NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
170 reports3,400 miles · Mar 5, 2025
Electrical System
The contact owns a 2024 Tesla Cybertruck. The contact stated that while waiting at a railroad track with the Full Self-Driving (FSD) feature activated, the destination was entered, and the railroad lights and gate were lowered when suddenly the Full Self-Driving (FSD) disengaged independently. The traffic light turned green, and…
Read full complaint
The contact owns a 2024 Tesla Cybertruck. The contact stated that while waiting at a railroad track with the Full Self-Driving (FSD) feature activated, the destination was entered, and the railroad lights and gate were lowered when suddenly the Full Self-Driving (FSD) disengaged independently. The traffic light turned green, and the driver was required to take control of the vehicle. During the independent disengagement of the Full Self-Driving (FSD) feature, the vehicle abruptly accelerated. The contact was concerned that the failure might have result in a crash, had he not taken control of the vehicle. The contact stated that he submitted a report through the vehicle App. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 3,400.
NHTSA ODI #11646534
5,149 miles · Mar 5, 2025
Air BagsElectrical SystemForward Collision AvoidanceCrashInjury
The contact owns a 2024 Tesla Cybertruck. The contact stated that while driving at 70 MPH with the "Full Self-Driving" (FSD) active, the vehicle ahead of the contact's vehicle abruptly slowed down. The contact began to notice that the vehicle failed to detect the vehicle slowing down and the contact attempted to manually stop th…
Read full complaint
The contact owns a 2024 Tesla Cybertruck. The contact stated that while driving at 70 MPH with the "Full Self-Driving" (FSD) active, the vehicle ahead of the contact's vehicle abruptly slowed down. The contact began to notice that the vehicle failed to detect the vehicle slowing down and the contact attempted to manually stop the vehicle. The contact crashed into the vehicle which resulted in a three-vehicle collision. The air bags failed to deploy upon impact; as a result, the contact hit her chest on the steering wheel. The contact was taken to the hospital via an ambulance and was treated for neck, back and chest pain. The two other vehicle occupants sustained both neck and back injuries but did not seek medical treatment. The whereabouts of the other drivers were unknown. A police report was filed(report unavailable). The vehicle was initially towed to an independent tow yard. The manufacturer was notified of the failure and later towed the vehicle to an authorized Tesla service center where it remained in their possession. The current condition of the vehicle remains unknown. The failure mileage was 5,149.
NHTSA ODI #11646503
Mileage unknown · Mar 3, 2025
Structure
The stainless steel trim piece above the windows is only attached by glue and comes loose. My front driver side came detached and the rear came loose on both sides. The piece would have completely fallen off and hit another vehicle if had I not noticed it and re attached it with construction adhesive. There is a whole forum abou…
Read full complaint
The stainless steel trim piece above the windows is only attached by glue and comes loose. My front driver side came detached and the rear came loose on both sides. The piece would have completely fallen off and hit another vehicle if had I not noticed it and re attached it with construction adhesive. There is a whole forum about it on the cybertruck owners club linked below. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11645930
Mileage unknown · Feb 27, 2025
Power TrainSteeringSuspension
Hello are you still in business or has Elon DOGED you already? No matter.... here's a CyberTruck in the junkyard. [XXX] The wheels have gone all whompy. Don't suppose you are bothered about it. Have a [XXX] day. Your friend [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11645396
Mileage unknown · Feb 25, 2025
Structure
A piece of the stainless steel body trim (right hand roof rail part #1860490-00-C) flew off the car at highway speeds. It looks like it was only held on by glue.
