NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
24 reportsClear category filterMileage unknown · Sep 14, 2026
Electrical SystemExterior LightingService Brakes
Water entusion in the tail light bar. After time causes corrosion of the circuit board on the turn rear turn signal making it inoperable. tesla doesn't have an open document nor a recall. Was quoted over $1300 to replace the assembly. I did a teardown of the root cause. Glue sealing the through hole for the clip that holds the…
Read full complaint
Water entusion in the tail light bar. After time causes corrosion of the circuit board on the turn rear turn signal making it inoperable. tesla doesn't have an open document nor a recall. Was quoted over $1300 to replace the assembly. I did a teardown of the root cause. Glue sealing the through hole for the clip that holds the badge of the car on the rear didn't adhere. Water entered the assembly and dripped onto the circuit board, over time corrosion occurred. My rear left turn signal went out on a car that just turned a year. I have documented the location of the fault with pictures
NHTSA ODI #11764041
Mileage unknown · Aug 27, 2026
Service Brakes
Screen provides alert that "center brake light condition deteceted". Shows up as VCRIGHT_a487. Tesla has said it is a software condition that will be fixed in an update, yet several updates later, the condition persists with no fix in sight. This error has appeared since the time of new vehicle delivery in early May 2026 to the…
Read full complaint
Screen provides alert that "center brake light condition deteceted". Shows up as VCRIGHT_a487. Tesla has said it is a software condition that will be fixed in an update, yet several updates later, the condition persists with no fix in sight. This error has appeared since the time of new vehicle delivery in early May 2026 to the present.
NHTSA ODI #11760096
Mileage unknown · Aug 17, 2026
Forward Collision AvoidanceService BrakesCrash
On August 15, 2026, at approximately 5:00 PM, the vehicle was being driven with Full Self-Driving (Supervised) engaged during light rain. As the vehicle approached traffic ahead, it did not slow or brake as expected. The driver recognized that the vehicle was not slowing and attempted to intervene manually by pressing the brake…
Read full complaint
On August 15, 2026, at approximately 5:00 PM, the vehicle was being driven with Full Self-Driving (Supervised) engaged during light rain. As the vehicle approached traffic ahead, it did not slow or brake as expected. The driver recognized that the vehicle was not slowing and attempted to intervene manually by pressing the brake pedal multiple times. The driver reports that despite these attempts, the vehicle did not slow or respond to the brake pedal as expected, and a collision occurred. There were no known warning lamps or warning messages indicating a braking-system problem prior to the incident. The vehicle has not yet been inspected to determine the cause of the reported braking behavior. The incident has been reported to the manufacturer, and a request has been made to preserve and review available vehicle data surrounding the collision, including braking inputs, vehicle speed, Full Self-Driving status/actions, warnings, diagnostic information, and safety/event data. The vehicle is available for inspection. At this time, the cause of the failure to slow as expected is UNKNOWN.
NHTSA ODI #11757356
Mileage unknown · Jul 30, 2026
Electrical SystemService BrakesInjury
My tesla model Y was driving on FSD (full self driving) and just did hard full stop brake at a traffic light and brought the car to a complete stop even when the light was green. Both of toddler kids in the back got pulled jolted forward where the seat belt hurt them. This stopping was random was unnecessary as no threat of othe…
Read full complaint
My tesla model Y was driving on FSD (full self driving) and just did hard full stop brake at a traffic light and brought the car to a complete stop even when the light was green. Both of toddler kids in the back got pulled jolted forward where the seat belt hurt them. This stopping was random was unnecessary as no threat of other cars or the light was present. Luckily no one was behind us or they would have rear ended our car causing a serious accident. This really left my children in shock.
