Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports2 fire reports6 injury reports

Electronic Stability Control (esc) complaints

14 reports

Clear category filter

182,450 miles · Dec 14, 2017

Electronic Stability Control (esc)Service Brakes

BRAKE LIGHT CAME ON, THEN SUDDEN POWER BRAKING SYSTEM FAILURE WHILE DRIVING ON A TWO LANE BUSY ROAD AT A CURVE, THERE WAS A DING SOUND, THEN SIMULTANEOUSLY, A VSC WARNING MESSAGE AND MULTIPLE WARNING LIGHTS ILLUMINATED. ONLY MANUAL BRAKING ALLOWED STOPPAGE OF VEHICLE. EXTREMELY DANGEROUS SITUATION THAT COULD HAVE HAD TRAGIC …

Read full complaint

NHTSA ODI #11054662

168,000 miles · Nov 13, 2017

Electronic Stability Control (esc)Service BrakesVehicle Speed Control

Read full complaint

FOR SEVERAL MONTHS, THE CRUISE CONTROL HAD ONLY BEEN WORKING INTERMITTENTLY AND MY BRAKES SEEMED ROUGH. THE NIGHT BEFORE I BROUGHT MY CAR IN, ALL THE LIGHTS ON THE INSTRUMENT PANEL CAME ON. ON AUG 1, 2017, I GOT A DIAGNOSTIC AND IT WAS THE ABS ACTUATOR, BUT I WAS TOLD I ALSO NEEDED A BRAKE JOB AND AN ALIGNMENT SO I WENT AHEAD WITH THAT $1,000 JOB. THEY COULD NOT DIAGNOSE THE CRUISE CONTROL SINCE IT WAS "FUNCTIONING" AT THE TIME. I HAD ALREADY REPLACED THE ABS SYSTEM IN 2013 AND WAS TOLD THAT I MAY APPLY FOR A REIMBURSEMENT FOR THAT $3,600 JOB, BUT I AM NOW OUT OF THE EXTENDED WARRANTY/SERVICE CAMPAIGN SO I COULD NOT GET REIMBURSED FOR THE CURRENT ABS FAILURE REPLACEMENT. AFTER MY BRAKE JOB AND ALIGNMENT, THE ROUGHNESS DID NOT SEEM TO IMPROVE AND THE CRUISE CONTROL CONTINUED TO MALFUNCTION. FOOLISHLY, I RATIONALIZED THAT THE BRAKES NEEDED TO BE WORN IN, BUT SOON MY CAR STARTED WITH A HIGH PITCHED NOISE AS I GOT IN AND OUT OF THE VEHICLE. THE BRAKES ALSO SEEMED TO "SLIP" SOMETIMES WHEN INITIALLY STARTING THE CAR. (FOOT ON BRAKE, START CAR, PUT INTO DRIVE, AND CAR WOULD START TO ROLL UNTIL I TOOK MY FOOT OFF THE BRAKE THEN REAPPLIED IT.) I WENT BACK TO TOYOTA HOPING FOR A MIRACLE AND THEY AGAIN SAID YOU HAVE TO REPLACE THE ABS, BUT THE SERVICE CAMPAIGN HAD NOT BEEN RE-EXTENDED AND I WAS UNABLE TO AFFORD ANOTHER $3,600. SO I CONTINUED TO DRIVE MY FAULTY VEHICLE OUT OF NECESSITY. ON OCTOBER 12, 2017, THE CAR BEGAN THE HIGH PITCHED NOISE AND THIS TIME IT DIDN'T STOP. I BEGAN DRIVING IN THE PARKING LOT SLOWLY (20 MPH) AND THEN THE BRAKES FAILED. WAS ABLE TO STOP BY PRESSING VERY HARD ON THE BRAKES. SINCE THAT DAY MY CAR HAS BEEN SITTING AT MY WORKPLACE UNUSED. OBVIOUSLY, THE ABS SYSTEM THAT WAS REPLACED IN 2013 (STILL AWAITING REIMBURSEMENT) WAS REPLACED WITH ANOTHER BAD SYSTEM. WE NEED A RECALL!