NHTSA ODI #11644923
2,000 miles · Feb 18, 2025
Electrical System
The contact owns a 2024 Tesla Cybertruck. The contact stated while driving 49 MPH with the Full Self-Driving (FSD) activated, the destination was entered, and the system announced the direction steps and suddenly the Full Self-Driving (FSD) disengaged independently causing the driver to be required to take control of the vehicle…
Read full complaint
The contact owns a 2024 Tesla Cybertruck. The contact stated while driving 49 MPH with the Full Self-Driving (FSD) activated, the destination was entered, and the system announced the direction steps and suddenly the Full Self-Driving (FSD) disengaged independently causing the driver to be required to take control of the vehicle. During the independent disengagement of the Full Self-Driving (FSD), the vehicle abruptly accelerated and almost struck another vehicle in a head-on collision. The contact was concerned that the failure could result in a crash if other vehicles were in the opposite direction. On a separate occasion, the contact stated that the Full Self-Driving (FSD) was engaged and driving at various speeds, and the vehicle independently maneuvered into oncoming traffic on a 2-lane road causing the contact to have to take control of the vehicle. A crash was avoided; however, the contact was concerned that if there had been a median barrier it could have resulted in a crash. In addition, the contact stated there was a second occasion where the vehicle was in Full Self-Driving (FSD) and veered into oncoming traffic, and manual control of the vehicle was required. The failure was not recorded via the Tesla App. A dealer was contacted, and a service appointment was scheduled for a diagnostic test. The Tesla Service Advisor informed the contact that there was nothing in the systems logs that there was an error, and the dealer was not able to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure several times. The failure mileage was approximately 2,000.
NHTSA ODI #11643535
Mileage unknown · Feb 14, 2025
Structure
on [XXX], I was driving my cybertruck on highway, at speed 55mph. the stainless panel on driver side, the one, on top of the windows, suddenly start falling off. This is the first winter for cybertruck. the stainless panel is hard and sharp enough to hit other cars. I pulled the car over. Please see my pictures below. Also, i i…
Read full complaint
on [XXX], I was driving my cybertruck on highway, at speed 55mph. the stainless panel on driver side, the one, on top of the windows, suddenly start falling off. This is the first winter for cybertruck. the stainless panel is hard and sharp enough to hit other cars. I pulled the car over. Please see my pictures below. Also, i included the youtube link here for your reference. [XXX] This is a serious safety issue. because the body side's stainless panels are glued on the frame with some kind of adhesive, metal to metal, and the nuts hold the frame to the body. Due to the cold temperature and the glued dry up. the stainless panels start falling off. i took a pictures of the new parts to proof that the stainless panel is glued by adhesive to the black frame INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11642765
Mileage unknown · Feb 8, 2025
Structure
Upper passanger trim piece fell off while driving on street, could have hurt another motorist. When new piece was fixed by Tesla service center, I advised them to replace drivers side just in case and they stated they will not be able to until it falls off. This trim comes in two pieces, one is bolted to the truck and the oth…
Read full complaint
Upper passanger trim piece fell off while driving on street, could have hurt another motorist. When new piece was fixed by Tesla service center, I advised them to replace drivers side just in case and they stated they will not be able to until it falls off. This trim comes in two pieces, one is bolted to the truck and the other is glued onto the bolted piece, the glued piece peeled off. Here is a youtube video showing in more detail the problem. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11641488
Mileage unknown · Feb 3, 2025
Visibility/wiper
On [XXX], while driving highways for over 2 hours, the windshield became very dirty with dried debris from the road. I activated the window cleaning function on the steering wheel ( for the first time) and could not clear the dirt from the passenger side. I tried many times, but no result. The drivers side did clean acceptabl…
Read full complaint
On [XXX], while driving highways for over 2 hours, the windshield became very dirty with dried debris from the road. I activated the window cleaning function on the steering wheel ( for the first time) and could not clear the dirt from the passenger side. I tried many times, but no result. The drivers side did clean acceptably. But not the passenger side! I could see arcs on the windshield where the wiper attempted to drop fluid. There were 8 or 9 such arcs left after the wiper withdrew. I did see cleaning solvent near the outside of the windshield. But I could not see out of the windshield. Reported same to Teslas customer svc and a service visit was scheduled for Jan. 8, 2025. By this time I had manually cleaned the window and verified the solvent well was full. Svc agent said, no one else complaining and system is operating 100% as designed. Experienced same situation again on [XXX]. Customer svc again scheduled an on site svc call for Feb 7 2025. I then saw on facebook, over 50 other people complaining of exactly the same problem. Most had tried svc and heard the same informational as I. Some included photos of the problem, some had their wiper or pump replaced, other e told that Tesla was planning an OTA update to cure the problem. I did a walk-in to svc on Jan 27,2025, and was told there is no guidance from corporate on this matter and that as far as they knew, corporate was not aware of the problem. I'll keep my appointment on Fri and hopefully I'll have some relief. I hate not seeing things coming from my right side! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11640313
Mileage unknown · Feb 2, 2025
Exterior Lighting
When driving in a winter storm, headlights quickly become snow packed rendering them useless. This is extremely dangerous driving in any snowstorm at night. The light bar does not provide sufficient visibility at night and also can become ice packed.
