2004 SUZUKI GRAND VITARA WITH REPLACEMENT OF MULTIPLE SAFETY CONCERNS. CONSUMER STATES THAT A SEAL ON THE TRANSMISSION HAS BEEN REPLACED 3 TIMES, THE SHIFT CABLES AND NUMEROUS SEALS. SHE STATED THEY FINALLY HAD TO PUT IN A BRAND NEW TRANSMISSION. *KB AFTER THE TRANSMISSION WAS REPLACED, THE CONSUMER BEGAN HEARING A ROAR FROM T…
Read full complaint
2004 SUZUKI GRAND VITARA WITH REPLACEMENT OF MULTIPLE SAFETY CONCERNS. CONSUMER STATES THAT A SEAL ON THE TRANSMISSION HAS BEEN REPLACED 3 TIMES, THE SHIFT CABLES AND NUMEROUS SEALS. SHE STATED THEY FINALLY HAD TO PUT IN A BRAND NEW TRANSMISSION. *KB AFTER THE TRANSMISSION WAS REPLACED, THE CONSUMER BEGAN HEARING A ROAR FROM THE TRANSMISSION AFTER REACHING 50 MPH. THE DEALER REPLACED ANOTHER SHIFT CABLE. A COUPLE OF WEEKS LATER, THE CHECK ENGINE LIGHT ILLUMINATED,THE AC COMPRESSOR WOULD COME ON EVERY FEW SECONDS AND THE VEHICLE JUST STOPPED ON THE HIGHWAY. THERE WAS A HORRIBLE WHISTLING SOUND COMING FROM THE WINDSHIELD. THE CONSUMER STATED THE VEHICLE HAS BEEN IN THE SHOP 12-15 TIMES FOR THE SAME PROBLEM. *JB
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Suzuki Grand Vitara Problems, Complaints & Recalls | Skip That Year
Illustration