2009 Subaru Wrx

WHEN I DEPRESS THE CLUTCH PEDAL THERE IS A VERY NOTICEABLE, AUDIBLE, "CLICKING" NOISE, AND A STIFF CLUTCH PEDAL. IT APPEARS TO BE BROKEN SPOT WELDS AND A DEFECTIVE CLUTCH. HAVE HAD THIS ISSUE REPAIRED BY SUBARU ONCE BUT HAS RETURNED MULTIPLE TIMES. IS A MAJOR SAFETY CONCERN BECAUSE CLUTCH ASSEMPLY IS DIRECTLY TIED TO BRAKE AND GAS PEDALS, AND WHEN THE WELDS FAIL COMPLETELY IT IS A POTENTIAL LIFE THREATENING SITUATION. IF YOU DO A SIMPLE GOOLGE SEARCH FOR SUBARU CLUTCH CLICKING IT IS A HUGE PROBLEM AND MANY MANY PEOPLE ARE EXPERINCING THIS ISSUE WITH THERE CLUTCH'S. IT APPEARS A RECALL IS NEEDED TO FIX THIS.

ABOUT 6-8 MONTHS AGO I HAD MY WRX IN FOR WORK AND POINTED OUT A LOUD CLUNK THAT WAS HAPPENING AS I DEPRESSED THE CLUTCH PEDAL. I WAS TOLD IT WAS NO CONCERN BUT THAT THEY COULD DIAGNOSE IT FURTHER FOR A COST. THINKING IT WAS FINE I CONTINUE USE, AND EVENTUALLY THE NOISE WENT AWAY. RECENTLY, MY CAR WAS UNABLE TO SHIFT INTO REVERSE AND MY CLUTCH FELT RATHER STIFF. HAVING LOOKED AT IT THE SPRING BEHIND MY PEDAL WAS BENDING SIDEWAYS AND MY ENTIRE FIREWALL WAS FLEXING AS I PUSHED IN THE CLUTCH. I TOOK THIS BACK TO THE SAME DEALERSHIP THAT TOLD ME THERE WAS NO NOTICEABLE PROBLEM AND THEY TOLD ME THAT I NEEDED. TO REPLACE MY CLUTCH, THEY NEEDED TO R&R MY DASH TO LOOK FOR BROKEN WELDS AND POSSIBLE REPLACE THE PEDAL ASSEMBLY. TO THE PRICE OF $3500.00. I THEN CAME ONLINE TO SEE QUITE A FEW POSTS IN MULTIPLE PLACES OF THE IDENTICAL PROBLEM. *TR

I GOT OFF WORK AND WAS ON MY WAY HOME, PUSHED THE CLUTCH IN TO HEAR A WONDERFUL SNAP AND I HAD ZERO CONTROL OF MY CLUTCH CAUSING ME TO NOT BE ABLE TO SHIFT INTO OR OUT OF ANY GEAR. CHASSIS FATIGUE AND CRACKING RESULTING IN DAMAGE/POTENTIAL COMPROMISE OF DRIVER CONTROLS. WELDS ON THE FIREWALL ARE POOR AND ITS A MANUFACTURER FAULT THAT MANY HAVE BROUGHT TO SURFACE WITH THE NHTSA AND THE SOA (SUBARU OF AMERICA) BUT THERE IS NOT ENOUGH OF THE CARS PRODUCED FOR ANYONE TO TAKE ACTION OR FOR SUBARU TO CARE FOR THE SAFETY OF THE OWNERS OF THE VEHICLE. LOSING COMPLETE OPERATION OF THE CLUTCH ASSEMBLY DUE TO THE WELDS OF THE VERY POOR SPOT WELDED FIREWALL GOING OUT IS A MAJOR CONCERN AND SHOULD BE ADDRESSED AS A HIGH RISK SAFETY HAZARD FOR THE OPERATOR AND OTHERS ON PUBLIC ROADWAYS. I NEED SUBARU TO FIX THE PROBLEM THAT THEY CAUSED FROM THE VERY BEGINNING OF THE MANUFACTURE PROCESS OF MY VEHICLE. *TR