NHTSA ODI #11640248
Official recalls
11Apr 21, 2026
Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles equipped with 18-inch steel wheels. The brake rotor stud holes may crack and allow the stud to separate from the wheel hub.
Consequence & remedy
Consequence: Wheel stud separation can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Tesla Service will replace the front and rear brake rotors, hubs, and lug nuts, free of charge. Owner notification letters were mailed June 20, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-33-003.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:disc:rotor
Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles equipped with 18-inch steel wheels. The brake rotor stud holes may crack and allow the stud to separate from the wheel hub.
Consequence: Wheel stud separation can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Tesla Service will replace the front and rear brake rotors, hubs, and lug nuts, free of charge. Owner notification letters were mailed June 20, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-33-003.
Wheels:lugs/nuts/bolts/studs
Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles equipped with 18-inch steel wheels. The brake rotor stud holes may crack and allow the stud to separate from the wheel hub.
Consequence: Wheel stud separation can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Tesla Service will replace the front and rear brake rotors, hubs, and lug nuts, free of charge. Owner notification letters were mailed June 20, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-33-003.
Oct 27, 2025
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles equipped with a service-installed off-road light bar accessory. An incorrect surface primer may have been used to attach the lightbar to the windshield, causing the light bar to loosen and detach.
Consequence & remedy
Consequence: A detached light bar may fall, creating a road hazard for other vehicles and increasing the risk of a crash.
Remedy: Tesla Service will inspect the light bar and install an additional mechanical attachment or replace the light bar using tape to adhere the light bar to the windshield as well as an additional mechanical attachment as necessary, free of charge. Owner notification letters were mailed April 9, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-90-001.
Oct 14, 2025
Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles operating software prior to 2025.38.3. The vehicle controller software may cause the front parking lights to be too bright and exceed the maximum light output, adversely affecting the vision of other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Parking lights that are too bright can reduce visibility of oncoming drivers, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 12, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-008.
Additional source detail variants (2)
Exterior Lighting
Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles operating software prior to 2025.38.3. The vehicle controller software may cause the front parking lights to be too bright and exceed the maximum light output, adversely affecting the vision of other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Parking lights that are too bright can reduce visibility of oncoming drivers, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 12, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-008.
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles operating software prior to 2025.38.3. The vehicle controller software may cause the front parking lights to be too bright and exceed the maximum light output, adversely affecting the vision of other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Parking lights that are too bright can reduce visibility of oncoming drivers, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 12, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-008.
Mar 18, 2025
Tesla, Inc. (Tesla) is recalling certain 2024-2025 Cybertruck vehicles. The light bar can delaminate and detach from the vehicle.
Consequence & remedy
Consequence: A detached light bar can become a road hazard, increasing the risk of a crash.
Remedy: Tesla service will replace the cant rail assembly, free of charge. Owner notification letters were mailed September 19, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-10-001.
Dec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Driving with improperly inflated tires increases the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Nov 5, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. A fault in the drive inverter may cause a loss of drive power to the wheels.
Consequence & remedy
Consequence: A loss of drive power can increase the risk of a crash.
Remedy: Tesla service will replace the drive inverter, free of charge. Owner notification letters were mailed January 4, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-40-009.
Sep 26, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. The rearview camera image may be delayed after shifting into reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed rearview image reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed November 25, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-016.
Jun 19, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. Excessive electrical current can cause the front windshield wiper motor controller to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Tesla service will replace the wiper motor, free of charge. Owner notification letters were mailed October 1, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-006.