NHTSA ODI #11753870
Mileage unknown · Jul 29, 2026
Forward Collision AvoidanceService Brakes
2026 Tesla Model Y (VIN [XXX]) running FSD Supervised v14.2.2.5 / software 2026.14.200 experienced two unintended phantom braking events while FSD was active. Incident 1: XXX, approximately 9:16 AM, XXX southbound off-ramp at [XXX] exit heading [XXX]. Vehicle braked abruptly and without warning at highway approach speed with no …
Read full complaint
2026 Tesla Model Y (VIN [XXX]) running FSD Supervised v14.2.2.5 / software 2026.14.200 experienced two unintended phantom braking events while FSD was active. Incident 1: XXX, approximately 9:16 AM, XXX southbound off-ramp at [XXX] exit heading [XXX]. Vehicle braked abruptly and without warning at highway approach speed with no obstacle present. Incident 2: XXX, approximately 2:08 PM, [XXX] westbound atXXX northbound on-ramp [XXX]. Same abrupt, unwarned braking with no obstacle present. Tesla service performed diagnostics XXX, at the Delray Beach service center. No hardware fault was found. Vehicle has been unable to receive OTA software updates. A nearly identical vehicle, a 2026 Tesla Model Y in the same household (VIN [XXX]), is currently running software 2026.20.6.11 and FSD v14.3.6, several versions ahead of the affected vehicle. Tesla confirmed the software disparity is due to VIN batch rollout scheduling and cannot be manually accelerated. Tesla regional management and engineering review team have been notified. While children were not in the vehicle at the time of these specific incidents, they are frequent passengers in this vehicle and this braking behavior represents a serious safety concern for our family. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11753635
Mileage unknown · Jun 6, 2026
Electrical SystemService BrakesSteering
I purchased a new 2026 Tesla Model Y Standard and took delivery on approximately 30 May 2026. Within the first week of ownership, the vehicle displayed multiple safety-related warnings, including: * Steering Assist Reduced * Power Braking Assist Reduced * Automatic Emergency Braking Unavailable * Lane Departure Avoidance Featur…
Read full complaint
I purchased a new 2026 Tesla Model Y Standard and took delivery on approximately 30 May 2026. Within the first week of ownership, the vehicle displayed multiple safety-related warnings, including: * Steering Assist Reduced * Power Braking Assist Reduced * Automatic Emergency Braking Unavailable * Lane Departure Avoidance Features Unavailable * Automatic Vehicle Hold Disabled The warnings have occurred more than once. They initially disappeared and then returned on a later drive. Both incidents occurred while the vehicle was operating with Full Self-Driving (FSD) engaged. During the most recent occurrence, while parking at less than 3 mph, the vehicle’s braking assistance appeared reduced and the brake pedal required significantly more effort than normal. As a result, I nearly struck a curb because the vehicle did not slow as expected. The warnings indicated that increased steering and braking effort may be required. Because the vehicle is brand new and these warnings involve steering, braking, and collision-avoidance systems, I believe this creates a significant safety risk. I no longer feel the vehicle is safe to drive until it is inspected and repaired. Tesla has been notified and a service request has been initiated.
NHTSA ODI #11742507
Mileage unknown · May 29, 2026
Service BrakesSuspension
Service Concern — Front Suspension / Rattling Noise Vehicle is experiencing a persistent rattling/knocking noise from the front area when driving over bumps, uneven pavement, or rough roads. Noise is noticeable at low to moderate speeds and appears suspension-related. Condition seems consistent with known Tesla Model Y service …
Read full complaint
Service Concern — Front Suspension / Rattling Noise Vehicle is experiencing a persistent rattling/knocking noise from the front area when driving over bumps, uneven pavement, or rough roads. Noise is noticeable at low to moderate speeds and appears suspension-related. Condition seems consistent with known Tesla Model Y service concerns regarding: * front upper control arm mounts, * front damper assemblies, * and wiper bracket pencil braces. Requesting inspection and evaluation of: * front suspension components, * damper assemblies, * upper control arm mounts, * and any applicable Tesla Service Bulletins related to front-end NVH/rattling concerns. Noise has become increasingly noticeable during normal driving conditions and is affecting ride quality. Please document findings and advise whether repairs are covered under warranty. The symptoms typically include: * Rattling noise over small bumps * Knocking or clunking from the front suspension * Noise on rough pavement, speed bumps, or uneven roads * Sometimes vibration or looseness felt near the dashboard/firewall area The repair procedure