IllustrationEXTENSIVE BODY FRAME RUST.LARGE RUSTED OUT HOLES IN FRAME. UNABLE TO GET MA. VEHICLE YEARLY INSPECTION STICKER. EMISSIONS TEST FAILED (MA. INSPECTION STATION #PB004755). VEHICLE BOUGHT NEW 6/2005 RECOMMENDED NOT TO DRIVE VEHICLE DUE TO EXTENSIVE HOLES IN FRAME.
2005 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 2005 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
3025–50K
3350–75K
4075–100K
72100–150K
96150K+
292 reports with mileage · 117 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 185 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports3 fire reports10 injury reports
Steering complaints
27 reportsSEVERE FRAME AND FRONT END RUST, VEHICLE WELL TAKEN CARE OF> SHOULD HAVE BEEN PART OF TACOMA RECALL!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
THIS VEHICLE HAS A VERY RUSTY FRAME. IT DOES NOT PASS STATE OF MAINE INSPECTION. LIKE MANY OTHER 4RUNNERS IT SUFFERS FROM TOYOTA'S FAULTY FRAMES. THIS TRUCK HAS NOT FALLEN APART AND CRASHED LIKE MANY SIMILAR UNITS. THIS ONE HAS A PERFORATED FRAME, AND DOESN'T PASS INSPECTION. WITH 80,000 MILES THE TRUCK IS LIKE NEW EXCEPT FO…
Read full complaint
THIS VEHICLE HAS A VERY RUSTY FRAME. IT DOES NOT PASS STATE OF MAINE INSPECTION. LIKE MANY OTHER 4RUNNERS IT SUFFERS FROM TOYOTA'S FAULTY FRAMES. THIS TRUCK HAS NOT FALLEN APART AND CRASHED LIKE MANY SIMILAR UNITS. THIS ONE HAS A PERFORATED FRAME, AND DOESN'T PASS INSPECTION. WITH 80,000 MILES THE TRUCK IS LIKE NEW EXCEPT FOR THE FAULTY FRAME. THE RUST MULTIPLIES SITTING STILL OR TRAVELING. THE FRAME IS SO THIN IN SO MANY PLACES, THERE ISN'T PLACE TO MAKE SATISFACTORY REPAIRS.
THE FRAME OF THE VEHICLE IS RUSTED, THE RUST INTEGRITY MAY RESULT IN A STEERING FAILURE.
SEVERE FRAME RUST TO THE POINT OF HOLES. THE FRAME INTEGRITY WILL SOON BE COMPROMISED; IF NOT ALREADY. TWO REAR BODY MOUNTS ARE RUSTING AWAY, THE BOTTOM OF BOTH MOUNTS IS NON EXISTENT. ONE MID MOUNT, THE SHEET METAL SIDE IS NEARLY RUSTED THROUGH. ONE FRONT MOUNT AREA IS RUSTED AWAY ON THE SHEET METAL SIDE. THE GAS TANK IS CURREN…
Read full complaint
SEVERE FRAME RUST TO THE POINT OF HOLES. THE FRAME INTEGRITY WILL SOON BE COMPROMISED; IF NOT ALREADY. TWO REAR BODY MOUNTS ARE RUSTING AWAY, THE BOTTOM OF BOTH MOUNTS IS NON EXISTENT. ONE MID MOUNT, THE SHEET METAL SIDE IS NEARLY RUSTED THROUGH. ONE FRONT MOUNT AREA IS RUSTED AWAY ON THE SHEET METAL SIDE. THE GAS TANK IS CURRENTLY ONLY HELD IN PLACE BY WHAT IS LEFT OF THE PROTECTION SHIELD UNDER THE TANK .
STEERING COLUMN RUSTED THROUGH. HARD TO TURN, WHEN TURNING WHEEL IT GOES FROM SMOOTH(NORMAL) THEN GRABBY. I ALMOST FLIPPED MY VEHICLE WHEN TURNING OFF OF MASS AVENUE IN SOMERVILLE. IF I WAS DRIVING ANY FAST I WOULD HAVE ROLLED. I DON'T KNOW IF ANY WHEELS CAME OFF THE GROUND, BUT IT WAS CLOSE.
