NOISE COMING FROM TIMING COVER. DEALER INDICATED IT WAS TIMING CHAIN TENSIONER. DEALER STATED THIS WAS A COMMON PROBLEM AND THAT THERE IS A TECHNICAL SERVICE BULLETIN (TSB) CONCERNING THIS ISSUE. TOTAL COST TO REMEDY THE SITUATION WAS APPROX $1600. THE ENGINE WOULD NEED TO BE PULLED FROM VEHICLE, OIL PAN, TIMING COVER REMOVED …
Read full complaint
NOISE COMING FROM TIMING COVER. DEALER INDICATED IT WAS TIMING CHAIN TENSIONER. DEALER STATED THIS WAS A COMMON PROBLEM AND THAT THERE IS A TECHNICAL SERVICE BULLETIN (TSB) CONCERNING THIS ISSUE. TOTAL COST TO REMEDY THE SITUATION WAS APPROX $1600. THE ENGINE WOULD NEED TO BE PULLED FROM VEHICLE, OIL PAN, TIMING COVER REMOVED AND THREE CHAINS, AND RELATED TENSIONERS REPLACED (12.5HRS LABOR). THIS PROBLEM SHOULD BE COVERED EITHER IN TOTAL OR PARTIAL BY MANUFACTURER. *NM
NHTSA ODI #10176709
50,000 miles · Nov 23, 2004
Electrical SystemEngine And Engine CoolingExterior Lighting
OWNER COMPLAINTS VIBRATION WHILE BRAKING AND PREMATURE WEAR. NUMBER OF OTHER PROBLEMS WITH THIS VEHICLE. *BF THE CONSUMER STATED THAT THE BRAKES SQUEEL LIKE NAILS ON A CHALKBOARD. THE CONSUMER WAS TOLD THAT THE ROTORS WERE DUSTY. THE VEHICLE HORN STARTED BLOWING AND WOULD NOT STOP. THE CONSUMER WAS TOLD THAT IT WAS AN ELECT…
Read full complaint
OWNER COMPLAINTS VIBRATION WHILE BRAKING AND PREMATURE WEAR. NUMBER OF OTHER PROBLEMS WITH THIS VEHICLE. *BF THE CONSUMER STATED THAT THE BRAKES SQUEEL LIKE NAILS ON A CHALKBOARD. THE CONSUMER WAS TOLD THAT THE ROTORS WERE DUSTY. THE VEHICLE HORN STARTED BLOWING AND WOULD NOT STOP. THE CONSUMER WAS TOLD THAT IT WAS AN ELECTRICAL PROBLEM. THE FUSE WAS TAKEN OUT TO STOP THE HORN FROM WORKING. THE TAIL LIGHT BULB WENT OUT. THE CONSUMER HEARD A TICKING NOISE COMING FROM THE VEHICLE. THE CONSUMER NOTICED SMOKE COMING THROUGH THE VENTS ON THE INSIDE OF THE VEHICLE. THE TEMPRATURE GAUGE WENT FROM COLD TO HOT INSTANTLY. THE VEHICLE NEEDS NEW STRUTS. *TC
NHTSA ODI #10103345
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicSteering
LEAK IN AC CONDENSER FOUND TO BE A COMMON PROBLEM, LEAK IN SAME LOCATION ON SEVERAL VEHICLES. PULL TO RIGHT WHILE DRIVING THAT ALIGHNMENT CANT FIX, SIMILAR PROBLEMS REPORTED BY OTHER OWNERS. PREMATURE WEAR AND VIBRATION OF FRONT BRAKES SIMILAR TO COMPLAINTS OF OTHER OWNERS. NO OFFER TO REPLACE FAILING CONDENSER BY DEALER WHO TOL…
Read full complaint
LEAK IN AC CONDENSER FOUND TO BE A COMMON PROBLEM, LEAK IN SAME LOCATION ON SEVERAL VEHICLES. PULL TO RIGHT WHILE DRIVING THAT ALIGHNMENT CANT FIX, SIMILAR PROBLEMS REPORTED BY OTHER OWNERS. PREMATURE WEAR AND VIBRATION OF FRONT BRAKES SIMILAR TO COMPLAINTS OF OTHER OWNERS. NO OFFER TO REPLACE FAILING CONDENSER BY DEALER WHO TOLD ME ABOUT PROBLEM WITH OTHER CONDENSERS THEY KNEW ABOUT. CAN NOT FIND ANY CONTACT INFO ON SUZUKI MOTORS SITE TO COMPLAIN.
NHTSA ODI #10069849
60,000 miles · Oct 29, 2003
Engine And Engine Cooling
2000 GRAND VITARA WITH 60K MILES NEEDS A TIMING CHAIN TENSIONER. HAVE BEEN TOLD THIS PART SHOULD NOT NEED TO BE REPLACED AT 60K MILES. HAVE READ INFORMATION FROM OTHER SUZUKI GRAND VITARA OWNERS WITH SIMILAR PROBLEMS AFTER WARRANTY IS EXPIRED.
NHTSA ODI #10045044
Mileage unknown · Mar 13, 2003
Engine And Engine Cooling
THE CHECK ENGINE LIGHT ILLUMINATED ON THE VEHICLE, THE DEALER INFORMED CONSUMER THE CATALYTIC CONVERTER NEEDED TO BE REPLACED.*JB
NHTSA ODI #10011689
Mileage unknown · Feb 15, 2003
Engine And Engine Cooling
VEHICLE REPAIR
NHTSA ODI #10005869
Mileage unknown · Jul 11, 2002
Engine And Engine Cooling
ENGINE WAS LEAKING OIL AND COULD HAVE CAUSED A FIRE. CAUSE UNKNOWN. DEALER NOTIFIED.*AK
NHTSA ODI #8013756
Mileage unknown · Jun 6, 2002
Engine And Engine Cooling
VEHICLE HAS BEEN LEAKING OIL ON TOP OFF ENGINE, AFTER 2-3 INSPECTIONS DEALER COULD NOT FIND THE LEAK. OIL LEAK GOT WORSE, VEHICLE LOST 3-4 QUARTS OF OIL IN 50-75 MILES. CONSUMER TOOK VEHICLE TO A SECOND DEALER. DEALER DETERMINED OIL GALLEY PLUG TO BE THE CAUSE OF THE LEAK.*AK
NHTSA ODI #8011183
Mileage unknown · Jan 4, 2001
Engine And Engine CoolingFire
VEHICLE CAUGHT FIRE 5 MINTUES AFTER CONSUMER PARKED IT, VEHICLE BURNED TO THE GROUND, DEALER STATED IT WAS NOT THERE PROBLEM AND SUZUKI STATED THAT THE CONSUMER NEEDED TO FILE THIS WITH HIS INSURANCE, POSSIBLE ENGINE FAILURE. *SLC
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
Consequence & remedy
Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR, THE FUEL DELIVER HOSE AND REPLACE THE HOSE CLAMP WITH AN IMPROVED CLAMP. THE RECALL BEGAN ON SEPTEMBER 29, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER TEMPERATURES BELOW -25 DEGREES, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. FUEL SYSTEM PRESSURE COULD INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
Consequence & remedy
Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A REDESIGNED INTAKE MANIFOLD VACUUM UNION AND A NEW FUEL PRESSURE REGULATOR. OWNER NOTIFICATION BEGAN JUNE 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2000 Suzuki Grand Vitara Problems, Complaints & Recalls | Skip That Year
Illustration