mentioned is consistent with a Tesla internal service approach for addressing front-end NVH issues (Noise, Vibration, Harshness). Here’s what each item means: Front Upper Control Arm Mounts These are suspension mounting components near the top of the front wheel assembly. If worn, loose, or improperly isolated, they can create: * Metallic knocking * Clicking during suspension travel * Vibration transferred into the cabin Replacing them helps stabilize suspension movement. Front Damper Assemblies The dampers (shock absorbers/struts) control suspension rebound and compression. Faulty or noisy dampers can produce: * Hollow clunks * Rattles over expansion joints * Repetitive knocking on rough roads Replacing the assemblies usually resolves internal damper noise. Wiper Bracket “Pencil Braces” These braces sit beneath the cowl/wiper assembly area. On some vehicles they c
NHTSA ODI #11740760
Mileage unknown · Apr 20, 2026
Forward Collision AvoidanceService BrakesStructureCrashInjury
On April 11 2026, I was involved in a serious accident involving my 2026 Tesla Model Y. At the time of the incident, I was returning home from my daughter’s event in downtown and had just entered my residential driveway. As I approached the driveway, I applied the brakes and slowed the vehicle. While momentarily stationary or ne…
Read full complaint
On April 11 2026, I was involved in a serious accident involving my 2026 Tesla Model Y. At the time of the incident, I was returning home from my daughter’s event in downtown and had just entered my residential driveway. As I approached the driveway, I applied the brakes and slowed the vehicle. While momentarily stationary or near-stationary, I spoke to my wife, who was seated in the front passenger seat, advising her to secure the food she was holding due to the uneven surface of the driveway. Upon removing my foot from the brake pedal, the vehicle suddenly and unexpectedly accelerated without any input . The vehicle proceeded forward and collided with my garage door. Notably, no collision warning alerts were issued, and no automatic emergency braking system engaged prior to or during the impact. Following the initial collision with garage door, the vehicle failed to stop and instead continued to accelerate into the garage, striking a refrigerator. The impact resulted in substantial damage to the refrigerator and caused extensive structural harm to the property, affecting the garage, adjacent living space, floors, and interior walls. The severity of the collision triggered deployment of the front airbags. At the time, my wife was seated in the front passenger seat, and my [XXX] daughter, along with her friend, was seated in the rear of the vehicle. Emergency services were called, I have forehead bruises and a burn on my hand from airbag deployment. My wife is advised physiotherapy for severe back pain and my daughter has since experienced ongoing emotional distress, nightmares.I am dealing with car and home claims issues for damages I am seeking a formal investigation into the cause of this incident, specifically addressing: 1)The unexpected and unintended acceleration of the vehicle 2)The failure of the vehicle to stop after the initial collision with the garage door 3)The absence of forward collision warnings and failure of automatic emergency braking . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFO
NHTSA ODI #11732416
Mileage unknown · Mar 25, 2026
Electrical SystemForward Collision AvoidanceService Brakes
On March 23, 2026, my vehicle experienced a sudden and simultaneous failure of multiple critical safety systems without any prior warning. The alerts displayed included: Automatic Emergency Braking unavailable, traction control disabled, stability control disabled, and additional driver-assistance features becoming unavailable. …
Read full complaint
On March 23, 2026, my vehicle experienced a sudden and simultaneous failure of multiple critical safety systems without any prior warning. The alerts displayed included: Automatic Emergency Braking unavailable, traction control disabled, stability control disabled, and additional driver-assistance features becoming unavailable. This incident created a serious safety hazard, as the loss of these systems significantly reduces vehicle stability and braking assistance, increasing the risk of loss of control, especially at highway speeds or in adverse weather conditions. In addition, the front-facing camera exhibits fogging and reduced visibility during cloudy and rainy conditions, which further impacts the reliability of safety and driver-assistance systems. Based on my research, similar issues have been reported by other Tesla owners, suggesting this may not be an isolated incident but a potential pattern defect. I am concerned about the safety of operating this vehicle and request that this matter be investigated for potential defects affecting critical safety systems.