Jun 19, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. The trunk bed trim sail applique could have been improperly adhered and can loosen.
Consequence & remedy
Consequence: A loose applique can detach from the vehicle, creating a road hazard for following motorists and increasing the risk of a crash.
Remedy: Tesla service will apply adhesion promoter and pressure sensitive tape or replace missing applique as necessary, free of charge. Owner notification letters were mailed August 18, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-12-006.
Apr 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. The accelerator pedal pad may dislodge and cause the pedal to become trapped by the interior trim.
Consequence & remedy
Consequence: A trapped accelerator pedal can cause the vehicle to accelerate unintentionally, increasing the risk of a crash.
Remedy: Tesla service will replace or repair the accelerator pedal assembly, free of charge. Owner notification letters were mailed June 18, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-33-003.
Jan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26002 · Fsd Collisions In Reduced Roadway Visibility Conditions
Opened Mar 18, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and capabilities of the updates, and Tesla’s assessment of their safety impact. Tesla’s FSD is an advanced driver assistance system (ADAS) that relies exclusively on vision-based cameras and the related FSD software to detect and respond to the roadway ahead, projecting a path forward based on traffic control devices, vehicles, pedestrians, and the roadway itself. When Tesla began transitioning away from using both cameras and radars to an exclusively camera-based approach, known as Tesla Vision, in mid-2021, it developed and implemented a degradation detection system that it deployed by a software update to existing and new Tesla vehicles. On June 28, 2024, the day after Tesla submitted the SGO report of the November 28, 2023 fatal crash listed in this document, Tesla began developing an update to the degradation detection system. At this time, ODI does not have information on when the update was deployed and which vehicles have the updated system. ODI discussed individual incidents and its initial findings during the PE phase of its investigation with Tesla. As part of those discussions, Tesla’s post-incident analysis indicated that the update to the degradation detection system, had it been installed on the vehicles at the time, may have affected 3 of the 9 incidents identified by ODI. Tesla also described internal data and labeling limitations that prevented a uniform identification and analysis of crash events with the subject system engaged. ODI believes this limitation could have led to under-reporting of subject crashes over portions of the defined time-period. Available incident data raise concerns that Tesla’s degradation detection system, both as originally deployed and later updated, fails to detect and/or warn the driver appropriately under degraded visibility conditions such as glare and airborne obscurants. In the crashes that ODI has reviewed, the system did not detect common roadway conditions that impaired camera visibility and/or provide alerts when camera performance had deteriorated until immediately before the crash occurred. Review of Tesla’s responses revealed additional crashes that occurred in similar environments and where the system either did not detect a degraded state, and/or it did not present the driver with an alert with adequate time for the driver to react. In each of these crashes, FSD also lost track of or never detected a lead vehicle in its path. In upgrading PE24031 to an Engineering Analysis (EA), ODI will gather further information on the updated degradation detection system, including the status of updating vehicles and scope of compatible vehicles, the system’s visibility degradation detection capability, and alerts or warnings to the driver. Lastly, ODI will conduct analysis on six recent potentially related incidents. These incidents can be found at NHTSA.gov under the following SGO report identification numbers: 13781-11937, 13781-13211, 13781-13569, 13781-13633, 13781-13693, 13781-13788. The crashes included in the failure report summary can be found at NHTSA.gov under the following SGO report identification numbers: 13781-8004, 13781-7181, 13781-7381, 13781-7767, 13781-7964, 13781-8977, 13781-9267.
