Air Bags. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

15 crash reports3 fire reports5 injury reports

Steering complaints

22 reports

Clear category filter

32,750 miles · Apr 3, 2010

Steering

Read full complaint

GETTING OFF THE FREEWAY I EXPERIENCED A MAJOR LOSS OF POWER STEERING ON MY 2006 SUZUKI GRAND VITARA. I WAS BARELY ABLE TO "MUSCLE" IT TO MY OFFICE A FEW BLOCKS AWAY. IN SEARCHING THE WEB, I DISCOVERED THERE IS A DESIGN FLAW WITH THE BELT TENSIONER WHERE A MOLDED PLASTIC OUTER RING IS PRONE TO FAILURE. WHEN THIS BREAKS, THE BELT BECOMES LOOSE AND LOOSES ITS GRIP ON THE POWER STEERING PUMP. SURE ENOUGH, PARTS OF THE BROKEN OUTER RING WERE FOUND IN THE PAN UNDER THE ENGINE. SUZUKI HAS CORRECTED THE PROBLEM ON NEWER CARS WITH AN ALL METAL PULLEY AND IT'S AN EASY REPLACEMENT. I WAS LUCKY, HAD THE FAILURE OCCURRED GOING AROUND A CURVE OR TURNING IN AN INTERSECTION IT COULD HAVE CAUSED A SERIOUS ACCIDENT. SUZUKI IS AWARE OF THE PROBLEM BUT THERE HAS BEEN NO RECALL AND WILL NOT REPLACE THE PART IF THE CAR IS OUT OF WARRANTY.

NHTSA ODI #10323631

41,400 miles · Mar 18, 2010

Steering

Read full complaint

I WAS DRIVING MY 2006 SUZUKI GRAND VITARA 2.7L SUV -TURNING THROUGH A MAJOR INTERSECTION WHEN THE POWER STEERING BELT TENSIONER PULLEY LOST IT'S OUTER RING WITHOUT WARNING. THE LOSS OF THIS RING CAUSED THE BELT TO SLIP, RESULTING IN A COMPLETE LOSS OF STEERING, NOT JUST POWER STEERING, BUT OF STEERING ALTOGETHER BECAUSE THE BELT SLIPPAGE WAS CAUSING INTERMITTENT PUMPING OF THE POWER STEERING PUMP, CAUSING FLUID CAVITATION AND MAKING THE WHEEL IMPOSSIBLE TO TURN. BY SHEER LUCK I MANAGED TO GET MY VEHICLE TO TURN BY ALMOST HITTING A CAR HEAD -ON. SUZUKI KNOWS ABOUT THE ISSUE WITH THE 2006 AND 2007 GRAND VITARA POWER STEERING PUMP TENSIONER PULLEYS AND HAS EVEN RELEASED A REVISED PART THAT USES A METAL OUTER RING ON THE PULLEY INSTEAD OF THE ORIGINAL PLASTIC ONE. HAD TO HAVE MY VEHICLE TOWED TO THE DEALER WHERE I WAS TOLD THIS WAS NOT COVERED UNDER THE WARRANTY SINCE I HAD 41,000 MILES ON MY VEHICLE AND MY EXTENDED WARRANTY DID NOT COVER THIS FAILURE. THERE NEEDS TO BE A RECALL ON THIS DEFECT BEFORE SOMEBODY GETS KILLED. AFTER DISCUSSING MY CONCERN WITH THE SERVICE MANAGER I CALLED THE 800# FOR SUZUKI AND COMPLAINED AND THE LOCAL DISTRICT MANAGER CALLED MY DEALER SERVICE MANAGER AND DECIDED TO COVER THE REPLACEMENT AFTER I TOLD THEM ABOUT WHAT I READ ON THE INTERNET ABOUT SO MANY OTHERS HAVING THIS PROBLEM AND THAT I WAS GOING TO FILE A COMPLAINT WITH THE NHTSA. *TR

NHTSA ODI #10320593

67,487 miles · Mar 16, 2010

Steering

POWER STEERING PULLEY BROKE WITHOUT ANY WARNING. FAILURE : LOST POWER STEERING. HAD TO TOW THE SUV TO THE DEALERSHIP (SINCE IT WAS HARD TO CONTROL THE VEHICLE WITHOUT POWER STEERING). DEALER REPLACED THE POWER STEERING PULLEY. I HAVE THE OLD PULLEY. *TR