NHTSA ODI #11727101
Mileage unknown · Mar 15, 2026
Service BrakesCrash
I've noticed periodically when the car is braking at start stop traffic in autopilot mode, the brake is very jerky and I can actually hear the pedal jerking and engaging. I wrote it off at the time in my head as normal operation of the car. I have brake pressure offset codes and brake booster mia codes. Sometimes I've noticed wh…
Read full complaint
I've noticed periodically when the car is braking at start stop traffic in autopilot mode, the brake is very jerky and I can actually hear the pedal jerking and engaging. I wrote it off at the time in my head as normal operation of the car. I have brake pressure offset codes and brake booster mia codes. Sometimes I've noticed when I brake, randomly the pedal is super stiff and it feels like the car is driving on ice, as if the brakes aren't working or slowing me down at all, but I thought nothing of it at the time. Today on the 14th, I got into an accident at a relatively slow speed that in any other scenario I should have been able to stop. Yet I hit a parked car because as I was braking, I felt the pedal go very very stiff and unresponsive, and I carried the same speed as when I started braking right until impact, it seems as if I didn't slow down one bit. The brakes did not respond as they did mere seconds before and I hit a parked car. I understand teslas may throw codes left and right in service mode that may mean nothing, but I am worried about the brake booster code and wonder if maybe it caused the accident I was involved in. My friends told me they heard about tesla brake issues and that I should look into it and when I went to go check the codes hours later there they were.
NHTSA ODI #11724394
Official recalls
8Aug 31, 2026
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence & remedy
Consequence: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Additional source detail variants (2)
Suspension:critical Fasteners
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Suspension:front
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Jul 7, 2026
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence & remedy
Consequence: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
Additional source detail variants (2)
Structure:body:bumpers
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
Air Bags:knee Bolster
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
May 18, 2026
Tesla, Inc. (Tesla) is recalling certain 2025-2026 Model Y vehicles. The certification label may not have been installed. As such, these vehicles fail to comply with the requirements of 49 C.F.R. Part 567, "Certification."
Consequence & remedy
Consequence: Missing weight information provided by the label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: Tesla Service will inspect and install a certification label as necessary, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-19-002.
Oct 10, 2025
Tesla, Inc. (Tesla) is recalling certain 2025 Model 3 and 2026 Model Y vehicles. The battery pack contactors may fail, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power can increase the risk of a crash.
Remedy: Tesla Service will replace the battery pack contactors, free of charge. Owner notification letters were mailed December 9, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-16-005.
Oct 1, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Additional source detail variants (2)
Electrical System:wiring
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Exterior Lighting:back Up Lights
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Jul 28, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The ring terminal of the horn ground wire may be improperly secured, allowing the circuit to open and preventing the horn from sounding.
Consequence & remedy
Consequence: An inoperable horn may prevent the driver from alerting other drivers as needed, increasing the risk of a crash.
Remedy: Tesla service will replace the steering wheel, free of charge. Owner notification letters were be mailed September 23, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-009.
Jun 18, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model 3 and Model Y vehicles. The fasteners attaching the seat back to the seat bottom may have been improperly tightened.
Consequence & remedy
Consequence: The seat may not properly restrain the occupant, increasing the risk of injury during a crash.
Remedy: Tesla Service Centers will inspect and tighten or replace the seat assembly fasteners as necessary, free of charge. Owner notification letters were mailed August 16, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-13-003.
May 29, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The hose connector may block the windshield washer nozzles, preventing washer fluid from reaching the windshield. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 104, "Windshield Wiping and Washing Systems."
Consequence & remedy
Consequence: The inability to clean the windshield reduces the driver’s visibility and increases the risk of a crash.