FRAME RUSTED LEADING TO FAILURE OF SWAY BAR BRACKETS CAUSING STEERING TO BECOME UNSTABLE. THIS OCCURRED WHILE DRIVING STRAIGHT DOWN A HIGHWAY. THE REPAIR ESTIMATE IS TOTAL FRAME REPLACEMENT.
BROUGHT VEHICLE TO REPAIR SHOP FOR MUFFLER AND TAILPIPE INSPECTION. REPAIR SHOP FOUND FRAME CRACKED AND RUSTED ALONG WITH STEERING SHAFT BROKEN. REPAIR SHOP INDICATED THAT THERE IS NO RECALL ON 4RUNNERS YET THIS IS A KNOWN PROBLEM WITH THE 2005 4RUNNER. REPAIR SHOP STATED IT WOULD COST $6000.00 FOR NEW FRAME FROM TOYOTA DEALER…
Read full complaint
BROUGHT VEHICLE TO REPAIR SHOP FOR MUFFLER AND TAILPIPE INSPECTION. REPAIR SHOP FOUND FRAME CRACKED AND RUSTED ALONG WITH STEERING SHAFT BROKEN. REPAIR SHOP INDICATED THAT THERE IS NO RECALL ON 4RUNNERS YET THIS IS A KNOWN PROBLEM WITH THE 2005 4RUNNER. REPAIR SHOP STATED IT WOULD COST $6000.00 FOR NEW FRAME FROM TOYOTA DEALER. HARTFORD TOYOTA SUPERSTORE HAS DONE OIL CHANGES ON THIS VEHICLE SINCE PURCHASE YET HAS NEVER BROUGHT THE FRAME PROBLEM TO OUR ATTENTION.
LAST SEPTEMBER, I SENT A WRITTEN PLEA ASKING TOYOTA TO EVALUATE AND CORRECT THE EXCESSIVE FRAME CORROSION ON MY 2005 4RUNNER. THE VEHICLE HAS NEVER BEEN REGISTERED OUTSIDE SOUTH CAROLINA OR EVER BEEN EXPOSED TO ROAD SALT. TOYOTA'S RESPONSE DISCLAIMING RESPONSIBILITY WAS UNSATISFACTORY. TOYOTA IS WELL AWARE OF THIS PROBLEM AND …
Read full complaint
LAST SEPTEMBER, I SENT A WRITTEN PLEA ASKING TOYOTA TO EVALUATE AND CORRECT THE EXCESSIVE FRAME CORROSION ON MY 2005 4RUNNER. THE VEHICLE HAS NEVER BEEN REGISTERED OUTSIDE SOUTH CAROLINA OR EVER BEEN EXPOSED TO ROAD SALT. TOYOTA'S RESPONSE DISCLAIMING RESPONSIBILITY WAS UNSATISFACTORY. TOYOTA IS WELL AWARE OF THIS PROBLEM AND HAS CORRECTED THIS IDENTICAL PROBLEM ON SIMILAR MODELS AND MODEL YEARS. YESTERDAY, MY WIFE AND I AND TWO FRIENDS RIDING WITH US NARROWLY ESCAPED A FATAL ACCIDENT WHEN THE FRONT SUSPENSION SEPARATED FROM THE FRAME DUE TO THE CORROSION PROBLEM. AT HIGHWAY SPEED, THE VEHICLE BEGAN SHAKING VIOLENTLY AND THE STEERING WAS UNABLE TO PROPERLY CONTROL THE VEHICLE. THE VEHICLE WENT OFF THE ROAD AFTER COMING CLOSE TO HITTING AN ONCOMING VEHICLE. IT WAS TOWED TO AN EXPERIENCED INDEPENDENT MECHANIC WHO EXPRESSED DISBELIEF AT THE CORRODED CONDITION OF THE FRAME AND IMMEDIATELY DECLARED THE VEHICLE UNREPAIRABLE AND INOPERABLE. HE SAID WE WERE FORTUNATE TO HAVE SURVIVED THE STRUCTURAL FAILURE. IN LIGHT OF THE FACT THAT TOYOTA IS AWARE OF SEVERE CORROSION ON SIMILAR VEHICLES AND HAS CORRECTED THE ISSUE ON SOME MODELS, PLEASE INVESTIGATE THIS AND DETERMINE IF THE EXCESS CORROSION IS INHERENT