NHTSA ODI #11045555

109,000 miles · Jan 13, 2017

Electronic Stability Control (esc)Service Brakes

Read full complaint

LATE EVENING 1/10/17, WHILE MOVING AT 65MPH ON I-95, IN MODERATE TRAFFIC, MY DASH LIT UP AND BRIEF ALERT TONE SOUNDED. INDICATOR READ: "CHECK VSC," BRAKES PULSED & GOT HEAVY. LASTED 5 MINUTES, THEN ALERTS CLEARED. MADE A CALL TO HAVE A MECHANIC TAKE A LOOK ON 1/13, HOWEVER ON THE EVENING OF 1/12/17 WHILE MOVING AT LOW SPEED IN A FLOW OF CARS, MY BRAKES BEGAN CLUTCHING UP & BECAME VERY HEAVY & UNRESPONSIVE, MY DASH LIT UP & A HIGH-PITCHED ALERT TONE SOUNDED. THE BRAKE LIGHT, MAINTENANCE LIGHT & OTHERS LIT UP & DASH INDICATOR SAID "CHECK VSC SYSTEM... MAINT REQUIRED." WHEN I STEPPED ON THE BRAKE, THE PEDAL PUSHED BACK, & AS I TRIED TO LIMP IT INTO THE PARKING LOT, THE BRAKES CONSTANTLY ENGAGED. I STOPPED TO WAIT FOR A FEW MINUTES, & TURNED THE CAR OFF BUT THE HIGH-PITCHED ALERT CONTINUED FOR SEVERAL MINUTES. FROM INSIDE THE CAR I COULD HEAR A WHIRRING NOISE IN THE FRONT END, IN THE AREA OF THE TIRES. I LET THE VEHICLE SIT FOR AN HOUR OR TWO, AT WHICH POINT, THE ALERT TONE HAD STOPPED BUT THE WHIRRING NOISE CONTINUED. I GOT INSIDE & FOUND THE ELECTRONICS WERE DIM, MOST WERE NOT WORKING. I STEPPED ON THE BRAKE & THE HIGH-PITCHED ALERT TONE RESUMED. RESISTANT FORCE CONTINUED IN THE BRAKE. I PUSHED THE START BUTTON A FEW TIMES, & EVENTUALLY THE DASH LIT BACK UP WITH ALL OF THE WARNING INDICATORS. THE CAR STARTED, BUT THE BRAKES PULSED AS IF CONSTANTLY ENGAGED & OCCASIONALLY BEING SLAMMED. IN GEAR, THE PROBLEMS PERSISTED, SO I GOT THE CAR OUT OF THE WAY & TURNED IT OFF. ALERT TONE & WHIR CONTINUED, ALONG WITH A BURNING KIND OF SMELL FROM THE AREA OF THE FRONT TIRES (RIGHT FRONT TIRE WELL FELT WARM). IT WAS DARK, SO I DIDN'T NOTICE IF THERE WAS SMOKE OF ANY COLOR. BECAUSE I WORRIED THAT THE WHIRRING MOTOR WAS GOING TO BURN UP & POSSIBLY EXACERBATE MATTERS, I DISCONNECTED THE BATTERY & HAD THE CAR TOWED TO A DEALER. I HAVE SOME VIDEOS IF THEY ARE HELPFUL.

