IllustrationRUST ROT ON FRAME OF BODY, WILL PROBABLY NOT PASS NEXT IN INSPECTION NOTED BY THOMPSON DEALERSHIP. TOYOTA FIXED OTHER MODELS, BUT AM IGNORING MY MODEL.
2004 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 2004 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
2825–50K
5150–75K
6275–100K
132100–150K
129150K+
418 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 309 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports3 fire reports14 injury reports
Unknown Or Other complaints
115 reportsDRIVING DOWN ROAD @40 MPH, ALL OF A SUDDEN FELT LIKE DRIVING ICE. IMMEDIATELY LET OFF GAS PEDAL TO REMAIN IN CONTROL OF VEHICLE. ABOVE 35 MPH, CAN BARELY STAY IN CONTROL. THANKFULLY CLOSE TO HOME, CRAWLED HOME UNDER 25 MPH. THANK GOD I WASN'T DRIVING ON THE HIGHWAY @ 70MPH. AT HIGHWAY SPEEDS I CERTAINLY DON'T THINK I WOULD HAVE …
Read full complaint
DRIVING DOWN ROAD @40 MPH, ALL OF A SUDDEN FELT LIKE DRIVING ICE. IMMEDIATELY LET OFF GAS PEDAL TO REMAIN IN CONTROL OF VEHICLE. ABOVE 35 MPH, CAN BARELY STAY IN CONTROL. THANKFULLY CLOSE TO HOME, CRAWLED HOME UNDER 25 MPH. THANK GOD I WASN'T DRIVING ON THE HIGHWAY @ 70MPH. AT HIGHWAY SPEEDS I CERTAINLY DON'T THINK I WOULD HAVE BEEN ABLE TO STAY IN CONTROL, & WOULD HAVE BEEN THE CAUSE OF A MAJOR POSSIBLY DEADLY ACCIDENT. I BROUGHT IT TO A REPUTABLE REPAIR SHOP, & WAS TOLD THE REAR LEFT CONTROL ARM & BRACKET ROTTED OFF THE FRAME. TOLD ME IT WAS UNSAFE TO DRIVE & UNREPAIRABLE, BECAUSE THE FRAME IS TOO ROTTED FROM RUST. HE ALSO TOLD ME IT IS UNSAFE TO DRIVE. IT IS THE ONLY VEHICLE I OWN, I NEED TO DRIVE TO WORK TO PROVIDE FOR MY FAMILY. I AM LEFT WITH VEHICLE THAT I CAN'T DRIVE OR REPAIR. YESTERDAY KELLY'S BOOK VALUE WAS $12, 000. TODAY ITS VALUE IS 0. TOYOTA TOLD ME THERE IS NO RECALL SO ITS MY PROBLEM. I FEEL BETRAYED! I'VE READ MANY COMPLAINTS ONLINE ABOUT ROTTED TOYOTA 4RUNNER FRAMES. THERE'S A RECALL ON 04 TUNDRA'S FOR ROTTED FRAMES, WHICH WERE MANUFACTURED WITH THE SAME METAL & TECHNIQUE'S AS THE 4RUNNER. SO WHY NO RECALL FOR 4RUNNER'S? NOT ENOUGH COMPLAINTS! TOYOTA SELLS MANY MORE TRUCKS THAN SUV'S IN USA. I CAN'T BELIEVE TOYOTA & THE NHTSA CAN & WILL ALLOW THESE UNSAFE VEHICLE'S TO DRIVE THROUGH OUR NEIGHBORHOODS KNOWING THE RISK THEY POSE TO INNOCENT PEOPLE. I GAVE TOYOTA ALOT OF MY HARD EARNED MONEY ON WHAT I THOUGHT WAS A QUALITY VEHICLE. I CHECKED OUT MY FRAME TODAY, & CAN EASILY PUT MY FINGER THRU FRAME IN MANY PLACES. IT IS UNACCEPTABLE TO ALLOW TOYOTA TO LEAVE ITS CUSTOMERS LEFT WITH A WORTHLESS VEHICLE WITHOUT ANY RESPONSIBILITY FOR THIER INFERIOR PRODUCT. I URGED THE NHTSA TO OPEN A LARGE SCALE INVESTIGATION INTO THE QUALITY OR LACK THERE OFF IN 2004 TOYOTA 4RUNNER FRAMES. I AM A HARD WORKING HONEST AMERICAN, I FEEL WRONGED BY TOYOTA! ITS NOT RIGHT!!
