← New search

2004 Toyota 4RUNNER

Owner reports · Recalls · Investigations

More warning signs than most 4RUNNER years

Owner complaints for the 2004 Toyota 4RUNNER are substantially higher than the model-year median of 58.

About this comparison →

When problems were reported

Mileage at the reported incident

418 reports with mileage · 194 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Structure. Review the 309 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Suspension. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports3 fire reports14 injury reports

Structure complaints

309 reports
Clear category filter
160,000 miles · Aug 29, 2018
StructureUnknown Or Other

EXCESSIVE FRAME RUST, INCLUDING HOLES, AND GENERAL RUST ALL AROUND THE FRAME. SPECIFICALLY IN THE FRONT AND REAR.

NHTSA ODI #11123248

155,950 miles · Aug 27, 2018
Structure

WE PURCHASED A 2004 TOYOTA 4 RUNNER IN MAY OF 2017. THE DEALER INFORMED US THAT HIS MECHANIC HAD CHECKED THE VEHICLE OVER AND WAS IN GOOD SHAPE AND SHOULD LAST US A LONG TIME. ON AUGUST 14, 2018 I DRIVE THE VEHICLE TO A TOYOTA DEALERSHIP APPROXIMATELY 70 MILES AWAY TO HAVE DIAGNOSTICS RUN ON IT FOR AN ISSUE WITH THE 4-WHEEL DRIV…

Read full complaint

WE PURCHASED A 2004 TOYOTA 4 RUNNER IN MAY OF 2017. THE DEALER INFORMED US THAT HIS MECHANIC HAD CHECKED THE VEHICLE OVER AND WAS IN GOOD SHAPE AND SHOULD LAST US A LONG TIME. ON AUGUST 14, 2018 I DRIVE THE VEHICLE TO A TOYOTA DEALERSHIP APPROXIMATELY 70 MILES AWAY TO HAVE DIAGNOSTICS RUN ON IT FOR AN ISSUE WITH THE 4-WHEEL DRIVE. AFTER PLACING THE VEHICLE ON A LIFT AND CHECKING IT OUT, HE HAD US STEP INTO THE SHOP WITH THE VEHICLE STILL ON THE LIFT TO SHOW US WHAT HE FOUND. THE FRAME HAD MULTIPLE RUST HOLE THROUGH THE FRAME AND ONE RUNNING VERTICALLY ALONG THE TRANSMISSION FRAME BRACKET. IT WAS SO BAD HE MADE US SIGN A WAIVER RELEASING THE DEALERSHIP FROM LIABILITY BEFORE HE WOULD LET US LEAVE WITH IT. THIS IS A LIMITED EDITION, 2004 TOYOTA 4 RUNNER WITH A LITTLE OVER 156,000 MILES ON IT. I FEEL THAT TOYOTA SHOULD STAND BEHIND THEIR PRODUCTS AS APPARENTLY THIS IS A WELL-KNOWN ISSUE WITH THESE VEHICLES. WE HAVE HAD OUR GRANDCHILDREN IN THIS VEHICLE AND THE FRAME COULD HAVE COLLAPSED AT ANYTIME CAUSING DEATH OR INJURY TO ANY OR ALL OF US. WE BOUGHT IT BECAUSE OF TOYOTA'S REPUTATION WHICH AT THIS POINT IS NOT WORTHY OF ANYTHING WHEN THEY DON'T STAND BEHIND IT. THIS ISSUE SHOULD HAVE BEEN ADDRESSED BEFORE THE FRAMES REACH THIS POINT OF BEING BEYOND REPAIR.

NHTSA ODI #11122791

Mileage unknown · Aug 26, 2018
Structure

THE OUTSIDE OF MY 4RUNNER IS RUST FREE. THE FRAME HOWEVER HAS EXTENSIVE RUST ISSUES. I HAVE HAD TO HAVE SECTIONS CUT OUT AND REWELDED BECAUSE IT WOULD NOT PASS INSPECTION. THE STEERING COLUMN RUSTED OUT AND HAD TO BE REPLACED BECAUSE THE STEERING STOPPED RESPONDING.