PE25012 · Traffic Safety Violations While Full Self Driving ("fsd") Is Engaged
Opened Oct 7, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects of the driving task, requiring a driver to supervise and intervene as necessary. The driver remains fully responsible at all times for driving the vehicle, including complying with applicable traffic laws. ODI’s investigation will therefore focus, in particular, on whether certain driving inputs within the control authority of FSD forestall the driver’s supervision when they are unexpectedly performed. ODI has identified a number of incidents in which the inputs to the dynamic driving task commanded by FSD induced vehicle behavior that violated traffic safety laws. Although reports of this nature span a variety of behaviors, the reports appear to most commonly involve two types of scenarios. The first type of scenario involves a vehicle operating with FSD proceeding into an intersection in violation of a red traffic signal. The second type of scenario involves FSD commanding a lane change into an opposing lane of traffic. With respect to the first type of scenario, ODI has identified 18 complaints and 1 media report alleging that a Tesla vehicle, operating at an intersection with FSD engaged, failed to remain stopped for the duration of a red traffic signal, failed to stop fully, or failed to accurately detect and display the correct traffic signal state in the vehicle interface. Some complainants also alleged that FSD did not provide warnings of the system's intended behavior as the vehicle was approaching a red traffic signal. ODI has identified six Standing General Order ("SGO") reports in which a Tesla vehicle, operating with FSD engaged, approached an intersection with a red traffic signal, continued to travel into the intersection against the red light and was subsequently involved in a crash with other motor vehicles in the intersection. Of these incidents, four crashes resulted in one or more reported injuries. At least some of the incidents appeared to involve FSD proceeding into the intersection after coming to a complete stop. ODI's pre-investigative work, including coordination with the Maryland Transportation Authority and State Police, indicated that the problem may be repeatable, given that multiple subject incidents occurred at the same intersection in Joppa, Maryland. NHTSA understands that Tesla has since taken action to address the issue at this intersection. With respect to the second type of scenario, ODI has identified 2 SGO reports, 18 complaints, and 2 media reports alleging that a Tesla vehicle, operating with FSD engaged, entered opposing lanes of travel during or following a turn, crossed double-yellow lane markings while proceeding straight, or attempted to turn onto a road in the wrong direction despite the presence of wrong-way road signs. Likewise, ODI has identified 4 SGO reports, 6 complaints, and 1 media report alleging that a Tesla vehicle, operating with FSD engaged, proceeded straight through an intersection in a turn-only lane or executed a turn at an intersection in a through lane despite the presence of lane markings or signals. Complaints also alleged that FSD did not provide warnings of the system's intended behavior. Some complaints alleged that more than one of these failures occurred and, as such, the numbers are not cumulative. Some of the reported incidents appeared to involve FSD executing a lane change into an opposing lane of travel with little notice to a driver or opportunity to intervene. ODI’s review will assess whether there was prior warning or adequate time for the driver to respond to the unexpected behavior or to safely supervise the automated driving task. This review will assess any warnings to the driver about the system's impending behavior; the time given to drivers to respond; the capability of FSD to detect, display to the driver, and respond appropriately to traffic signals; and the capability of FSD to detect and respond to lane markings and wrong-way signage. NHTSA's review will also consider any updates or modifications to the system(s) that may affect the performance of FSD with respect to obeying traffic safety laws and signals. This assessment will focus, in particular, on the types of traffic safety violations described above, as most reports identified thus far have centered around those behaviors. While the behaviors under investigation appear to occur most frequently at intersections, NHTSA’s investigation will encompass any other types of situations in which this behavior may arise, such as when traveling adjacent to a lane of opposing traffic or when approaching railroad crossings. If other evidence received during this investigation involve other types of traffic safety violations, those may be considered as part of this assessment as well. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov. The SGO reports cited in this Resume are listed below by report ID and are available for download at NHTSA.gov/laws-regulations/standing-general-order-crash-reporting. 13781-8739-1, 13781-8995-1, 13781-9623-1, 13781-10333-1, 13781-10872-1, 13781-10930-1, 13781-10939-1, 13781-10941-1, 13781-11069-1, 13781-11305-1, 13781-11579-1 Media reported allegations included as a separate attachment.