NHTSA ODI #10320337

41,800 miles · Feb 28, 2010

Steering

SUDDEN LOSS OF POWER STEERING ON 2006 SUZUKI GRAND VITARA. *TR

NHTSA ODI #10314923

40,585 miles · Feb 12, 2010

Steering

Read full complaint

THERE IS A VERY DANGEROUS PROBLEM WITH THE 2006, 2007 SUZUKI GRAND VITARA. THE POWER STEERING TENSIONER, DUE TO ITS DEFECTIVE DESIGN, CAN FALL APART AT ANYTIME. THAT PARTICULAR PART HAS SINCE BEEN REDESIGNED, DUE TO MANY FAILURES, AND THE NEW PART SUBSEQUENTLY UTILIZED IN THE LATER MODELS OF THAT VEHICLE. HOWEVER, NO ATTEMPT HAS BEEN MADE BY SUZUKI TO RECALL THE VEHICLE OR INFORM IT'S OWNERS ABOUT THE PROBLEM. WHEN THE POWER STEERING TENSIONER BREAKS APART, THE POWER STEERING IS IMMEDIATELY DISABLED AND THE DRIVER IS FACED WITH A VERY SUDDEN, SEVERE INCREASE IN EFFORT, REQUIRED TO STEER THE VEHICLE. MANY PEOPLE WOULD PANIC IN THAT SITUATION AND COULD VERY LIKELY HAVE A COLLISION. AS SOON AS I DESCRIBED THE PROBLEM TO THE SERVICE MANAGER, HE IMMEDIATELY KNEW WHAT THE PROBLEM WAS AND HAD ME BRING IN THE VEHICLE FOR REPAIRS. THE REPAIR MANAGER MENTIONED TO ME THAT HE HAD AT LEAST 20 FAILURES OF THAT COMPONENT OCCUR WITHIN THE PAST TWO YEARS. I CALLED SUZUKI, BUT THEY WOULD NOT COVER THE REPAIR COST NOR EVEN GIVE THE SLIGHTEST HINT OF WANTING TO RECALL THAT MODEL & YEAR VEHICLE. FYI, THE ORIGINAL TENSIONER CONSISTED OF A METAL PULLEY WHEEL WHICH HAD A PLASTIC ?U? SHAPED RIM MOLDED ONTO THE OUTSIDE OF THE PULLEY. THE FUNCTION OF THE PLASTIC RIM IS TO HOLD THE POWER STEERING BELT IN PLACE. THE FAILURES THAT HAVE OCCURRED ARE DUE TO THE PLASTIC RIM FALLING OFF OF THE PULLEY (DUE TO DETERIORATION OR FATIGUE), LOOSENING THE BELT AND THUS NO LONGER TURNING THE POWER STEERING PUMP. THE NEW COMPONENT IS NOW DESIGNED AS ONE PIECE AND IS ALL METAL. *TR

NHTSA ODI #10310049

52,000 miles · Feb 1, 2010

Steering

Read full complaint

I WAS DRIVING MY 2006 SUZUKI GRAND VITARA 2.7L SUV ON A HIGHWAY WHEN THE POWER STEERING BELT TENSIONER PULLEY LOST IT'S OUTER RING WITHOUT WARNING. THE LOSS OF THIS RING CAUSED THE BELT TO SLIP, RESULTING IN A COMPLETE LOSS OF STEERING, NOT JUST POWER STEERING, BUT OF STEERING ALTOGETHER BECAUSE THE BELT SLIPPAGE WAS CAUSING INTERMITTENT PUMPING OF THE POWER STEERING PUMP, CAUSING FLUID CAVITATION AND MAKING THE WHEEL IMPOSSIBLE TO TURN. BY SHEER LUCK I MANAGED TO GET THE CAR OFF OF THE HIGHWAY WITHOUT CRASHING. SUZUKI KNOWS ABOUT THE ISSUE WITH THE 2006 AND 2007 GRAND VITARA POWER STEERING PUMP TENSIONER PULLEYS AND HAS EVEN RELEASED A REVISED PART THAT USES A METAL OUTER RING ON THE PULLEY INSTEAD OF THE ORIGINAL PLASTIC ONE. THE PART WAS $180 AFTER TAX, AND TOOK AN HOUR OF LABOR TO INSTALL. THERE NEEDS TO BE A RECALL ON THIS DEFECT BEFORE SOMEBODY GETS KILLED. *TR