NHTSA ODI #10944978

125,403 miles · Sep 3, 2015

Electronic Stability Control (esc)Service Brakes

Read full complaint

UPON STARTING VEHICLE A "CHECK VSC SYSTEM" WARNING MESSAGE WAS DISPLAYED. THE MAINTENANCE "!", "BRAKE DRUM", "TRAC" AND "ABS" WARNING LIGHTS ILLUMINATED. AN OBD2 CODE CHECK WAS PERFORMED AND A DIAGNOSTIC CODE "C0210 RH REAR SPEED SENSOR CIRCUIT" WAS RETURNED. AUTHORIZED TOYOTA DEALER/SERVICE REPLACED THE RIGHT REAR SPEED SENSOR AND HUB. WARNING SIGNALS RESET WAS ATTEMPTED, BUT FAILED. DIAGNOSTIC CODE REMAINED. DEALER PROPOSED TO BEGIN REPLACING DOWN-STREAM PARTS UNTIL CODE WOULD BE ABLE TO BE RESET. THERE WAS NO GUARANTEE THAT ANY OF THE REPLACEMENTS WOULD CORRECT THE CODE OR RESET THE ABS & STABILITY SYSTEMS. AGGRESSIVE CONVERSATION BETWEEN THE DEALERSHIP AND TOYOTA COULD NOT RESOLVE THE ISSUE. THE VEHICLE IS WITHOUT THE SAFETY OF THE ABS OR TRACTION CONTROL SYSTEMS AS LONG AS THE WARNING LIGHTS ARE ON. REVIEWING MULTIPLE INTERNET SITES CONCERNING THIS TOYOTA VEHICLE RELATED PROBLEM REVEALS NUMEROUS COMPLAINTS AND TEMPORARY SOLUTIONS, WHICH ULTIMATELY FAIL. IT IS SURPRISING WITH THE VOLUMINOUS CUSTOMER-LOGGED COMPLAINTS ON THIS ISSUE THAT TOYOTA HAS NOT DEEPENED ITS INVESTIGATION ON HOW TO CORRECT THE PROBLEM. IT APPEARS THAT THEY HAVE DETERMINED THAT EACH COMPLAINT IS IN INDIVIDUAL PROBLEM AND THEREFORE EASILY IGNORED.

NHTSA ODI #10761197

64,950 miles · May 4, 2015

Electronic Stability Control (esc)Vehicle Speed Control

I WAS DRIVING ON A STRAIGHT-LINE HIGHWAY AT 55MPH IN DRY CONDITIONS WHEN SUDDENLY "CHECK VSC SYSTEM" WARNING INDICATOR DISPLAYED. BRAKE LIGHT, BRAKE ICON AND ABS ICONS ALSO ILLUMINATED. ABOUT 10 MINUTES LATER, SYSTEM RETURNED TO NORMAL WHILE STILL DRIVING STRAIGHT DOWN THE ROAD. *TR

NHTSA ODI #10714381

165,000 miles · Dec 4, 2014

Electronic Stability Control (esc)Service BrakesVehicle Speed Control

Read full complaint

WHILE DRIVING HOME FROM WORK MY DASH BRAKE LIGHT WENT ON. AT THE NEXT STOPLIGHT I CHECKED TO SEE IF THE E BRAKE HAD BEEN DEPRESSED, IT HAD NOT. ONE BLCK LATER WHILE GOING ABOUT 35MPH MY DASH LIT UP LIKE A CHRISTMAS TREE, THE ABS, SLIPPERY CONDITIONS LIGHT, RED WARNING LIGHT AND CHECK ENGINE LIGHT ALL CAME ON AS WELL AS A WARNING TO "CHECK VSC" ALSO MY BREAKS WENT DOWN TO THE FLOOR AND I WAS UNABLE TO STOP RIGHT AWAY LUCKILY I WAS ABLE TO QUICKLY PULL INTO A,PARKING LOT AND COAST TO A STOP. HAD I NEEDED TO STOP SOON OR BEEN GOING FASTER THERE IS NO DOUBT IN MY MIND THIS WOULD HAVE RESULTED IN A CRASH. *TR

