IllustrationTHE BRAKE CALIPERS STUCK ON THE FRONT AND REAR OF THE CAR CATCHING THE FRONT WHEELS ON FIRE. THIS ALL CAUSED THE CAR TO STOP SUDDENLY ON A MAJOR HIGHWAY. I WAS ABLE TO GET OFF THE ROADWAY SAFELY. IT TURNS OUT THE BRAKE HOSE LINES COLLAPSED INSIDE CAUSING THE CALIPERS TO LOCK UP. I HAD TO REPLACE THE ENTIRE BRAKE SYSTEM. *TR
2006 Suzuki Forenza
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Suzuki Forenza do not stand out strongly from the model-year median of 156.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forenza years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
540–25K
4925–50K
5950–75K
4375–100K
31100–150K
4150K+
240 reports with mileage · 40 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 116 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports8 fire reports20 injury reports
Service Brakes complaints
2 reportsI SLOWED DOWN TO TURN OFF OF A BUSY STREET ONTO A SIDE STREET. AS I WENT TO SPEED UP TO ABOUT 15-20 MPH THE CAR SLAMMED ON THE BRAKES ITSELF, MY FOOT WAS ON THE GAS. I PUT MY FOOT ON THE BRAKE FOR 20 SECONDS AND THEN PUT MY FOOT ON THE GAS TO TRY TO DRIVE AGAIN. THE CAR AGAIN SLAMMED ON THE BRAKES. I PUT MY FOOT ON THE BRAKE, P…
Read full complaint
I SLOWED DOWN TO TURN OFF OF A BUSY STREET ONTO A SIDE STREET. AS I WENT TO SPEED UP TO ABOUT 15-20 MPH THE CAR SLAMMED ON THE BRAKES ITSELF, MY FOOT WAS ON THE GAS. I PUT MY FOOT ON THE BRAKE FOR 20 SECONDS AND THEN PUT MY FOOT ON THE GAS TO TRY TO DRIVE AGAIN. THE CAR AGAIN SLAMMED ON THE BRAKES. I PUT MY FOOT ON THE BRAKE, PUT CAR IN PARK AND TURNED OFF THE CAR. I TURNED IT BACK ON AND WAS ABLE TO DRIVE TO A SAFE SPOT. I AM TERRIFIED TO DRIVE IT AGAIN. WHAT IF I HAD STILL BEEN ON THE MAIN ROAD? *TR
Official recalls
414V262000 · Exterior Lighting:headlights
May 19, 2014
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Consequence & remedy
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy: Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
12V397000 · Electrical System:wiring:interior/under Dash; Exterior Lighting:headlights
Aug 14, 2012
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence & remedy
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Additional source detail variants (2)
Exterior Lighting:headlights
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Electrical System:wiring:interior/under Dash
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
07V452000 · Exterior Lighting
Sep 25, 2007
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence & remedy
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
07V315000 · Seat Belts:front:buckle Assembly
Jul 24, 2007
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE RELEASE BUTTON.
Consequence & remedy
Consequence: THESE BUCKLE MALFUNCTIONS, WHICH COULD PREVENT A PERSON FROM USING THE SEAT BELT OR COULD CAUSE THE SEAT BELT TO FAIL TO FUNCTION AS DESIGNED, CAN INCREASE THE RISK OF INJURY IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SEAT BELT BUCKLES WITH THE IMPROVED PART FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.