NHTSA ODI #10303622

54,025 miles · May 16, 2009

Steering

Read full complaint

MY 2006 SUZUKI GRAND VITARA HAS A BROKEN POWER STEERING TENSIONER PULLEY. THE REASON IS THAT THE MANY 2006 MODELS OF THE GRAND VITARA USED A METAL PULLEY WRAPPED WITH A PIECE OF PLASTIC AROUND IT. THE PLASTIC HAS CRACKED, AND ACCORDING TO SUZUKI, IT IS NOT FREE TO REPLACE IT. SINCE 2007, SUZUKI HAS STARTED USING A ALL-SOLID METAL TENSIONER PULLEY AFTER REALIZING THAT PLASTIC TENDS TO BREAK MORE OFTEN. ACCORDING TO SUZUKI, A BROKEN TENSIONER PULLEY WILL LEAD TO IMMEDIATE AND SUDDEN LOSS OF POWER STEERING. THIS COULD CAUSE MAJOR ACCIDENTS WHEN POWER STEERING STOPS WORKING WITHOUT PRIOR NOTICE. HAVING REALIZED THIS DESIGN FLAW, SUZUKI IS STILL NOT WILLING TO REPLACE THE PLASTIC-COVERED TENSIONER PULLEY FOR FREE, ASKING ME FOR $200 FOR THE REPLACEMENT. THIS ISSUE SEEMS TO BE A SAFETY CONCERN WHERE I AM NOT AT FAULT. I SPECIFICALLY ASKED THE TECHNICIAN IF THERE WAS ANYTHING I COULD'VE DONE TO PREVENT IT, AND HE SAID NO. THIS PROBLEM COULD HAVE DIRE CONSEQUENCES IF LEFT IN IT'S CURRENT STATE. I FEEL LIKE THIS TYPE OF DESIGN FLAW SHOULD BE THE RESPONSIBILITY OF SUZUKI TO CORRECT, AND NOT THE CONSUMER. *TR

NHTSA ODI #10268923

55,000 miles · Apr 30, 2009

Steering

Read full complaint

STARTED MY CAR AND THERE WAS A LOUD ODD NOISE COMING FROM UNDER THE HOOD, AFTER A LITTLE INVESTIGATION, I FOUND THAT THE POWER STEERING TENSIONER (WHICH ON EARLY 06 MODELS SUCH AS MINE WAS MADE FROM PLASTIC) HAD CRACKED CAUSING A LOUD NOISE AS WELL AS AN END TO MY POWER STEERING. THE CAR IS WITHOUT POWER STEERING. I CALLED THE LOCAL DEALERSHIP AND THEY ARE NOT GOING TO FIX IT AS IT DOESN'T FALL UNDER WARRANTY, HOWEVER, UPON FURTHER INVESTIGATION THIS SAME ISSUE HAS HAPPENED TO MULTIPLE EARLY MODEL 06 SUZUKI GRAND VITARA OWNERS. SUZUKI FIXED THE PROBLEM WITH LATER 06 MODELS AND ON NEWER MODELS BY CHANGING THE TENSION PULLEY FROM PLASTIC TO STEEL. *TR

NHTSA ODI #10267349

3,963 miles · Feb 27, 2008

Engine And Engine CoolingFuel System, GasolineSeats

2006 SUZUKI GRAND VITARA WITH SEVERAL PROBLEMS. CONSUMER STATES THAT THE PROBLEMS ARE: STEERING SHAFT, ENGINE MAKING A KNOCKING NOISE, ENGINE LIGHT ILLUMINATION, GASOLINE ODOR FROM ENGINE AND SEAT WARMER NOT WORKING. *KB THE ENGINE NOISE WAS DUE TO THE CAMSHAFT TIMING BELT WHICH NEEDED TO BE RE-TORQUED. THE PURGE VALVE WAS REP…

Read full complaint

NHTSA ODI #10219509

6,000 miles · Jan 2, 2008

SteeringInjury

Read full complaint

TL*THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. WHILE DRIVING APPROXIMATELY 10MPH HE NOTICED THAT THE STEERING COLUMN WAS SHIFTING FROM LEFT TO RIGHT. THE DEALER TIGHTENED THE STEERING BOLTS. TWO MONTHS LATER WHILE MAKING A TURN, THE STEERING COLUMN FELL ON THE FLOOR CAUSING HER TO LOSE CONTROL OF THE VEHICLE. THE POLICE REPORT IS AVAILABLE. A FORMAL COMPLAINT WAS FILED WITH THE MANUFACTURER. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 6,000. UPDATED 01/29/08 *BF THE CONSUMER COMPLAINED OF PAIN IN HER NECK AND BACK. UPDATED

NHTSA ODI #10213498

Official recalls

19V187000 · Air Bags:sensor:occupant Classification; Seats

Mar 7, 2019

Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.

Consequence & remedy

Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.

Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.

Additional source detail variants (2)

Air Bags:sensor:occupant Classification

Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.

Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.