NHTSA ODI #10662126

170,000 miles · Nov 24, 2014

Electronic Stability Control (esc)Service BrakesVehicle Speed Control

Read full complaint

AS THE VEHICLE WAS BEING DRIVEN ON 11/20/2014, "CHECK VSC SYSTEM" SHOWED UP ON THE MULTI-INFORMATION DISPLAY, AND THE MASTER WARNING LIGHT, ABS LIGHT, SLIP INDICATOR LIGHT, AND BRAKE SYSTEM WARNING LIGHT (YELLOW INDICATOR) CAME ON. VEHICLE BRAKING PERFORMANCE SEEMED SLIGHTLY DIMINISHED BUT STILL SAFE TO DRIVE. ON 11/22/2014 I HAD TO MAKE A TRIP TO TOWN, AND NOT KNOWING THE SEVERITY OF THE WARNINGS, USED THE CAMRY. WHILE DRIVING NORTHBOUND AT APPROXIMATELY 50 MILES PER HOUR, I INDICATED A RIGHT HAND TURN, AND A WESTBOUND VEHICLE AT A STOP SIGN STARTED TURNING FROM THE ROAD I WAS TURNING ONTO TO DRIVE NORTH ON THE ROAD I WAS TURNING OFF OF. WHILE ATTEMPTING TO SLOW DOWN TO MAKE MY TURN, THE BRAKE PERFORMANCE WAS EXTREMELY POOR. I WAS UNABLE TO SLOW DOWN TO A REASONABLE SPEED TO MAKE THE TURN AND HAD TO MAKE MY TURN AT A MUCH HIGHER THAN NORMAL RATE OF SPEED TO AVOID COLLIDING WITH THE DRIVER THAT WAS TURNING OUT IN FRONT OF ME. I FINISHED MY TRIP TO TOWN, ALLOWING FAR MORE BRAKING DISTANCE THAN NORMAL, AND RETURNED HOME AND LEFT THE VEHICLE IN THE GARAGE. I CHECKED THE BRAKE FLUID LEVEL AND IT WAS WITHIN THE NORMAL RANGE BETWEEN MIN AND MAX. THIS MORNING I CONTACTED A LOCAL TOYOTA DEALER FOR A SERVICE APPOINTMENT. *TR

NHTSA ODI #10660474

65,000 miles · Nov 19, 2014

Electronic Stability Control (esc)SteeringCrash

Read full complaint

LOSS OF CONTROL OR STABILITY DUE TO MULTIPLE PROBLEMS CREATED BY FAULTY AND WEAK INTERNAL COMPONENTS OF THE ELECTRIC ASSIST RACK AND PINION. THE FAULTY ELECTRIC ASSIST RACK AND PINION CAUSES UNDETECTABLE MICRO-VIBRATIONS THAT LEADS TO CHAFFING OF THE FRONT TIRES, IT ALSO LEADS TO UNEVEN TREAD WEAR TO THE INSIDE OF THE FRONT TIRES WHICH CAUSES LOSS OF TRACTION AT ALL SPEEDS WITHOUT IMPLICATION OF THE WEAR. THE UNDERLYING PROBLEM DOES NOT COME TO YOUR ATTENTION WITH ANY WARNING OR IMPLICATIONS UNTIL THE INEVITABLE HAPPENS (WHICH COULD BE A FATAL ACCIDENT). WHILE DRIVING ON A HIGHWAY OR SUBURBAN STREET THAT ALLOWS SPEEDS IN ACCESS OF 45+MPH IS WHERE THE PROBLEM IS AT THE HIGHEST RISK CAUSING A DRIVER TO LOSE CONTROL OF THE VEHICLE DUE TO SWAYING OF THE TIRES BECAUSE OF THE FAULTY ELECTRIC ASSIST RACK AND PINION, CHAFFING OF THE TIRES, AND UNEVEN WEAR OF THE TIRES. THIS IS AN EXTREMELY DANGEROUS FAULT THAT SHOULD BE ADDRESSED IMMEDIATELY. IF YOU ARE AWARE OF HOW DANGEROUS IT CAN BE TO DRIVE A VEHICLE WITHOUT BRAKE PADS, THIS IS THE EQUIVALENT OF DRIVING A VEHICLE WITHOUT FINGERS. *TR

NHTSA ODI #10659494

145,000 miles · Nov 11, 2014

Electronic Stability Control (esc)Service BrakesVehicle Speed Control

CHECK VSC SYSTEM DISPLAYED AND ABS, TRACTION CONTROL, EMERGENCY BRAKE AND CAUTION LIGHTS ARE ON AND THE BRAKES ARE VERY SLOW TO RESPOND. *TR

