IllustrationI PUT MY SUNVISOR DOWN TO BLOCK THE LATE AFTERNOON SUN. AFTER I PUT IT BACK UP, IT DROPPED IN FRONT OF MY VISION CAUSING A DANGEROUS CONDITION. THE CAR IS A 2008 TOYOTA CAMRY, PURCHASED NEW WITH 54,000 MILES ON IT. I GOOGLED MY ISSUE AND SAW DOZENS OF OTHERS WITH THE EXACT SAME DEFECT. *TR
2008 Toyota Camry Hybrid
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry Hybrid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
2025–50K
3750–75K
3175–100K
23100–150K
13150K+
137 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports2 fire reports6 injury reports
What owners actually said
162 reports4.20.2010 SAT .930PM DRY CLEAR ROADS 40MPH NIGHT. FRONT END HIT A RESIDENTIAL PARKED CAR. AIR BAGS DEPLOYED AT WHEEL AND KNEE. IT WAS 75 DEGREES I HAD ON SHORTS /SANDALS.I CALLED 911 EMTS ARRIVED I WAS CRYING WITH COMPLAINTS OF FIRE FEELING IN MY LEGS FROM THE AIRBAG AND I WENT TO ER COMPLAINED OF FIRE FEELING. ENDED UP WITH FR…
Read full complaint
4.20.2010 SAT .930PM DRY CLEAR ROADS 40MPH NIGHT. FRONT END HIT A RESIDENTIAL PARKED CAR. AIR BAGS DEPLOYED AT WHEEL AND KNEE. IT WAS 75 DEGREES I HAD ON SHORTS /SANDALS.I CALLED 911 EMTS ARRIVED I WAS CRYING WITH COMPLAINTS OF FIRE FEELING IN MY LEGS FROM THE AIRBAG AND I WENT TO ER COMPLAINED OF FIRE FEELING. ENDED UP WITH FRACTURED RIGHT PINKY AREA FROM STEERING WHEEL AIR BAG DEPLOYMENT FOR SOME REASON; I LEFT HOSPITAL STILL WITH BURNING FEELING IN LEFT LEG. IN ER TWO HOURS, TOOK XRAYS FOUND NOTHING ELSE WRONG JUST SEVERE CONTUSION TO BOTH LEGS. NO CUTS. LEGS WERE BLACK, RED PURPLE FROM TOES TO THIGHS. BY TIME L GOT HOME 4 HOURS FROM TIME OF MVA OCCURRENCE. I RESTED. BY MONDAY I HAD WATER LIKE BLISTERS APPEAR ON LEFT CALF . I POPPED ONE AS THERE WERE A FEW AND ANOTHER BLISTER GREW DEEPER FROM THAT LAYER.EVENTUALLY LARGE AREA APPROXIMATELY 10 IN LONG BY 6 INCHES WIDE WAS FILLED WITH BLISTERS I GAUZE WRAPPED. IT. SAW DOCTOR WED. TOOK OFF GAUZE FROM BLISTERED AREA WE WERE SHOCKED ALL SURFACE SKIN & FEW LAYERS DEEP GONE! EATEN AWAY LIKE ACID. I AM SURE 100% AIRBAG POWDER. POWDER SOAKED IN AT IMPLOSION AND ATE ITS WAY OUT! I NEVER KNEW POWDER IN "AIR" BAGS. AT ER NO ONE TOLD ME TO CLEANSE LEGS. SAID REST KEEP LEGS UP. STAFF DID NOT KNOW TO CLEANSE AFFECTED THAT COME IN CONTACT WITH AIRBAG & SKIN. STAYED IN BED SORE FOR DAYS. WENT TO WOUND CARE DOC & SKIN CONTINUED DESINTEGRATE APRIL 20 2010 EMERGENCY SURGERY REMOVE NECROTIC AREA. NOT HEALING .GRAFT JULY 2010 NOT HEALING .AUG 31 TOOK LAST BANDAGE OFF . HUGE UGLY SCAR, CHUNK OF CALF MISSING/DEFORMITY NOW. AIR BAG POWDER LIKE CAUSTIC ACID. MANY PEOPLE SAY THEY HAD BLISTERS TOO. LAWYERS TOO SAID SAME. MOST PEOPLE CARS ARE GONE BEFORE CAN INVESTIGATE I STILL HAVE CAR UNTIL 2/1/2011. I HAVE KEPT AIRBAGS STERILE STORAGE. [XXX]..MANY PHOTOS OF DAMAGE TO ME & CAR .PUT VISOR CAUTION! I WANT CLASS SUIT ACTION AGAINST AIR BAG MANUFACTURERS. I AM RUINED. I LOVED MY GREEN CAMRY HYBRID! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F
AIR BAGS FAILED TO DEPLOY. THE VEHICLE (2008 TOYOTA CAMRY HYBRID), WAS INVOLVED IN A FRONT END COLLISION WHICH RESULTED IN SEVERE FRONT END DAMAGE TO THE POINT THAT DOORS COULD NOT BE OPENED. NONE OF THE AIR BAGS DEPLOYED, INCLUDING BY THE KNEES, EVEN THOUGH COLLISION WAS HARD ENOUGH TO RESULT IN THE DRIVER HITTING THE DASH WI…
