG DID NOT DEPLOY AND I HAVE MULTIPLE CHEST WALL INJURIES FROM HITTING THE STEERING WHEEL. BOTH AIRBAGS DEPLOYED IN THE EQUINOX.
NHTSA ODI #10925159
174,000 miles · Sep 29, 2016
Air Bags
NOTICED SLIGHT SWELLING OF THE PASSENGER SIDE AIRBAG OVER A PERIOD OF A FEW MONTHS. APPEARED THAT THE UPPER SEAM OF THE COVER WAS WIDENING. YESTERDAY WHEN DRIVING HOME NOTICED IT APPEARED LARGER THAN USUAL. UPON GETTING HOME TOO A PICTURE, AS THE AIRBAG SEAM HAD BEGUN TO SPLIT AND CAN SEE A RED FOAM LIKE SUBSTANCE THROUGH THE…
Read full complaint
NOTICED SLIGHT SWELLING OF THE PASSENGER SIDE AIRBAG OVER A PERIOD OF A FEW MONTHS. APPEARED THAT THE UPPER SEAM OF THE COVER WAS WIDENING. YESTERDAY WHEN DRIVING HOME NOTICED IT APPEARED LARGER THAN USUAL. UPON GETTING HOME TOO A PICTURE, AS THE AIRBAG SEAM HAD BEGUN TO SPLIT AND CAN SEE A RED FOAM LIKE SUBSTANCE THROUGH THE SPLIT. CALLED LOCAL TOYOTA DEALERSHIP AND INDIVIDUAL I SPOKE WITH WAS VAGUE, HAD NEVER HEARD OF ANYTHING SIMILAR OR ANY AIRBAG RECALLS WITH TOYOTA. SEEMED DISTRACTED AND RUSHED, ALTHOUGH IT WAS ABOUT AN HOUR TIL THEIR OFFICIAL CLOSING TIME. PROCEEDED TO CALL TOYOTA CUSTOMER SERVICE. SPOKE WITH A VERY NICE AGENT WHO SEARCHED FOR RECALLS BASED ON MY VIN NUMBER. SHE CAME UP WITH NO RECALLS BUT EXPRESSED SIMILAR CONCERNS AS MYSELF OF THE AIRBAG DEPLOYING AND CAUSING INJURY OR ACCIDENT. SHE ASSIGNED ME A CASE NUMBER BUT ADVISED ME TO HAVE IT LOOKED AT AT A TOYOTA DEALERSHIP. AFTER RESEARCHING ONLINE, IT SEEMS LIKE A PROBLEM THAT MANY HAVE NOTED...SAME DESCRIPTION AND VERY SIMILAR PICTURES.
NHTSA ODI #10910511
54,608 miles · Aug 16, 2016
Air BagsVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNED A 2004 TOYOTA CAMRY. AFTER PARKING THE VEHICLE, IT SUDDENLY ACCELERATED WITHOUT WARNING AND CRASHED INTO A GARAGE. THE AIR BAGS FAILED TO DEPLOY. THE PASSENGER SUSTAINED CHEST CONTUSIONS, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE MANUFACTURE…
Read full complaint
TL* THE CONTACT OWNED A 2004 TOYOTA CAMRY. AFTER PARKING THE VEHICLE, IT SUDDENLY ACCELERATED WITHOUT WARNING AND CRASHED INTO A GARAGE. THE AIR BAGS FAILED TO DEPLOY. THE PASSENGER SUSTAINED CHEST CONTUSIONS, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 54,608. UPDATED 01/05/17*LJ
NHTSA ODI #10896232
60,000 miles · Jun 23, 2016
Air Bags
TAKATA AIR BAG. AIRBAG SECTION ON DASHBOARD HAS AN OILY RING AROUND IT AND SEEMS TO BE DISTORTED IN APPEARENCE.
NHTSA ODI #10876237
68,000 miles · Mar 7, 2016
Air Bags
OFF LIGHT FOR PASSENGER AIR BAG STAYS ON. IT WAS RESET A YEAR AGO AND WITHIN THREE MONTHS WENT BACK ON. THE MECHANICS SAID THAT THE SEAT OCCUPANCY SENSOR NEEDS TO BE REPLACED WHICH FOR PART HE QUOTED $431.50 AND WITH LABOR WOULD COST TOTAL OF $640.00. IS THERE A RECALL FOR THIS. THE CAR IS U AROUND 95,000 MILES AND IT NEEDS ROBE…
Read full complaint
OFF LIGHT FOR PASSENGER AIR BAG STAYS ON. IT WAS RESET A YEAR AGO AND WITHIN THREE MONTHS WENT BACK ON. THE MECHANICS SAID THAT THE SEAT OCCUPANCY SENSOR NEEDS TO BE REPLACED WHICH FOR PART HE QUOTED $431.50 AND WITH LABOR WOULD COST TOTAL OF $640.00. IS THERE A RECALL FOR THIS. THE CAR IS U AROUND 95,000 MILES AND IT NEEDS ROBE FIXED FOR MY CAR INSPECTION?
NHTSA ODI #10840407
Mileage unknown · Feb 22, 2016
Air BagsSeat BeltsCrashInjury
TL* THE CONTACT OWNS A 2004 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, ANOTHER VEHICLE CRASHED INTO THE REAR END OF THE VEHICLE. THE CONTACT MENTIONED THAT THE AIR BAGS FAILED TO DEPLOY HOWEVER, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE SEAT BELT FAILED TO RETRACT AND CAU…
Read full complaint
TL* THE CONTACT OWNS A 2004 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, ANOTHER VEHICLE CRASHED INTO THE REAR END OF THE VEHICLE. THE CONTACT MENTIONED THAT THE AIR BAGS FAILED TO DEPLOY HOWEVER, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE SEAT BELT FAILED TO RETRACT AND CAUSED THE CONTACT'S PREGNANT BELLY TO ENCOUNTER THE STEERING WHEEL. A POLICE REPORT WAS FILED. THE CONTACT AND THE FRONT SEAT PASSENGER SUSTAINED MUSCLE INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10837410
Official recalls
3Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A FRONT PASSENGER POWER SEAT, WHEN INSTALLING CERTAIN REAR-FACING INFANT CHILD SEAT BASES ONTO THE SEAT WITH AN EXCESSIVELY HIGH SEATBELT TENSION, IT MAY BE POSSIBLE TO UNSEAT A COMPONENT CALLED THE BUCKLE STATUS SWITCH FROM THE SEAT BELT BUCKLE.
Consequence & remedy
Consequence: IF THE SWITCH BECOMES UNSEATED, THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM MAY MISTAKE THE REAR-FACING CHILD RESTRAINT FOR AN UNBELTED ADULT OCCUPANT, AND MAY NOT SUPPRESS THE DEPLOYMENT OF THE FRONT PASSENGER AIRBAG.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SEATBELT BUCKLE STATUS SWITCH. THIS SAFETY IMPROVEMENT CAMPAIGN (SSC 40M) BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987..
Jul 13, 2004
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SHIELD AIR BAGS (CSA), ONE OR BOTH OF THE CURTAIN AIR BAGS MAY BE TWISTED NEAR THE INFLATOR DUE TO IMPROPER ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CSA MAY NOT DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE CSAS AND REPLACE THE AIR BAG ASSEMBLY IF NECESSARY. THE RECALL BEGAN ON AUGUST 6, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
Illustration