NHTSA ODI #11122405

145,000 miles · Aug 22, 2018
SeatsStructureUnknown Or Other

RUST ON THE FRAME INCLUDING THE REAR BUMPER, CRACK IN THE DASHBOARD FROM DRIVERS SIDE OVER TO THE CENTER OF CAR. DRIVERS SEAT EXCESSIVE MOVEMENT AT ATTACHMENT BETWEEN SEAT BACK AND BASE ON EXTERNAL PORTION OF SEAT. THE VEHICLE WAS PARKED AT VARIOUS TIMES WHEN INSPECTED. REPAINTED RIMS THAT PAINT HAD FLAKED AND PEELED.

NHTSA ODI #11121774

Mileage unknown · Aug 22, 2018
Structure

THE FRAME IS RUSTED REALLY BAD. THE BRACKET THAT HOLDS THE REAR PASSENGER SIDE LOWER CONTROL ARE HAS RUSTED OFF MAKING ME TIE IT UP AND MAKING IT USELESS. THE FRAME HAS SEVERAL PLACES THAT THE RUST HAS ATE LARGE HOLES IN IT. IF YOU NEED ME TO I CAN MAIL PICTURES TO YOU. I BOUGHT THIS 4RUNNER BRAND NEW. I CONTACTED TOYOTA ABOUT T…

Read full complaint

THE FRAME IS RUSTED REALLY BAD. THE BRACKET THAT HOLDS THE REAR PASSENGER SIDE LOWER CONTROL ARE HAS RUSTED OFF MAKING ME TIE IT UP AND MAKING IT USELESS. THE FRAME HAS SEVERAL PLACES THAT THE RUST HAS ATE LARGE HOLES IN IT. IF YOU NEED ME TO I CAN MAIL PICTURES TO YOU. I BOUGHT THIS 4RUNNER BRAND NEW. I CONTACTED TOYOTA ABOUT THIS PROBLEM AND THEY TOLD ME THAT THE WARRANTY HAS EXPIRED BUT THAT IF I BOUGHT A NEW TOYOTA THEN THEY WOULD GIVE ME A 1000 DOLLAR REBATE AS A GOODWILL GESTURE. I DO NOT WANT THE 1000 DOLLAR GOODWILL REBATE, I WANT MY 4RUNNER FIXED.

NHTSA ODI #11121562

128,000 miles · Aug 21, 2018
Structure

MY FRAME FOR MY 2004 4RUNNER ARE ROTTING AND RUSTING AWAY MAKING IT UNSAFE FOR ME TO DRIVE.

NHTSA ODI #11121522

Mileage unknown · Aug 16, 2018
Structure

MY NAME IS [XXX], I AM HERE BECAUSE OF RUSTED FRAMES I WAS JUST TOLD TODAY BY AAA MECHANIC CENTER IN SKOKI ILLINOIS THAT I CAN NOT DRIVE MY 4RUNNER HOME BECAUSE ISN'T SAFE FOR DRIVE, AND THEY SHOW ME THE FRAMES BOTH SIDES ARE RUSTED AND I TOOK THE CAR TO 6042 N WESTERN AVE CHICAGO IL 60659 (773-728-5000) CHICAGO NOTHSIDE TOYOTA …

Read full complaint

MY NAME IS [XXX], I AM HERE BECAUSE OF RUSTED FRAMES I WAS JUST TOLD TODAY BY AAA MECHANIC CENTER IN SKOKI ILLINOIS THAT I CAN NOT DRIVE MY 4RUNNER HOME BECAUSE ISN'T SAFE FOR DRIVE, AND THEY SHOW ME THE FRAMES BOTH SIDES ARE RUSTED AND I TOOK THE CAR TO 6042 N WESTERN AVE CHICAGO IL 60659 (773-728-5000) CHICAGO NOTHSIDE TOYOTA AT WESTERN AVE AND PETERSON IN CHICAGO ILLINOIS IMMEDIATELY AND I WAS TOLD ISN'T ON RECALL. I CONTACTED CONSUMER AFFAIRS ALREADY AND I WILL GO TO SECRETARY OF STATE ON MONDAY WITH THE PICTURES TO ALERT OTHER OWNERS. I WILL DRAFT A LETTER TO SEND WITH THE PICTURES TO THE STATE REPRESENTATIVE AS SOON AS POSSIBLE BECAUSE THIS NEED IMMEDIATELY ATTENTION. THIS SUV IS BEAUTIFUL IN AND OUT BUT WHEN THEY LIFTED THE CAR UP I WAS SCREAMING BECAUSE BOTH FRAMES WAS RUSTED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #11120524