TO 4RUNNERS AND IF AN IMMEDIATE RECALL IS WARRANTED. THE INTERNET HAS MANY REFERENCES TO EXCESS FRAME CORROSION ON 4RUNNERS. IT IS UNCONCIONABLE THAT TOYOTA WOULD PUT THOUSANDS OF THEIR CUSTOMER'S LIVES AT RISK TO AVOID THE COST OF REPAIRING FRAMES THAT WERE SUBJECT TO AN INADEQUATE CORROSION PROTECTION PROCESS. AGAIN, MY VEHICLE HAS ONLY 76,000 MILES, HAS NO CORROSION WHATSOEVER ON THE BODY, AND HAS NEVER BEEN OPERATED WHERE SALT IS APPLIED TO THE ROADS. ATTACHED IS ONE OF THE MANY PHOTOS OF THE FAILURE LOCATION. *JS*JS*JS *JS *JS *TR
MY SUV ONLY HAS 66,000 MILES ON IT AND RECENTLY (PAST MONTH) THE STEERING IS VERY LABORIOUS. TO THE POINT THAT I HAVE NECK AND SHOULDER PAIN. THE STEERING IS HARD TO START A TURN (NO MATTER WHAT SPEED) AND AS I CONTINUE TO TURN THE WHEEL IT WILL EASE UP A BIT AND THEN BE HARD TO TURN IT BACK AGAIN TO STRAIGHT. MEANING THAT IT WI…
Read full complaint
MY SUV ONLY HAS 66,000 MILES ON IT AND RECENTLY (PAST MONTH) THE STEERING IS VERY LABORIOUS. TO THE POINT THAT I HAVE NECK AND SHOULDER PAIN. THE STEERING IS HARD TO START A TURN (NO MATTER WHAT SPEED) AND AS I CONTINUE TO TURN THE WHEEL IT WILL EASE UP A BIT AND THEN BE HARD TO TURN IT BACK AGAIN TO STRAIGHT. MEANING THAT IT WILL NOT RETURN WITHOUT CONSIDERABLE EFFORT. I WAS ON CARS.COM WEBSITE AS THEY HAD RECALLS LISTED. I LOOKED UP 4 RUNNER STEERING PROBLEMS AND THEY GAVE ME A RECALL NUMBER. WHEN I CALLED TOYOTA THEY TOLD ME THERE WERE NO RECALLS FOR MY VIN #. I THINK TOYOTA IS RIPPING ME OFF BECAUSE THE PROBLEM I'M HAVING IS JUST WHAT IS DESCRIBED IN THE SUMMARY. THE COMPONENT LISTED IS STEERING; LINKAGES; ROD; RELAY; CONNECTING. THE CONSEQUENCE LISTED IS IF THE VEHICLE IS CONTINUED TO BE OPERATED IN THIS CONDITION, THE RELAY ROD MAY FRACTURE, INCREASING THE RISK OF A CRASH. THE RECALL NUMBER IS 05V389000 AND THE RECALL DATE IS 09-06-2005. PLUS MY WIFE AND I DO NOT TURN THE WHEEL UNTIL THE VEHICLE IS MOVING. WE ARE OLD ENOUGH TO KNOW WHAT IS WAS LIKE BEFORE CARS HAD POWER STEERING. THIS IS A SAFETY ISSUE! THANKS FOR ANY HELP THAT YOU CAN DO FOR US.
Official recalls
516V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
16V065000 · Air Bags:side/window
Feb 5, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Consequence & remedy
Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.
11V113000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP18002 · Frame Corrosion
Opened Aug 17, 2018 · Closed Mar 18, 2022
Status: closed (inferred from source dates) · Structure:frame And Members
On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.