NHTSA ODI #10654137

96,000 miles · Apr 21, 2014

Electronic Stability Control (esc)Service BrakesSuspension

Read full complaint

MY BRAKES FAILED THE FIRST TIME ON 1/29/14 ON MY WAY TO WORK. LUCKILY, I WASN'T GOING TOO FAST, WHICH ALLOWED ME TO SAFELY PULL OVER ONTO ONE OF THE SIDE STREETS. MY CAR DISPLAYED THE ERROR MESSAGE: "CHECK VSC SYSTEM." I CALLED AAA, AND ONE OF THEIR TOW TRUCK DRIVERS SUGGESTED THAT RATHER THAN TAKING MY CAR TO THE DEALERSHIP, I USE A DIFFERENT PLACE (WHICH HE CLAIMED WAS AAA APPROVED; IT WASN'T). NEARLY $500 LATER ($472.94 TO BE EXACT), MY CAR SEEMED FINE FOR ABOUT A MONTH. THEN ON 2/26/14, THIS TIME WHILE DRIVING ON THE INTERSTATE, MY BRAKES FAILED AGAIN. I GOT THE SAME MESSAGE AS BEFORE: "CHECK VSC SYSTEM." THIS TIME, I ASKED TO BE TOWED TO THE DEALERSHIP. SUPPOSEDLY, NOBODY AT THE DEALERSHIP WAS AWARE OF A RECALL FOR THIS SYSTEMATIC PROBLEM. HOWEVER, I HAVE SINCE FOUND OUT THAT 59 OTHER COMPLAINTS HAVE BEEN REPORTED FOR THIS VERY ISSUE. THAT'S ONLY THROUGH JANUARY; I CAN IMAGINE HOW MANY OTHER TIMES THIS HAPPENED THAT WERE NOT REPORTED. I ATE THE COST (THIS TIME UPWARDS OF $3,800) TO HAVE THE ENTIRE VEHICLE SUSPENSION CONTROL (VSC) UNIT COMPLETELY REPLACED. THIS MORNING, 4/21/14, I TURNED ON MY CAR & WAS GREETED WITH THAT OLD FAMILIAR MESSAGE: "CHECK VSC SYSTEM." I'M AFRAID TO TRY DRIVING MY CAR TO WORK IN THIS CONDITION, AND MEANWHILE I'VE SUNK OVER $4,000 INTO "REPAIRS" THAT DO NOT SEEM TO LAST. I ALWAYS THOUGHT TOYOTAS WERE SUCH GOOD, RELIABLE CARS. HOWEVER, I'M NOT SURE IF I WOULD BUY ANOTHER ONE AT THIS RATE. MY CAR HAS LESS THAN 100K MILES AND I'M EXTREMELY DISAPPOINTED WITH THIS HEADACHE. DOES SOMEONE HAVE TO DIE BEFORE TOYOTA ACTUALLY STEPS UP & ISSUES A RECALL?? *TR

NHTSA ODI #10583890

Official recalls

12V491000 · Visibility:power Window Devices And Controls

Oct 10, 2012

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Consequence & remedy

Consequence: If the switch overheats, it may melt, possibly resulting in a fire.

Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

PE14001 · Brake Actuator Malfunction

Opened Jan 23, 2014 · Closed Aug 22, 2014

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Air:supply:reservoir/tank; Service Brakes, Electric; Service Brakes, Hydraulic:power Assist

On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.

Additional source detail variants (4)

Service Brakes, Air:supply:reservoir/tank

Service Brakes, Electric

Service Brakes, Hydraulic:power Assist

Service Brakes

EA12006 · Power Window Master Switch Fire

Opened Jun 14, 2012 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.

Additional source detail variants (3)

Electrical System

Structure:body

Unknown Or Other

PE12002 · Power Window Master Switch Fire

Opened Feb 6, 2012 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.

Additional source detail variants (3)

Electrical System

Structure:body

Unknown Or Other