188,000 miles · Aug 14, 2018
Structure

SEVERE FRAME RUSTING, WITH HOLES, SOME AS LONG AS 6", AND WOULD NOT PASS PENNSYLVANIA INSPECTION. HAD TO HAVE WELDED IN 6 DIFFERENT SECTIONS.CENTER FRONT TOE, LEFT AND RIGHT FRONT HARNESS, LEFT AND RIGHT FRAME CENTER, AND LEFT REAR FRAME END. THE GARAGE AND AUTOBODY SHOP SAID TOYOTA SHOULD BE RECALLING THE 4 RUNNERS FOR FRAME …

Read full complaint

SEVERE FRAME RUSTING, WITH HOLES, SOME AS LONG AS 6", AND WOULD NOT PASS PENNSYLVANIA INSPECTION. HAD TO HAVE WELDED IN 6 DIFFERENT SECTIONS.CENTER FRONT TOE, LEFT AND RIGHT FRONT HARNESS, LEFT AND RIGHT FRAME CENTER, AND LEFT REAR FRAME END. THE GARAGE AND AUTOBODY SHOP SAID TOYOTA SHOULD BE RECALLING THE 4 RUNNERS FOR FRAME RUST, NOT JUST THE TACOMA, TUNDRA AND SEQUOIAS. THEY HAVE SEEN THE SEVERE RUSTING OF THE FRAME IN THE 4 RUNNERS. I HAVE READ NUMEROUS COMPLAINTS OF THE 4 RUNNER FRAME RUSTING. THIS IS A DANGEROUS SITUATION!!! IT NEEDS TO BE ADDRESSED.

NHTSA ODI #11119927

185,000 miles · Aug 2, 2018
Structure

I JUST DISCOVERED THAT THE FRAME ON MY 4RUNNER IS SEVERELY RUSTED DUE TO LOW QUALITY STEEL. SEVERAL MECHANICS HAVE OBSERVED THE FRAME AND ALL OF THEM HAVE TOLD ME IT IS UNSAFE TO DRIVE. I HAVE A 2003 TOYOTA LAND CRUISER AND ITS FRAME IS IN GREAT CONDITION. BOTH CARS HAVE BEEN GARAGED AND OPERATED IN THE SAME CONDITIONS. THE…

Read full complaint

I JUST DISCOVERED THAT THE FRAME ON MY 4RUNNER IS SEVERELY RUSTED DUE TO LOW QUALITY STEEL. SEVERAL MECHANICS HAVE OBSERVED THE FRAME AND ALL OF THEM HAVE TOLD ME IT IS UNSAFE TO DRIVE. I HAVE A 2003 TOYOTA LAND CRUISER AND ITS FRAME IS IN GREAT CONDITION. BOTH CARS HAVE BEEN GARAGED AND OPERATED IN THE SAME CONDITIONS. THE FRAME RUST IS SO BAD, IT IS DIFFICULT TO GET THE CAR UP ON A LIFT TO PERFORM OIL CHANGES, ETC. THE MAIN CONCERN IS SAFETY. IF THE CAR IS IN AN ACCIDENT, I WAS TOLD THAT IT WOULD NOT PROVIDE ANY PROTECTION FROM A SIDE OR FRONT IMPACT.

NHTSA ODI #11115408

106,500 miles · Jul 31, 2018
Structure

MY 2004 TOYOTA 4RUNNER WAS NOT ABLE TO GET A BRAKE JOB BECAUSE THE FRAME WAS RUSTED, REAR TRAILING ARM BRACKETS BROKEN OFF, DIFFERENTIAL HOUSING ON BOTH SIDES BROKEN, HOLES IN FRAME RIGHT SIDE. TOTALLY RUSTED AND UNSAFE TO DRIVE.

NHTSA ODI #11114755

Official recalls

2

16V065000 · Air Bags:side/window

Feb 5, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.

Consequence & remedy

Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.

Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.

11V113000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP18002 · Frame Corrosion

Opened Aug 17, 2018 · Closed Mar 18, 2022

Status: closed (inferred from source dates) · Structure:frame And Members

On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.