Remedy: Tesla service will inspect and replace the wiper arm elbow connector as necessary, free of charge. Owner notification letters were mailed July 25, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-20-001.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26002 · Fsd Collisions In Reduced Roadway Visibility Conditions
Opened Mar 18, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and capabilities of the updates, and Tesla’s assessment of their safety impact. Tesla’s FSD is an advanced driver assistance system (ADAS) that relies exclusively on vision-based cameras and the related FSD software to detect and respond to the roadway ahead, projecting a path forward based on traffic control devices, vehicles, pedestrians, and the roadway itself. When Tesla began transitioning away from using both cameras and radars to an exclusively camera-based approach, known as Tesla Vision, in mid-2021, it developed and implemented a degradation detection system that it deployed by a software update to existing and new Tesla vehicles. On June 28, 2024, the day after Tesla submitted the SGO report of the November 28, 2023 fatal crash listed in this document, Tesla began developing an update to the degradation detection system. At this time, ODI does not have information on when the update was deployed and which vehicles have the updated system. ODI discussed individual incidents and its initial findings during the PE phase of its investigation with Tesla. As part of those discussions, Tesla’s post-incident analysis indicated that the update to the degradation detection system, had it been installed on the vehicles at the time, may have affected 3 of the 9 incidents identified by ODI. Tesla also described internal data and labeling limitations that prevented a uniform identification and analysis of crash events with the subject system engaged. ODI believes this limitation could have led to under-reporting of subject crashes over portions of the defined time-period. Available incident data raise concerns that Tesla’s degradation detection system, both as originally deployed and later updated, fails to detect and/or warn the driver appropriately under degraded visibility conditions such as glare and airborne obscurants. In the crashes that ODI has reviewed, the system did not detect common roadway conditions that impaired camera visibility and/or provide alerts when camera performance had deteriorated until immediately before the crash occurred. Review of Tesla’s responses revealed additional crashes that occurred in similar environments and where the system either did not detect a degraded state, and/or it did not present the driver with an alert with adequate time for the driver to react. In each of these crashes, FSD also lost track of or never detected a lead vehicle in its path. In upgrading PE24031 to an Engineering Analysis (EA), ODI will gather further information on the updated degradation detection system, including the status of updating vehicles and scope of compatible vehicles, the system’s visibility degradation detection capability, and alerts or warnings to the driver. Lastly, ODI will conduct analysis on six recent potentially related incidents. These incidents can be found at NHTSA.gov under the following SGO report identification numbers: 13781-11937, 13781-13211, 13781-13569, 13781-13633, 13781-13693, 13781-13788. The crashes included in the failure report summary can be found at NHTSA.gov under the following SGO report identification numbers: 13781-8004, 13781-7181, 13781-7381, 13781-7767, 13781-7964, 13781-8977, 13781-9267.
PE25012 · Traffic Safety Violations While Full Self Driving ("fsd") Is Engaged
Opened Oct 7, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects of the driving task, requiring a driver to supervise and intervene as necessary. The driver remains fully responsible at all times for driving the vehicle, including complying with applicable traffic laws. ODI’s investigation will therefore focus, in particular, on whether certain driving inputs within the control authority of FSD forestall the driver’s supervision when they are unexpectedly performed. ODI has identified a number of incidents in which the inputs to the dynamic driving task commanded by FSD induced vehicle behavior that violated traffic safety laws. Although reports of this nature span a variety of behaviors, the reports appear to most commonly involve two types of scenarios. The first type of scenario involves a vehicle operating with FSD proceeding into an intersection in violation of a red traffic signal. The second type of scenario involves FSD commanding a lane change into an opposing lane of traffic. With respect to the first type of scenario, ODI has identified 18 complaints and 1 media report alleging that a Tesla vehicle, operating at an intersection with FSD engaged, failed to remain stopped for the duration of a red traffic signal, failed to stop fully, or failed to accurately detect and display