PE24031 · Fsd Collisions In Reduced Roadway Visibility Conditions
Opened Oct 17, 2024 · Closed Mar 18, 2026
Status: closed (inferred from source dates) · Electrical System:adas
On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document, and if so, the contributing circumstances for each of those crashes; and any updates or modifications by Tesla to the FSD system that may affect the performance of FSD in degraded roadway visibility conditions, including the timing, purpose, and capabilities of any such updates, and Tesla’s assessment of their safety impact. Tesla’s FSD is an advanced driver assistance system (ADAS) that relies exclusively on vision-based cameras and the related FSD software to detect and respond to the roadway ahead, projecting a path forward based on traffic control devices, vehicles, pedestrians, and the roadway itself. During this phase of the investigation, ODI reviewed the materials provided by Tesla detailing any actions taken, or changes, modifications, and updates made that may relate to the alleged defect. ODI reviewed information related to Tesla’s transition to a vision-only perception system, and its deployment of the strategy in vehicles. ODI’s findings include information on limitations of the vision-only perception system and updates made in response to known subject crashes. When Tesla began transitioning away from using both cameras and radars to an exclusively camera-based approach, known as Tesla Vision, in mid-2021, it developed and implemented a degradation detection system that it deployed by a software update to existing and new Tesla vehicles. On June 28, 2024, the day after Tesla submitted the SGO report of the November 28, 2023 fatal crash listed in this document, Tesla began developing an update to the degradation detection system. ODI reviewed certain public statements, including those made during an April 2025 earnings call, in which Tesla stated that it had developed a breakthrough “direct photon-counting” capability that eliminates the degradation that the camera-based system experiences when glare is encountered. At this time, ODI does not have information on when the update was deployed and which vehicles have the updated system. ODI has discussed individual incidents and its initial findings with Tesla. Based on Tesla’s post-incident analysis, the update to the degradation detection system, had it been installed on the vehicles at the time, may have affected 3 of the 9 incidents identified by ODI. Review of Tesla’s responses revealed additional crashes that occurred in similar environments and where the system either did not detect a degraded state, and/or it did not present the driver with an alert with adequate time for the driver to react. In each of these crashes, FSD also lost track of or never detected a lead vehicle in its path. Tesla also described internal data and labeling limitations that prevented a uniform identification and analysis of crash events with the subject system engaged. ODI believes this limitation could have led to under-reporting of subject crashes over portions of the defined time-period. Available incident data raise concerns that Tesla’s FSD system fails to detect and/or warn the driver appropriately under degraded visibility conditions such as glare and airborne obscurants where the camera-based system performance degrades significantly. In the crashes that ODI has reviewed, the FSD system did not detect common roadway conditions that impaired its visibility and/or provide alerts when camera performance had deteriorated until immediately before the crash occurred. ODI is upgrading this investigation (PE24031) to Engineering Analysis (EA) 26002 to further evaluate this matter. The crashes included in the failure report summary can be found at NHTSA.gov under the following SGO report identification numbers: 13781-8004, 13781-7181, 13781-7381, 13781-7767, 13781-7964, 13781-8977, 13781-9267.
RQ24009 · Recall 23V838 Remedy Effectiveness
Opened Apr 25, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas:driver Monitoring:software
The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the safety defect, Tesla’s Defect Information Report (DIR) explained that “the prominence and scope of the system’s controls may be insufficient to prevent driver misuse,” and Tesla committed to the deployment of a multipart remedy aimed at improving system and engagement controls and reducing mode confusion. EA22002 (upgraded from PE21020) was opened to investigate whether Tesla’s Autopilot contained a defect that created an unreasonable risk to motor vehicle safety and involved extensive crash analysis, human factors analysis, vehicle evaluations, and assessment of vehicle control authority and driver engagement technologies. The work conducted in these investigations aligns with Tesla’s conclusion in its 23V838 recall filing. During EA22002, ODI identified at least 13 crashes involving one or more fatalities and many more involving serious injuries in which foreseeable driver misuse of the system played an apparent role. Tesla filed Recall 23V838 to address concerns regarding the Autopilot system investigated in EA22002. Following deployment of the remedy in Recall 23V838, ODI identified concerns due to post-remedy crash events and results from preliminary NHTSA tests of remedied vehicles. Also, Tesla has stated that a portion of the remedy both requires the owner to opt in and allows a driver to readily reverse it. Tesla has also deployed non-remedy updates to address issues that appear related to ODI’s concerns under EA22002. This investigation will consider why these updates were not a part of the recall or otherwise determined to remedy a defect that poses an unreasonable safety risk. ODI is therefore opening this Recall Query investigation to further evaluate the adequacy of the remedy for recall 23V838.
Illustration