Read full complaint
AIR BAGS FAILED TO DEPLOY. THE VEHICLE (2008 TOYOTA CAMRY HYBRID), WAS INVOLVED IN A FRONT END COLLISION WHICH RESULTED IN SEVERE FRONT END DAMAGE TO THE POINT THAT DOORS COULD NOT BE OPENED. NONE OF THE AIR BAGS DEPLOYED, INCLUDING BY THE KNEES, EVEN THOUGH COLLISION WAS HARD ENOUGH TO RESULT IN THE DRIVER HITTING THE DASH WITH KNEES. ALL THE OFFICERS TAKING REPORTS ALONG WITH THE VARIOUS TOW TRUCK DRIVERS WERE SHOCKED TO SEE NO AIR BAG DEPLOYMENT DUE TO THE FORCE OF THE COLLISION AND SEVERE DAMAGE TO FRONT OF VEHICLE, ENGINE COMPARTMENT, AND FRAME. *TR
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY HYBRID. THE CONTACT WAS SITTING AT A STOP WITH THE BRAKES DEPRESSED. THE CONTACT SHIFTED INTO REVERSE AND THE VEHICLE ABNORMALLY ACCELERATED AND CRASHED INTO A BUILDING. THE FRONT PASSENGER SIDE OF THE VEHICLE WAS DAMAGED. THE CONTACT STATED THAT HER NECK WAS BRUISED FROM THE SEAT BELT WH…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY HYBRID. THE CONTACT WAS SITTING AT A STOP WITH THE BRAKES DEPRESSED. THE CONTACT SHIFTED INTO REVERSE AND THE VEHICLE ABNORMALLY ACCELERATED AND CRASHED INTO A BUILDING. THE FRONT PASSENGER SIDE OF THE VEHICLE WAS DAMAGED. THE CONTACT STATED THAT HER NECK WAS BRUISED FROM THE SEAT BELT WHEN THE VEHICLE JERKED FORWARD. THE FRONT AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 10,500. UPDATED 12/14/2011 *CN THE CONSUMER STATED THE VEHICLE ACCELERATED FORWARD WITH GREAT SPEED, WHILE THE VEHICLE WAS IN REVERSE. UPDATED 04/28/11
2008 TOYOTA CAMRY HYBRID. CONSUMER STATES PROBLEM WITH BRAKE RESPONSE *TGW THE CONSUMER EXPERIENCED SUDDEN ACCELERATION WHILE ATTEMPTING TO PARK, WHICH ULTIMATELY CAUSED SIGNIFICANT DAMAGE TO TWO VEHICLES. THE CONSUMER TRIED REPEATEDLY TO APPLY THE BRAKES TO STOP THE VEHICLE, BUT TO NO AVAIL. THE CONSUMER ALSO HIT A PEDESTRIA…
Read full complaint
2008 TOYOTA CAMRY HYBRID. CONSUMER STATES PROBLEM WITH BRAKE RESPONSE *TGW THE CONSUMER EXPERIENCED SUDDEN ACCELERATION WHILE ATTEMPTING TO PARK, WHICH ULTIMATELY CAUSED SIGNIFICANT DAMAGE TO TWO VEHICLES. THE CONSUMER TRIED REPEATEDLY TO APPLY THE BRAKES TO STOP THE VEHICLE, BUT TO NO AVAIL. THE CONSUMER ALSO HIT A PEDESTRIAN. (DAUGHTER WROTE IN ON BEHALF OF HER 83 YEAR MOTHER WHO WAS DRIVING THE VEHICLE). *JB THE CONSUMERS DAUGHTER THERE WAS NO FLOOR MAT PRESENT IN THE VEHICLE, SO THAT WAS NOT THE ISSUE. UPDATED 06/09/10.*JB
LTR FWD FM (WI) RE TOYOTA VEHICLES INCIDENTS OF SUDDEN UNINTENDED ACCELERATION FM OWNER OF A 2008 TOYOTA CAMRY CONCERNED FOR SAFETY WHILE DRIVING VEHICLE. *TGW
2008 TOYOTA CAMRY HYBRID INCLUDED IN THE FLOOR MAT RECALL. *KB THE CONSUMER STATED WHEN HE CONTACTED THE DEALER TO MAKE AN APPOINTMENT TO HAVE THE RECALL TAKEN CARE OF, HE WAS INFORMED THAT TOYOTA WAS ONLY PROVIDING SUFFICIENT PARTS TO THE DEALER TO PERFORM 10 VEHICLES PER DAY. AS A RESULT, THE CONSUMERS APPOINTMENT WAS IN 13 …
Read full complaint
2008 TOYOTA CAMRY HYBRID INCLUDED IN THE FLOOR MAT RECALL. *KB THE CONSUMER STATED WHEN HE CONTACTED THE DEALER TO MAKE AN APPOINTMENT TO HAVE THE RECALL TAKEN CARE OF, HE WAS INFORMED THAT TOYOTA WAS ONLY PROVIDING SUFFICIENT PARTS TO THE DEALER TO PERFORM 10 VEHICLES PER DAY. AS A RESULT, THE CONSUMERS APPOINTMENT WAS IN 13 DAYS.