Seats

18V667000 · Steering:hydraulic Power Assist System

Sep 25, 2018

Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2006 Suzuki Grand Vitara vehicles. The power steering pump belt tension adjuster pulley has an outer portion that is made of plastic. Repeated heat stress can cause the plastic material to deteriorate, causing pieces of the pulley to break off.

Consequence & remedy

Consequence: Broken pieces of the pulley can get caught between the pulley and the drive belt, causing the drive belt to come off, resulting in a sudden loss of power steering assist, increasing the risk of a crash.

Remedy: Suzuki will notify owners, and dealers will replace the power steering pump drive belt tension adjuster pulley, free of charge. The recall began November 9, 2018. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's number for this recall is 4009. Note: The vehicles included in this recall were not previously recalled under 10V-250.

13V405000 · Air Bags

Sep 6, 2013

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2006-2011 Grand Vitara and 2007-2011 SX4 vehicles. In the affected vehicles, over time, the OCS sensor mat installed in the front passenger seat may fail due to repeated flexing of the mat from use of the seat. As a result, during a crash necessitating deployment, the air bag will deploy regardless of whether the front seat occupant is an adult or a child.

Consequence & remedy

Consequence: Air bag deployment with a child in the front passenger side seat increases the risk of injury to that child.

Remedy: Suzuki will notify owners and dealers will replace the front passenger seat cushion assembly (which includes the OCS sensor mat) free of charge. Sufficient quantities of parts are not currently available to fix all of the affected vehicles. Owners will be notified of the recall in October 2013 and will receive a second notification when parts are available to have their vehicle repaired. The recall began on May 23, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's recall campaign number is VD.

10V250000 · Steering:hydraulic Power Assist:pump

Jun 9, 2010

SUZUKI IS RECALLING CERTAIN MODEL YEAR MODEL YEAR 2006 GRAND VITARA AND MODEL YEAR 2005-2006 XL-7 VEHICLES. THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT THAT OPERATES THE POWER STEERING PUMP AND AIR CONDITIONER COMPRESSOR (IF EQUIPPED) HAS AN OUTER PORTION THAT IS MADE OF PLASTIC. REPEATED HEAT STRESS CAN CAUSE THE PLASTIC MATERIAL TO DETERIORATE AND PIECES OF THE PULLEY CAN BREAK OFF.

Consequence & remedy

Consequence: BROKEN PIECES OF THE PULLEY CAN GET CAUGHT BETWEEN THE PULLEY AND THE DRIVE BELT, CAUSING THE DRIVE BELT TO COME OFF AND RESULTING IN THE DRIVER NEEDING INCREASED EFFORT TO STEER THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE POWER STEERING PUMP DRIVE BELT TENSION ADJUSTER PULLEY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2010. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.

07V554000 · Power Train:automatic Transmission:lever And Linkage:column Shift

Dec 7, 2007

CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION. ' THE AUTOMATIC TRANSMISSION SELECTOR LEVER "PARK" LOCK FUNCTION MAY BE INOPERATIVE DUE TO A STICKING SHIFT LOCK ARM. THE SHIFT LEVER MAY BE ABLE TO BE SHIFTED OUT OF "PARK" WITH THE KEY REMOVED AND WITHOUT DEPRESSING THE BRAKE PEDAL.

Consequence & remedy

Consequence: THIS CAN GIVE RISE TO INCREASED INCIDENTS OF CRASHES RESULTING FROM THE ROLLAWAY OF PARKED VEHICLES AS A RESULT OF INADVERTENTLY MOVING THE SHIFT LEVER FROM THE "PARK" POSITION WHEN THE PARKING BRAKE IS NOT FULLY ENGAGED.

Remedy: DEALERS WILL REPLACE THE SHIFT LOCK MODULE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 7, 2008. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.

05V548000 · Power Train:driveline:driveshaft

Dec 1, 2005

ON CERTAIN PASSENGER VEHICLES, THE LEFT SIDE OF THE RETAINER REAR DRIVE SHAFT MAY CRACK AND THE GEARS MAY GET STUCK DUE TO OIL LEAKAGE BY THE RETAINER.

Consequence & remedy

Consequence: THIS CAN LEAD TO THE REAR DIFFERENTIAL GEARS LOCKING UP AND THE VEHICLE MAY BECOME DISABLED INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE LEFT SIDE OF THE RETAINER REAR DRIVE SHAFT. SUZUKI WILL CALL OWNERS ON OR ABOUT DECEMBER 15, 2005. FOLLOWUP LETTERS TO OWNERS WERE MAILED ON FEBRUARY 13, 2006. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE13021 · Occupant Classification System Failure

Opened Jun 14, 2013 · Closed Sep 30, 2013

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.

Additional source detail variants (3)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Air Bags:frontal

Air Bags