the correct traffic signal state in the vehicle interface. Some complainants also alleged that FSD did not provide warnings of the system's intended behavior as the vehicle was approaching a red traffic signal. ODI has identified six Standing General Order ("SGO") reports in which a Tesla vehicle, operating with FSD engaged, approached an intersection with a red traffic signal, continued to travel into the intersection against the red light and was subsequently involved in a crash with other motor vehicles in the intersection. Of these incidents, four crashes resulted in one or more reported injuries. At least some of the incidents appeared to involve FSD proceeding into the intersection after coming to a complete stop. ODI's pre-investigative work, including coordination with the Maryland Transportation Authority and State Police, indicated that the problem may be repeatable, given that multiple subject incidents occurred at the same intersection in Joppa, Maryland. NHTSA understands that Tesla has since taken action to address the issue at this intersection. With respect to the second type of scenario, ODI has identified 2 SGO reports, 18 complaints, and 2 media reports alleging that a Tesla vehicle, operating with FSD engaged, entered opposing lanes of travel during or following a turn, crossed double-yellow lane markings while proceeding straight, or attempted to turn onto a road in the wrong direction despite the presence of wrong-way road signs. Likewise, ODI has identified 4 SGO reports, 6 complaints, and 1 media report alleging that a Tesla vehicle, operating with FSD engaged, proceeded straight through an intersection in a turn-only lane or executed a turn at an intersection in a through lane despite the presence of lane markings or signals. Complaints also alleged that FSD did not provide warnings of the system's intended behavior. Some complaints alleged that more than one of these failures occurred and, as such, the numbers are not cumulative. Some of the reported incidents appeared to involve FSD executing a lane change into an opposing lane of travel with little notice to a driver or opportunity to intervene. ODI’s review will assess whether there was prior warning or adequate time for the driver to respond to the unexpected behavior or to safely supervise the automated driving task. This review will assess any warnings to the driver about the system's impending behavior; the time given to drivers to respond; the capability of FSD to detect, display to the driver, and respond appropriately to traffic signals; and the capability of FSD to detect and respond to lane markings and wrong-way signage. NHTSA's review will also consider any updates or modifications to the system(s) that may affect the performance of FSD with respect to obeying traffic safety laws and signals. This assessment will focus, in particular, on the types of traffic safety violations described above, as most reports identified thus far have centered around those behaviors. While the behaviors under investigation appear to occur most frequently at intersections, NHTSA’s investigation will encompass any other types of situations in which this behavior may arise, such as when traveling adjacent to a lane of opposing traffic or when approaching railroad crossings. If other evidence received during this investigation involve other types of traffic safety violations, those may be considered as part of this assessment as well. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov. The SGO reports cited in this Resume are listed below by report ID and are available for download at NHTSA.gov/laws-regulations/standing-general-order-crash-reporting. 13781-8739-1, 13781-8995-1, 13781-9623-1, 13781-10333-1, 13781-10872-1, 13781-10930-1, 13781-10939-1, 13781-10941-1, 13781-11069-1, 13781-11305-1, 13781-11579-1 Media reported allegations included as a separate attachment.
AQ25002 · Compliance With Standing General Order 2021-01 Reporting Requirements
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a single batch, while others were submitted on a rolling basis. Preliminary engagement between ODI and Tesla on the issue indicates that the timing of the reports was due to an issue with Tesla’s data collection, which, according to Tesla, has now been fixed. NHTSA is opening this Audit Query, a standard process for reviewing compliance with legal requirements, to evaluate the cause of the potential delays in reporting, the scope of any such delays, and the mitigations that Tesla has developed to address them. As part of this review, NHTSA will assess whether any reports of prior incidents remain outstanding and whether the reports that were submitted include all of the required and available data. The SGO reports cited in the Opening Resume, can be found at NHTSA.gov/SGOCrashReporting under the following SGO 2021-01 report IDs: 13781-11020-1 13781-10844-1 13781-10843-1 13781-10530-1 13781-10160-1 13781-10159-1 13781-10157-1 13781-10146-1 