THIS IS THE WELL KNOWN AND DOCUMENTED FIREWALL WELD ISSUE FOR THE PEDAL BRACKET. THE WELDS HAVE BROKEN AND THE PEDAL BRACKET NOW SHIFTS WHEN I PRESS DOWN ON THE CLUTCH. IT MAKES A LOUD POPPING NOISE AS WELL AS CREAKING AND SQUEAKING. IF LEFT UNCHECKED, THE ISSUE WILL WORSEN AND THE ENTIRE BRACKET MAY BREAK OFF WHILE DRIVING, CAUSING A HUGE SAFETY CONCERN. SUBARU NEEDS TO BE FORCED TO RECALL THIS AND PAY TO FIX ALL OF THEM.

I PURCHASED MY WRX IN 2009 FROM THE LOCAL SUBARU DEALER HERE IN CHICAGO. I AM ORIGINAL OWNER OF THIS VEHICLE. A YEAR AGO I FIRST NOTICED A PROBLEM WITH THE CLUTCH PEDAL. WHEN FULLY PRESSED IT MADE A LOUD CREAKING NOISE. WHEN I INVESTIGATED THE NOISE I NOTICED THAT THE ENTIRE CLUTCH + PEDAL BRACKET ASSEMBLY MOVES AND SHIFTS APPROXIMATELY 1/4 INCH. WHEN I REMOVED WINDSHIELD WIPERS I NOTICED THAT 4 SPOT WELDS THAT SECURE THE CLUTCH PEDAL BRACKET TO THE FORWARD FIREWALL ARE BROKEN. I CAN SEE HOLES IN THE FIREWALL SHEET METAL EVERY TIME I PRESS THE CLUTCH PEDAL. THE ENTIRE CLUTCH BRACKET ASSEMBLY MOVES OUT OF ALIGNMENT CAUSING THIS CRACKING NOISE. FINALLY TWO WEEKS AGO THE NOISE WENT AWAY ALL BY ITSELF. I NOTICED THAT THE ENTIRE ASSEMBLY SHIFTS EVEN MORE TO ONE SIDE WHEN CLUTCH IS PRESSED AND I HAVE EXTREME TROUBLE SHIFTING INTO A GEAR. I THINK THAT ENTIRE BRACKET SEPARATED FROM THE MOUNTING POINTS. I FEAR THAT CLUTCH MAY BECOME INOPERABLE. *TR

WHEN I BOUGHT THE CAR FROM THE USED CAR LOT I NOTICED THE CLUTCH PEDAL WHEN BEING PRESSED AND DEPRESSED MADE A SQUEAKING NOISE. I FIGURED IT WAS PROBABLY LACK OF LUBRICATION SO I WENT AHEAD AND LUBRICATED THE PEDAL ASSEMBLY AND THE NOISE STAYED THE SAME. COUPLE MONTHS GO BY AND THE NOISE GOT MUCH LOUDER AND SOMETIMES A LOUD POP WOULD OCCUR. RECENTLY I DID SOME RESEARCH AND FOUND OUT THAT MANY OTHER WRX OWNERS HAVE HAD THE SAME ISSUE. SO I FOLLOWED THE PROCEDURES TO CHECK THE CAUSE OF THE NOISE AND IT SEEMS TO BE THAT THE WELDS ON THE FIREWALL HAVE BEEN BROKEN AND ARE CAUSING THE NOISE.I ALSO NOTICED MY BRAKE PEDAL SHIFTS EVERY TIME I PRESS THE CLUTCH PEDAL. AS TIME PROGRESSES IT FEELS AS IF ITS GETTING HARDER TO SHIFT. I'M AFRAID THAT THIS ISSUE IS CAUSING PREMATURE WEAR OF THE TRANSMISSION. EVERY TIME I PRESS THE CLUTCH PEDAL I FEAR THAT THE CLUTCH PEDAL ASSEMBLY IS GOING TO RIP OFF THE FIREWALL. *TR

TL* THE CONTACT OWNS A 2009 SUBARU IMPREZA WRX (N/A). THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 70 MPH, THE VEHICLE HAD A LOSS OF POWER AS THE SPEED REDUCED TO 30 MPH INTERMITTENTLY. THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCH AND THE FLY WHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.