I RECEIVED A LETTER FROM TOYOTA IN MAY OF 2015 IN REFERENCE OF A WARRANTY ENHANCEMENT NOTIFICATION. WE HAVE GONE TO THE TOYOTA DEALERSHIP MANY TIMES TO ASK WHEN OUR REPAIR WOULD PROCESS THOUGH AND COMMENCE. THEY KEEP ON SAYING THAT WE WERE FOURTH IN LINE. IT HAS BEEN MORA THAT ONE YEAR AND WE STILL HAVEN'T RECEIVED ANY NOTIFICA…
Read full complaint
I RECEIVED A LETTER FROM TOYOTA IN MAY OF 2015 IN REFERENCE OF A WARRANTY ENHANCEMENT NOTIFICATION. WE HAVE GONE TO THE TOYOTA DEALERSHIP MANY TIMES TO ASK WHEN OUR REPAIR WOULD PROCESS THOUGH AND COMMENCE. THEY KEEP ON SAYING THAT WE WERE FOURTH IN LINE. IT HAS BEEN MORA THAT ONE YEAR AND WE STILL HAVEN'T RECEIVED ANY NOTIFICATIONS
2004 4 RUNNER SPORT, FRAME RUSTING OUT EVERYWHERE, N OW FRONT CROSS MEMBER UNDER THE RADIATOR IS COMPLETLY RUSTED THRU. THIS CAR HAS BEEN WELL MAINTAINED, TOYOTA SHOULD BE STANDING BEHIND THIS PROBLEM. I HAD HOPED THIS WOULD BE MY LAST CAR TO BUY, NOW AT 75 I MUST LOOK FOR ANOTHER VEHICLE. THIS CAR IS IN MASSACHUSETT
DASH BOARD CRACK RECALL 2 YEARS ALL DEALER SAYS IS THEY DON'T HAVE THE PARTS
THESE VEHICLES ARE PLAGUED BY RUST ON THE FRAME AND COMPONENTS ATTACHED TO THE FRAMES. THERE IS THE POTENTIAL THAT THIS CAN CAUSE A HAZARD DUE TO FAILURE OF CRITICAL COMPONENTS OF THE VEHICLE. THIS ISSUE EFFECTS MULTIPLE VEHICLES AND IS NOT AN ISOLATED INCIDENT. FRAMES DEGRADE JUST LIKE THE ONES ON THE TACOMA YET NO ACTION IS BE…
Read full complaint
THESE VEHICLES ARE PLAGUED BY RUST ON THE FRAME AND COMPONENTS ATTACHED TO THE FRAMES. THERE IS THE POTENTIAL THAT THIS CAN CAUSE A HAZARD DUE TO FAILURE OF CRITICAL COMPONENTS OF THE VEHICLE. THIS ISSUE EFFECTS MULTIPLE VEHICLES AND IS NOT AN ISOLATED INCIDENT. FRAMES DEGRADE JUST LIKE THE ONES ON THE TACOMA YET NO ACTION IS BEING TAKEN TO ENSURE THE SAFETY OF 4RUNNER OWNERS.
CALIPER.
EXCESSIVE RUST AND CORROSION TO THE POINT WHERE MY SKID PLATE CAME OFF AND TRANSMISSION FLUID LINES BROKE APART, LEADING TO MAJOR LEAK AND FIX - LUCKILY IT CAME OFF IN DRIVEWAY AND NOT ON HIGHWAY WHERE SOMEONE COULD HAVE BEEN SIGNIFICANTLY INJURED. SHOCKS HAVE HOLES IN THEM FROM RUST AND CORROSION, AS DO SUPPORT BARS AND FRAME. …
Read full complaint
EXCESSIVE RUST AND CORROSION TO THE POINT WHERE MY SKID PLATE CAME OFF AND TRANSMISSION FLUID LINES BROKE APART, LEADING TO MAJOR LEAK AND FIX - LUCKILY IT CAME OFF IN DRIVEWAY AND NOT ON HIGHWAY WHERE SOMEONE COULD HAVE BEEN SIGNIFICANTLY INJURED. SHOCKS HAVE HOLES IN THEM FROM RUST AND CORROSION, AS DO SUPPORT BARS AND FRAME. CAN BREAK OFF PIECES OF THE FRAME IN MY HAND WITHOUT EFFORT. CONCERNED THAT FRAME COULD CRACK, SUPPORT COMPONENTS COULD FAIL WHILE DRIVING BECAUSE OF CORROSION. OTHER TOYOTA MODELS HAVE BEEN RECALLED FOR RUST, USING THE SAME COMPONENTS BUT ASSEMBLED IN DIFFERENT FACTORIES THAN THE 4RUNNER AND LAND CRUISER MODELS, TO MY UNDERSTANDING. THIS IS A SAFETY ISSUE THAT TOYOTA MUST ADDRESS BEFORE ANYONE IS SERIOUSLY INJURED.