13781-10122-1 13781-10098-1 13781-10097-1 13781-10096-1 13781-10095-1 13781-10094-1 13781-10093-1 13781-10023-1 13781-10022-1 13781-10021-1 13781-10020-1 13781-10017-1 13781-10016-1 13781-10015-1 13781-10014-1 13781-10013-1 13781-10012-1 13781-6047-1 13781-9930-1 13781-9917-1 13781-9928-1 13781-9925-1 13781-9924-1 13781-9923-1 13781-9922-1 13781-9835-1 13781-9834-1 13781-9833-1 13781-9832-1 13781-9831-1 13781-9830-1 13781-9829-1 13781-9827-1 13781-9818-1 13781-9780-1 13781-9779-1 13781-9778-1 13781-9777-1 13781-9775-1 13781-9774-1 13781-9773-1 13781-9772-1 13781-9771-1 13781-9770-1 13781-9728-1 13781-9688-1 13781-9715-1 13781-9714-1 13781-9713-1 13781-9712-1 13781-9711-1 13781-9710-1 13781-9709-1 13781-9696-1 13781-9695-1 13781-9694-1 13781-9693-1 13781-9692-1 13781-9691-1 13781-9690-1 13781-9687-1 13781-9686-1 13781-9342-1 13781-9319-1 13781-9019-1 13781-8910-1 13781-8732-1 13781-8712-1 13781-8310-1 13781-7897-1 13781-7895-1 13781-7835-1 13781-7798-1 13781-7797-1 13781-7758-1 13781-7757-1 13781-7756-1 13781-7755-1 13781-7667-1 13781-7399-1 13781-7398-1 13781-7397-1 13781-7396-1 13781-7395-1 13781-7394-1 13781-7393-1 13781-7389-1 13781-7388-1 13781-7387-1 13781-7386-1 13781-7385-1 13781-7383-1 13781-7187-1 13781-7186-1 13781-7185-1 13781-7184-1 13781-7181-1 13781-7023-1 13781-6399-1 13781-6389-1 13781-6388-1 13781-6387-1 13781-6386-1 13781-6379-1 13781-6378-1 13781-6377-1 13781-6375-1 13781-6214-1 13781-6172-1 13781-6155-1 13781-6154-1 13781-6122-1 13781-6120-1 13781-6118-1 13781-5800-1
PE24033 · Actually Smart Summon Sessions Resulting In low-speed Impacts.
Opened Jan 6, 2025 · Closed Apr 3, 2026
Status: closed (inferred from source dates) · Electrical System:adas:autonomous/self Driving
On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Summon reported crashes involved minor property damage claims with no reported incidents involving a vulnerable road user, injury, fatality, or major property damage as indicated by an air bag deployment or vehicle tow away. Out of millions of Summon sessions, a fraction of 1% resulted in an incident. Almost all those incidents took place where, typically early in a Summon session, the system or person using the app failed to fully detect or respond appropriately to vehicle surroundings resulting in minor impacts. Incidents took place when app users did not have a complete 360-degree view of the surroundings in the app to assess situational awareness. This limited the app user’s ability to determine whether an impact was imminent during initial vehicle maneuvers such as reversing in close proximity to an obstacle or a curb. ODI found that the impacts most often occurred with parking gates, adjacently parked vehicles, and short parking bollards. During this investigation, ODI identified two Summon crashes related to camera blockages. In both crashes, Summon attempted to navigate a snowy parking lot with snow partially or fully obstructing the forward-facing cameras. Summon did not detect the camera blockage and the vehicles collided with unoccupied parked vehicles while navigating the parking lot. App users in both instances did not command a vehicle stop or pause despite the obstructed camera visible in the camera stream in the app. On January 15, 2025, Tesla released Over-the-Air (OTA) Software (SW) Update Action numbers 578998 and 579185 for vehicles in service to implement a camera blockage detection condition. Both OTAs improve camera blockage detection mechanisms. Additionally, on January 20, 2025, and January 30, 2025, Tesla identified additional system requirements associated with camera visibility checks and released OTA SW-578752 and SW-580322, respectively. These firmware updates reduce false negative camera blockage detections due to snow or condensation. In its investigation, ODI identified one Summon incident where the vehicle did not yield for a gate arm blocking a garage exit lane and the app user did not command a vehicle stop or pause, resulting in an impact. On February 6, 2025, Tesla deployed OTA SW-578839 to improve vehicle reaction to dynamic gates. This OTA update upgraded vehicle perception systems through a high-fidelity occupancy determination network, which uses data from vehicle sensory systems to improve reconstruction of field objects with high accuracy. On November 20, 2025, Tesla further improved vehicle performance by adding object detections from a separate neural network through OTA SW-580514. Owners of the affected vehicles received all six OTA SW updates. Tesla also released these SW updates to production vehicles. See online public file for detailed descriptions of all six OTA SW updates. Due to low incident occurrence and low incident severity, this preliminary evaluation is closed. The closing of this investigation does not constitute a finding that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by future circumstances. For additional information regarding this investigation, see the complete online public file.
Illustration