Seat BeltsService Brakes, HydraulicVehicle Speed Control
BRAKES MADE LOUD GRINDING NOISE, HAVE HAD BRAKE PADS/LINERS REPLACE 3 TIMES IN THE LAST SEVERAL MONTHS. PROBLEM WILL NOT RESOLVE. BRAKE PEDAL BECOMES MUSHY AND ABS HAS FAILED SEVERAL TIMES. SEAT BELTS LOCK AND STAY LOCKED AT THE SLIGHTEST BRAKING PRESSURE AND/OR VEHICLE SPEED AND DO NOT RELEASE FOR SEVERAL MINUTES. THIS IS …
Read full complaint
BRAKES MADE LOUD GRINDING NOISE, HAVE HAD BRAKE PADS/LINERS REPLACE 3 TIMES IN THE LAST SEVERAL MONTHS. PROBLEM WILL NOT RESOLVE. BRAKE PEDAL BECOMES MUSHY AND ABS HAS FAILED SEVERAL TIMES. SEAT BELTS LOCK AND STAY LOCKED AT THE SLIGHTEST BRAKING PRESSURE AND/OR VEHICLE SPEED AND DO NOT RELEASE FOR SEVERAL MINUTES. THIS IS A SERIOUS PROBLEM THAT NO ONE SEEMS TO WANT TO ADDRESS. *JB
NHTSA ODI #10205087
29,000 miles · Mar 2, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED THE ANTILOCK BRAKES FAILED WHILE DRIVING 40 MPH IN SNOW WITHOUT WARNING. THERE IS A NHTSA RECALL, # 05V452000, REGARDING THE SERVICE BRAKES HYDRAULIC. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA ODI #10151661
16,500 miles · Oct 4, 2005
Service Brakes, Hydraulic
WE PURCHASED A 2004 XL7 MAY 28 2004 AND CURRENTLY THE VEHICLE HAS APPROXIMATELY 38K MILES. SO FAR WE HAVE HAD TO REPLACE THE BRAKE LINING TWICE SO THE VEHICLE IS NOW ON IT'S THIRD SET OF BRAKES. THIS SEEMS TO BE A PROBLEM. MY FATHER ALSO HAS THE SAME VEHICLE, WITH 36K MILES. HE TOO HAS HAD THE BRAKE LINING REPLACED TWICE. THIS C…
Read full complaint
WE PURCHASED A 2004 XL7 MAY 28 2004 AND CURRENTLY THE VEHICLE HAS APPROXIMATELY 38K MILES. SO FAR WE HAVE HAD TO REPLACE THE BRAKE LINING TWICE SO THE VEHICLE IS NOW ON IT'S THIRD SET OF BRAKES. THIS SEEMS TO BE A PROBLEM. MY FATHER ALSO HAS THE SAME VEHICLE, WITH 36K MILES. HE TOO HAS HAD THE BRAKE LINING REPLACED TWICE. THIS CANNOT BE NORMAL! PLEASE INVESTIGATE. *JB
NHTSA ODI #10138485
3,000 miles · Feb 3, 2005
Service Brakes, HydraulicCrash
THIS IS THE THIRD TIME THAT MY FRONT BRAKES HAVE LOCKED UP @ SPEEDS LESS THAN 35 MPH CAUSING THE ENTIRE VEHICLE TO SKID & NOT BE ABLE TO TURN. THE FIRST 2 TIMES I STOPPED IN TIME, THIS TIME I SLID FOR AT LEAST 4 SECONDS BEFORE MY VEHICLE REAR-ENDED ANOTHER. CAUSING MINOR DAMAGE TO THE OTHER VEHICLE AND HALF OF MY FRONT BUMPER …
Read full complaint
THIS IS THE THIRD TIME THAT MY FRONT BRAKES HAVE LOCKED UP @ SPEEDS LESS THAN 35 MPH CAUSING THE ENTIRE VEHICLE TO SKID & NOT BE ABLE TO TURN. THE FIRST 2 TIMES I STOPPED IN TIME, THIS TIME I SLID FOR AT LEAST 4 SECONDS BEFORE MY VEHICLE REAR-ENDED ANOTHER. CAUSING MINOR DAMAGE TO THE OTHER VEHICLE AND HALF OF MY FRONT BUMPER SCRATCHED, DISCOLORED, AND PUSHED IN.*JB
NHTSA ODI #10108469
5,000 miles · Sep 21, 2004
Service Brakes, Hydraulic
ON THREE OCCASIONS BRAKES FAILED, CAUSING THE CONSUMER TO GO THROUGH STOPS SIGNS, AND LIGHTS. MASTER CYLINDER WAS REPLACED, BU TPROBLEM RECURRED. *AK
NHTSA ODI #10092928
25,000 miles · Sep 17, 2004
Service Brakes, HydraulicCrash
WHILE DRIVING ON AN INCLINE AT 15 MPH AND APPLYING THE BRAKE PEDAL CONSUMER HEARD A CLICKING SOUND, AND LOST BRAKINGPOWER. CONSUMER'S VEHICLE RAN INTO THE BACK OF ANOTHER VEHICLE. DEALER WAS NOT NOTIFIED. *AK
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Suzuki XL-7 Problems, Complaints & Recalls | Skip That Year
Illustration