2007 Suzuki GSX-R600

I WAS RIDING MY BIKE AND MY BUDDIES BEHIND ME SMELLED A SULFUR SMELL RODE ABOUT 15 MORE MILES AND THE BIKE SHUT OFF PULLED IN TO PARK IT AND SEE WHAT HAPPENED AND THE SULFUR SMELL WAS 10X WORSE AND HAD TO TOW THE BIKE HOME. THE DASH WENT ALL CRAZY FLASHING AND SHUT ON AND OFF AND THEN AN F1 CODE POPPED UP. SO THE NEXT DAY I TOOK IT TO THE LOCAL MECHANIC AND MY BATTERY WAS BAD,HE SAID THE REGULATOR RECTIFIER WAS OVER CHARGING THE BATTERY. *TR

I OWN A 2007 SUZUKI GSX-R600. THE MOTORCYCLE STALLED WHILE TRAVELING AT ABOUT 65 MPH WITHOUT ANY WARNING. I HAD THE MOTORCYCLE TOWED HOME. THE MECHANIC STATED THE REGULATOR COULD HAVE CAUSED THE FAILURE TO OCCUR. I WAS TOLD THERE WAS ONLY A RECALL RELATED TO 2008/2009 MODEL VEHICLES. THE FAILURE AND CURRENT MILEAGE WAS 20,989. *KB

TL* THE CONTACT OWNS A 2007 SUZUKI GSX-R600 MOTORCYCLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED FLAMES NEAR THE HANDLE BAR AREA, CLOSE TO THE CONTACT'S HANDS. THE CONTACT WAS ABLE TO STOP THE VEHICLE AND EXTINGUISH THE FIRE USING WATER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC ADVISED THAT THE RECTIFIER HAD TO BE REPLACED BECAUSE THERE WAS A HOLE WHICH HAD MELTED THE RECTIFIER. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.

TL* THE CONTACT OWNS A 2007 SUZUKI GSX-R600. THE CONTACT STATED THE MOTORCYCLE STALLED WHILE TRAVELING 30 MPH WITHOUT ANY WARNING. THE CONTACT HAD THE MOTORCYCLE TOWED TO THE RESIDENCE. THE MECHANIC STATED THE REGULATOR COULD HAVE CAUSED THE FAILURE TO OCCUR. THE CONTACT WAS TOLD THERE WAS ONLY A RECALL RELATED TO 2008/2009 MODEL VEHICLES. THE FAILURE AND CURRENT MILEAGE WAS 6,914.

MY SON SUDDENLY LOST POWER ON HIS 2007 SUZUKI GSXR600 MOTORCYCLE WHILE OPERATING AT LOW SPEED. TECHNICIAN FOUND AND REPLACED A BLOWN FUSE. A FEW DAYS LATER, THE SAME THING OCCURRED. THE PROBLEM FUSE WAS THE ONE RELATED TO THE FUEL PUMP. TECHNICIAN THEN DISCOVERED THE WIRE HARNESS HAD SHORTED OUT DUE TO BEING ROUTED TOO CLOSE TO THE "TENSIONER". MY SON SAID THIS POWER LOSS COULD BE FATAL IF IT WERE TO OCCUR WHILE DRIVING AROUND A CURVE AT HIGHWAY SPEED. I SEE THAT SUZUKI HAD A RECALL FOR A SIMILAR PROBLEM IN A 2006 MODEL: NHTSA CAMPAIGN ID NUMBER: 05V566000. I STRONGLY RECOMMEND YOU CONSIDER AN INVESTIGATION / RECALL FOR THIS DEFECT IN THE 2007 GSXR600 BEFORE IT CAUSES ACCIDENTS OR DEATH. *TR

TL*THE CONTACT OWNS A 2007 SUZUKI GSX-R600. WHEN THE VEHICLE CAME TO A COMPLETE STOP, THE CONTACT SMELLED AN ODOR AS IF THE ELECTRICAL WIRES WERE ON FIRE. SHORTLY AFTER, THE VEHICLE STALLED. HE NOTICED THAT THE MAIN FUSE HAD BURNED AND WAS LATER REPLACED. THE FAILURE RECURRED INTERMITTENTLY. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE CHARGING SYSTEM RECTIFIER. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 95,000 AND CURRENT MILEAGE WAS 95,971.

A FAST ON/OFF OF THE THROTTLE CAN CAUSE AN UNEXPECTED DECELERATION FOLLOWED BY A RAPID ACCELERATION MAKING THE BIKE FEEL UNSTABLE. DOESN'T OCCUR VERY OFTEN. THE MAJORITY OF THE TIME IT SEEMS TO HAPPEN BETWEEN ABOUT 4-6K RPM WHEN THE BIKE IS 150+ IN TEMP. THE COMPLETE NOTE/TONE OF THE BIKE WILL CHANGE AND IT CAN MAKING PASSING/DRIVING UNCOMFORTABLE. *TR

TL*THE CONTACT OWNS A 2007 SUZUKI GSX-R600. WHILE DRIVING 60 MPH, THE SPEEDOMETER WOULD NOT FUNCTION CORRECTLY AND WOULD DISPLAY APPROXIMATELY 7-9 MILES OVER THE ACTUAL SPEED. THE MILEAGE INDICATOR WOULD ALSO DISPLAY A HIGHER MILEAGE THAN WHAT WAS ACTUALLY ON THE VEHICLE. THE DEALER STATED THAT THEY WOULD ATTEMPT TO REPLACE THE SPEED SENSOR. WHEN THE CONTACT RETRIEVED THE VEHICLE, THE DEALER STATED THAT THE ISSUE WAS CORRECTED AND WOULD ONLY READ 1 MPH OVER THE ACTUAL SPEED. WHEN THE CONTACT TOOK THE VEHICLE HOME, SHE NOTICED YET AGAIN THAT THE SAME FAILURE OCCURRED. SHE RETURNED TO THE DEALER AND THEY STATED THAT IT WAS ACCEPTABLE FOR THE SPEEDOMETER TO BE OFF APPROXIMATELY 10% OF THE ACTUAL SPEED. THE FAILURE MILEAGE WAS APPROXIMATELY 30. UPDATED 05/28/08 *BF