SUV IS UNSAFE TO DRIVE DUE TO EXCESSIVE RUSTING OF FRAME AND ALL OTHER UNDERCARRIAGE METAL PARTS. FRAME INTEGRITY IS SERIOUSLY COMPROMISED. RUST IS EXPONENTIATING OVER TIME. RUST LEACHING TO OTHER MAJORS PARTS LIKE THE EXHAUST. TRANSMISSION, RADIATOR, AC, WHEELS, BRAKES, EXHAUST, STEERING, ETC ALL ARE COMPROMISED AND FAILING …
Read full complaint
SUV IS UNSAFE TO DRIVE DUE TO EXCESSIVE RUSTING OF FRAME AND ALL OTHER UNDERCARRIAGE METAL PARTS. FRAME INTEGRITY IS SERIOUSLY COMPROMISED. RUST IS EXPONENTIATING OVER TIME. RUST LEACHING TO OTHER MAJORS PARTS LIKE THE EXHAUST. TRANSMISSION, RADIATOR, AC, WHEELS, BRAKES, EXHAUST, STEERING, ETC ALL ARE COMPROMISED AND FAILING DUE TO RUST. THIS HAS BEEN GOING ON FOR YEARS. RADIATOR REPLACED. AC LEAKING. OCT 2011 HEAT SHIELD RUST NOTED BY TOYOTA. FEB. 2014 HEAT SHIELDS WERE REMOVED BY TOYOTA. THEY CLAIMED THAT THE TRUCK DOESN'T NEED THE HEAT SHIELDS. THEY DID NOT MENTION THE FRAME RUSTING OR THE LIFETIME EXHAUST RUSTING. THEY DID NOT MENTION THAT THIS IS A COMMON ISSUE WITH 4RUNNERS. I HAVE ALWAYS HAD ISSUES WITH THAT SERVICE DEPT. BUT THE ONLY OTHER TOYOTA IS WORSE. THIS ISSUE NEEDS SERIOUS RECALL ASAP. I THINK THESE TRUCKS WILL START FAILING AND CAUSING DEATHS SOON. NUMEROUS ISSUES WITH THIS TRUCK OVER THE YEARS ALL MAY BE DUE TO RUST. BRAKES DON'T SEEM TO LAST AND THE TRUCK IS HARDLY USED. I BELIEVE RUST IS INTERFERING WITH THE BRAKES.
MY 2004 4RUNNER WITH $144K MILES WAS RECENTLY DISCOVERED TO HAVE A SIX INCH HOLE IN THE FRAME DUE TO RUST, AND BASED ON MD SAFETY INSPECTION REQUIREMENTS, THIS VEHICLE PRESENTS A SIGNIFICANT SAFETY HAZARD AND CAN NOT BE REGISTERED. THE DEALERSHIP INFORMED ME THE REPAIR WOULD BE A COMPLETE FRAME REPLACED AT A COST OF $18-20K. I…
Read full complaint
MY 2004 4RUNNER WITH $144K MILES WAS RECENTLY DISCOVERED TO HAVE A SIX INCH HOLE IN THE FRAME DUE TO RUST, AND BASED ON MD SAFETY INSPECTION REQUIREMENTS, THIS VEHICLE PRESENTS A SIGNIFICANT SAFETY HAZARD AND CAN NOT BE REGISTERED. THE DEALERSHIP INFORMED ME THE REPAIR WOULD BE A COMPLETE FRAME REPLACED AT A COST OF $18-20K. I HAVE MAINTAINED MY VEHICLE METICULOUSLY THROUGHOUT IT'S LIFE WITH MOSTLY DEALERSHIP MAINTENANCE AND AT NO TIME DID ANY MECHANIC OR SERVICE DEPARTMENT MENTION EXCESSIVE RUST OR HOLES IN THE FRAME. I SPOKE TO TOYOTA CUSTOMER SERVICE AND ALTHOUGH THEY HAVE RECALL PROGRAMS FOR TACOMA AND SEQUOIA VEHICLES DUE TO SIMILAR FRAME RUSTING PROBLEMS, THEY ARE UNWILLING TO ACKNOWLEDGE THAT ANY FLAW EXISTS WITH EXCESSIVE CORROSION IN THE 4RUNNER MODELS. IT APPEARS TO ME THAT TOYOTA HAS A SERIOUS SAFETY PROBLEM RELATED TO THIS GENERATION OF 4RUNNERS, AND SINCE THEY ARE UNWILLING TO EVEN ACKNOWLEDGE THE PROBLEM EXISTS, IT APPEARS THIS IS AN ISSUE THAT REQUIRES GOVERNMENTAL/NHTSA INTERVENTION. I CAN'T IMAGINE HOW MANY OTHER 4RUNNERS ARE ON THE ROAD WITH SIMILAR COMPROMISED FRAMES, AND I WOULD HATE TO SEE AN ACCIDENT DUE TO FRAME FAILURE AT HIGH SPEED OR DURING TIGHT CORNERING. PLEASE LOOK INTO THIS ISSUE TO PREVENT ANY INADVERTENT INJURY OR DEATH.
Official recalls
216V065000 · Air Bags:side/window
Feb 5, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Consequence & remedy
Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.
11V113000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP18002 · Frame Corrosion
Opened Aug 17, 2018 · Closed Mar 18, 2022
Status: closed (inferred from source dates) · Structure:frame And Members
On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.