LTR FWD FM (MD) OWNER OF A 2008 TOYOTA CAMRY HYBRID CONCERNED THAT HER VEHICLE IS NOT INCLUDED IN THE TOYOTA VOLUNTARY RECALL. *TGW THE CONSUMER STATED SINCE TOYOTA DOES NOT KNOW THE CAUSE OF THE SUDDEN ACCELERATION, SHE BELIEVED THAT ALL OF THE POTENTIALLY AFFECTED VEHICLES WITH ELECTRONIC SYSTEMS THAT CONTROL ACCELERATION AN…
Read full complaint
LTR FWD FM (MD) OWNER OF A 2008 TOYOTA CAMRY HYBRID CONCERNED THAT HER VEHICLE IS NOT INCLUDED IN THE TOYOTA VOLUNTARY RECALL. *TGW THE CONSUMER STATED SINCE TOYOTA DOES NOT KNOW THE CAUSE OF THE SUDDEN ACCELERATION, SHE BELIEVED THAT ALL OF THE POTENTIALLY AFFECTED VEHICLES WITH ELECTRONIC SYSTEMS THAT CONTROL ACCELERATION AND BRAKING SHOULD BE RECALLED. *JB
I WAS DRIVING MY 2008 TOYOTA CAMRY HYBRID ON A MULTI LANE HIGHWAY AT ABOUT 60 MPH, WHEN THE CAR JERKED, ALL INDICATOR LIGHTS CAME ON AND THE ENGINE BECAME COMPLETELY UNRESPONSIVE. I PUSHED THE ACCELERATOR PEDAL TO TRY TO MANEUVER TO THE SHOULDER AND THERE WAS NO RESPONSE (NO ENGINE REV., NO ACCELERATION). I MANAGED TO GET THE…
Read full complaint
I WAS DRIVING MY 2008 TOYOTA CAMRY HYBRID ON A MULTI LANE HIGHWAY AT ABOUT 60 MPH, WHEN THE CAR JERKED, ALL INDICATOR LIGHTS CAME ON AND THE ENGINE BECAME COMPLETELY UNRESPONSIVE. I PUSHED THE ACCELERATOR PEDAL TO TRY TO MANEUVER TO THE SHOULDER AND THERE WAS NO RESPONSE (NO ENGINE REV., NO ACCELERATION). I MANAGED TO GET THE CAR TO THE SHOULDER AND UPON RESTART, THE CAR DROVE HESITANTLY. I MADE IT TO A TOYOTA DEALERSHIP THAT NIGHT WITH ALL INDICATOR LIGHTS STILL LIT UP. THE NEXT DAY AS THEY BEGAN TO LOOK AT THE CAR, THEY COULD FIND NO STORED COMPUTER CODE FOR THE PROBLEM AND UPON DRIVING THE CAR, IT DROVE NORMALLY. AS A RESULT, THEY COULD NOT FIGURE OUT THE PROBLEM AND HAVE FIXED NOTHING. A TOYOTA SERVICE TECH ALSO LOOKED AT THE CAR WITH THE SAME RESULT. I NOW AM BEING FORCED TO PICK UP MY CAR UNREPAIRED. AS I LISTENED TO THE NEWS LAST EVENING (MARCH 18, 2010), THEY REPORTED ON A PROBLEM WITH THE EVM MODULE IN TOYOTA COROLLA'S. THIS PROBLEM SOUNDS VERY SIMILAR. *TR
MY CAR ACCELERATED FOR ABOUT 2 SECONDS. I HAVE A CAMRY HYBRID WHICH WAS NOT RECALLED BUT FIXED ANYWAY. *TR
Official recalls
212V491000 · Visibility:power Window Devices And Controls
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE14001 · Brake Actuator Malfunction
Opened Jan 23, 2014 · Closed Aug 22, 2014
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Air:supply:reservoir/tank; Service Brakes, Electric; Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Additional source detail variants (4)
Service Brakes, Air:supply:reservoir/tank
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Electric
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.