IllustrationFRAME IS LOADED WITH HOLES BODY PANELS ARE PERFECT. CAR IS UNSAFE TO DRIVE AND WILL NOT PASS SAFETY INSPECTION. WITH ONLY 80,000 MILES
1998 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 1998 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
125–50K
450–75K
975–100K
20100–150K
70150K+
105 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports2 fire reports1 injury reports
Structure complaints
72 reportsBADLY RUSTED FRAME, BY MECHANIC UNSAFE TO DRIVE IT. STARTED MAKING NOISES UNDER THE CAR REASON WHY I TOOK TO THE MECHANIC.
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. WHILE DRIVING 25 MPH, THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. IT WAS DIAGNOSED THAT THE CHASSIS AND CONTROL ARM WERE ROTTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.
AFTER MULTI-POINT INSPECTION, DEALER INFORMED ME THAT THE "FRAME IS VERY RUSTED AND IS ROTTING OUT WHERE REAR SUSPENSION MEETS FRAME. DO NOT RECOMMEND TO DRIVE."
FRAME RUSTED OUT AND REAR AXLE SUPPORT DETACHED FROM FRAME WHILE DRIVING, CAUSING VEHICLE TO SWAY UNCONTROLLABLY ALMOST ROLLING OVER. FOUND THAT MANUFACTURER HAS RECALL ON TRUCKS WITH SIMILAR FRAME FOR RUST ISSUE, BUT NOT THIS VEHICLE BECAUSE THERE ARE NOT ENOUGH COMPLAINTS OR DEATHS. *TR
EXTENSIVE UNDER BODY FRAMES SCALY RUST AND WITH SPECIFIC SERIOUS DAMAGE TO REAR STRUTS BASE. WHOLE PIECE SUPPORTING STRUT BASE BROKEN COMPLETELY BROKEN AROUND AND SUNK IN CREATING LOUD NOISE WITH THE LIST IMPACT. I HAVE SEVERAL PICTURES AS PROOF.
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 45 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED THAT THE REAR PASSENGER SIDE FRAME WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWAR…
Read full complaint
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 45 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED THAT THE REAR PASSENGER SIDE FRAME WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 161,000.
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE VEERED TO THE LEFT AND RIGHT BEFORE WOBBLING VIOLENTLY. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE OF THE FRAME WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 1998 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE VEERED TO THE LEFT AND RIGHT BEFORE WOBBLING VIOLENTLY. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE OF THE FRAME WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.
THE FRAME OR THE CHASSIS AND ALL AROUND IT ARE HEAVILY CORRODED THAT I WAS ADVISED BY THE INSPECTOR AND THE TIRE PLACE (COSTCO) WHERE I BROUGHT THE CAR FOR TIRE REPLACEMENT NOT TO DRIVE IT AS IT IS UNSAFE. I UNDERSTAND THAT THE TOYOTA TACOMA OF THE SAME YEAR WITH THE SAME KIND OH CHASSIS WAS RECALLED BY TOYOTA. MY QUESTION IS…
Read full complaint
THE FRAME OR THE CHASSIS AND ALL AROUND IT ARE HEAVILY CORRODED THAT I WAS ADVISED BY THE INSPECTOR AND THE TIRE PLACE (COSTCO) WHERE I BROUGHT THE CAR FOR TIRE REPLACEMENT NOT TO DRIVE IT AS IT IS UNSAFE. I UNDERSTAND THAT THE TOYOTA TACOMA OF THE SAME YEAR WITH THE SAME KIND OH CHASSIS WAS RECALLED BY TOYOTA. MY QUESTION IS WHY NOT DO THE SAME FOR THE 4RUNNER?
I OWN A WONDERFUL 1998 TOYOTA 4RUNNER LTD SPORT VEHICLE. THE FRAME IS DISAPPEARING DUE TO SEVERE RUST. THE HEAT SHIELD HAS WORN AWAY, AND NOW MY FEET GET VERY HOT AFTER JUST 20 MINUTES OF LOCAL DRIVING. HAVE HAD IT CHECKED BY A GARAGE, NOTHING FUNCTIONALLY WRONG WITH MY SUV.
Official recalls
102V021000 · Suspension
Jan 18, 2002
ON CERTAIN 2-WHEEL-DRIVE (2WD) AND 4-WHEEL-DRIVE (4WD) 4RUNNER SPORT UTILITY VEHICLES, A COMBINATION OF HEAVY LOADING (SIMULTANEOUS LOADING TO REAR GROSS AXLE WEIGHT RATING AND GROSS VEHICLE WEIGHT RATING) AND SEVERE STEERING MANEUVERS COULD CAUSE THE 2WD 4RUNNER TO LOSE DIRECTIONAL STABILITY.
Consequence & remedy
Consequence: THIS MAY RESULT IN A LOSS OF CONTROL AND COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE REAR SUSPENSION PARTS. ALTHOUGH THE 4WD 4RUNNERS DO NOT EXHIBIT THE HANDLING CONDITION, TOYOTA WILL RECALL THESE VEHICLES TO AVOID ANY PUBLIC CONFUSION AS TO WHICH VEHICLES SHOULD RECEIVE THE REPLACEMENT PARTS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.