I RECENTLY STARTED HAVING A CREAKING NOISE EVERY TIME I WOULD DEPRESS THE CLUTCH ON MY 2009 WRX SEDAN. WHEN I PUSH THE CLUTCH IN I NOTICED THAT THE BRAKE PEDAL WOULD ALSO MOVE APPROXIMATELY A OF AN INCH. WHAT REALLY GOT ME WORRIED WAS SEEING THE FIREWALL FLEXING AND MOVING. THE MASTER CYLINDER BRACE WAS ALSO MOVING AROUND AS THE CLUTCH WAS BEING PRESSED. I WAS ABLE TO SEE BOTH BY HAVING THE WINDOW COWL OFF AND HOOD OPENED. AFTER THAT HAPPENED I WENT ONLINE AND SAW THAT OTHER 2008+ WRX OWNERS ARE HAVING THIS SAME PROBLEM AND THE DIAGNOSIS WAS FAILING/BROKEN FIREWALL SPOT WELDS. *TR

I AM THE ONLY OWNER OF A 2009 SUBARU IMPREZA WRX SEDAN. I NOTICED MY CLUTCH SQUEAKING ABOUT 10,000 MILES AGO. I BROUGHT IT INTO A SUBARU DEALER TO HAVE IT CHECK OUT AT THE TIME OF OCCURRENCE AND THEY TOLD ME NOTHING WAS WRONG. ABOUT 3000 MILES AGO, THE CLUTCH STARTED TO "CLICK" INSIDE THE VEHICLE. FOR MY 50,000 MILE SERVICE, I ASKED THE SERVICE DEPARTMENT TO CHECK OUT THE NOISE. THE SERVICE DEPARTMENT CAME BACK TO ME AND TOLD ME THAT MY FIREWALL HAS TORN. THEY TOLD ME THEY HAVE SEEN THIS BEFORE AND THAT IT WAS A RESULT OF POOR SPOT WELDS ON THE FIREWALL DONE BY THE FACTORY. AS A RESULT, THE SERVICE DEPARTMENT SAID MY CLUTCH WILL NEED REPLACING BECAUSE THE TEAR IN THE FIREWALL HAS MESSED UP THE CLUTCH ALIGNMENT. THE SERVICE DEPARTMENT ALSO TOLD ME THAT I AM LUCKY I CAUGHT THIS PROBLEM EARLY BECAUSE IN A SIMILAR CASE THEY SAW IT DESTROYED THE TRANSMISSION OF A DIFFERENT WRX. CURRENTLY, SUBARU IS TRYING TO BRUSH THIS UNDER THE RUG OFFERING TO FIX THE FIREWALL FOR FREE BUT WANTS TO CHARGE ME $1000 TO REPLACE THE CLUTCH. I HAVE CALLED SUBARU OF AMERICA TO REPORT THE ISSUED AND TO SEE IF THEY WILL COVER THE REPAIR. SUBARU OF AMERICA SAID THEY ARE AWARE OF THIS BEING AN ISSUE WITH THEIR VEHICLES AND WILL INVESTIGATE THIS SPECIFIC CASE. I AM AN AVID SUBARU ENTHUSIAST AND HAVE BEEN READING ABOUT HUNDREDS OF OTHER IMPREZA OWNERS FACING THE SAME ISSUE AS MINE. *TR

CLUTCH PEDAL STARTING SQUEAKING AND GEARS WOULD NOT SYNCH WELL DURING SHIFTING WHICH INDICATED THE CLUTCH WOULD NOT FULLY DISENGAGE. BROUGHT TO DEALER AND DIAGNOSED THAT THE CLUTCH PEDAL MOUNTING BRACKET HAS BROKEN FREE OF THE FIREWALL, CAUSING DAMAGE TO THE FIREWALL AND CAUSING THE VEHICLE TO BE INOPERABLE. SUBARU WILL NOT COVER THE REPAIR AND THERE IS NO RECALL ON FILE. THIS IS A COMMON PROBLEM FOR THIS VEHICLE. *TR