2003 Suzuki SV1000

THE CHARGING SYSTEM MAGNETS DETACHED FROM THE FLYWHEEL/ROTOR (INTERNAL TO THE MOTOR), CAUSING AN ISSUE WHERE THE CHARGING SYSTEM WAS NOT FUNCTIONING PROPERLY. THIS IS A SAFETY ISSUE BECAUSE THE MAGNETS COULD HAVE BECOME DISLODGED ENOUGH TO CAUSE A CATASTROPHIC AND IMMEDIATE ENGINE SEIZURE/FAILURE, RESULTING IN I A CRASH. THANKFULLY, I CAUGHT THE ISSUE BEFORE IT BECAME SEVERE. AFTER A BIT OF ONLINE RESEARCH, I HAVE FOUND THIS TO BE A VERY COMMON ISSUE FOR SUZUKI BIKES EQUIPPED WITH THIS FAMILY OF ENGINES. NUMEROUS INSTANCES CAN BE FOUND ON THE SV650, SV1000, AND ALL MODELS OF THE V-STROM. I HAVE NOT YET CONTACTED SUZUKI REGARDING THIS MATTER, BUT PLAN TO DO SO TODAY. IT IS MY UNDERSTANDING THAT A CASE HAS BEEN OPENED TO LOOK INTO THIS MATTER. I BELIEVE THE CASE NUMBER IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY SV1000 HAS EXPERIENCED PROBLEMS WITH ITS CHARGING SYSTEM THAT AFFECTS THE ENTIRE ENGINE. I CAME TO FIND IT WAS A HEAVILY DOCUMENTED ON PUBLIC ONLINE FORUMS SUCH AS SV-PORTAL.COM AND HAS AFFECTED ALMOST ALL SV1000 OWNERS. THE MAGNETS, WHICH ARE GLUED TO THE INTERIOR OF THE STATOR ROTOR, BREAK FREE OF THEIR EPOXY BOND AND SHATTER INTO PIECES INSIDE THE ENGINE CASE. THIS IS A MAJOR SAFETY ISSUE AS DAMAGE TO THE STATOR/ALTERNATOR IS CERTAIN AND FRAGMENTED MAGNETS ENTER THE TRANSMISSION, OIL PAN, CLUTCH AND OTHER ENGINE SYSTEMS. WHEN ANY OF THESE SYSTEMS ARE CAUSED TO FAIL BY THE BROKEN MAGNET PIECES OR CHARGING SYSTEM FAILURE AT DRIVING SPEED THE RIDER AND ALL NEAR BY MOTORISTS ARE AT SERIOUS RISK. THIS PROBLEM IS WIDESPREAD AND AFFECTS ALL YEARS OF THE SV1000. THE SAFETY ISSUE OCCURS AT VARYING MILEAGE BUT IT IS CERTAIN THAT VEHICLES WITH MORE THAN 15,000 TO 18,000 MILES WILL HAVE THIS ISSUE. *TR

1. BIKE WOULD COMPLETELY GO DEAD WHILE RIDING, GAUGES GO BLACK AND BIKE WILL NOT CRANK. IT HAPPENED ON MULTIPLE OCCURRENCES 2. PROBLEM WAS A TOTAL LOSS OF ELECTRICAL POWER, THIS MEANS NO LIGHTS, NO IGNITION, NO GAUGES, LIKE IF SOMEONE HAD TURNED OFF THE IGNITION SWITCH. 3. I TROUBLE SHOT THE PROBLEM BECAUSE THE MOTORCYLCE WAS OUT OF WARRANTY AND THE SHOP WANTED TO CHARGE ME A DIAGNOSTIC FEE TO LOOK AT IT. I FOUND THE CONNECTOR ON THE WIRE HARNESS THAT GOES TO THE IGNITION SWITCH BLACK AND BURNT FROM THE WIRES SHORTING TOGETHER. I BYPASSED THE CONNECTOR WITH A NEW CONNECTION. THE OLD CONNECTOR IS STILL AVAILABLE. *JB

DT: THE CONTACT S OWNS A 2003 SUZUKI SV-1000S MOTORCYCLE. WHILE ATTEMPTING TO START THE MOTORCYCLE THE INDICATOR LIGHTS CAME ON, AND THEN THE MOTORCYCLE LOST POWER. THE MOTORCYCLE WAS TOWED TO A DEALER, AND THEY REPLACED THE WIRE FROM THE HARNESS TO THE IGNITION SWITCH. THIS SEEMED TO REMEDY THE PROBLEM AT THE TIME. BUT THE MOTORCYCLE LOST POWER AGAIN AFTER A MONTH . THE SECOND TIME THIS HAPPENED SHE WAS RIDING THE MOTORCYCLE. THE SAME THING OCCURRED AS THE FIRST TIME THE MOTORCYCLE LOST POWER. THE MOTORCYCLE HAS NOT BEEN TO THE DEALER THIS TIME, BUT SHE FELT THAT IT WAS THE SAME PROBLEM LAST TIME. SHE CONTACTED THE MANUFACTURER THE FIRST TIME THE PROBLEM HAPPENED, AND THEY STATED THAT SINCE THE MOTORCYCLE WAS OUT OF WARRANTY SHE WOULD HAVE TO COVER THE REPAIR EXPENSES. SHE WAS GOING TO CONTACT THE SERVICE DEALER AND THE MANUFACTURER ABOUT THE SECOND TIME THAT THIS PROBLEM OCCURRED AGAIN. *AK

MY 2003 SUZUKI SV1000S MOTORCYCLE HAD AN INTERMITANT TOTAL POWER(ELECTRICAL) FAILURE THAT WOULD RESULT IN THE BIKE COMPLETELY SHUTTING OFF. BIKE WAS BROUGHT TO A LOCAL DEALER AND THEY COULD NOT DUPLICATE THE PROBLEM. THE DEALER REPLACED THE BATTERY UNDER WARRENTY AND ADVISED ME THAT SOMETIMES THE BATTERYS JUST GO BAD. THE BIKE WAS FINE ON THE FEW SHORTER RIDES I TESTED IT ON..THE MOTOR DIDN'T CUT OUT LEADING ME TO BELEIVE THAT THE PROBLEM WAS FIXED. WHILE LEANING IN TO A CORNER ON THE MORNING OF SEPT. 13TH I AGAIN EXPERIENCED THIS ENGINE CUT OUT LEADING ME TO LOOSE CONTROL OF THE FRONT END. THIS RESULTED IN A PRETTY NASTY HIGH SIDE ACCIDENT WHEN I TRIED TO SAVE THE BIKE. INJURIES WERE A BROKEN SHOULDER, ELBOW, AND TWO CRACKED VERTIBRAE. WHEN I WAS WELL ENOUGH AFTER THE ACCIDENT I WANTED TO KNOW FOR MYSELF WHAT HAPPEDED, SO APART CAME THE BIKE. THE CAUSE OF MY INTERMITANT FAILURE TURNED OUT TO BE A FAULTY ELECTRICAL CONNECTION WERE THE IGNITION SWITCH PLUGS IN TO THE MAIN WIRING HARNESS. THE BIKE WAS BROUGHT TO A LOCAL DEALER AT THIS POINT FOR REPAIR, AND PER SUZUKI'S RECOMENDATIONS THE FAULTY PLUG WAS REPLACED.....I WAS JUST SO PLEASED WITH SUZUKI'S EXPLANATION REGARDING THIS MATTER. THERE TAKE WAS "SOMETIMES THESE PLUGS WORK LOOSE AND GO BAD." IF ANY ONE NEEDS PICTURS OF THE CRAP PLUG I HAVE THEM. JG