2022 Subaru Outback

While sitting stationary on our driveway over the weekend, the windshield of our relatively brand new 2022 Subaru Outback developed a large crack starting from the center bottom and is slowly creeping up. There are no rock chips or any damage that would have caused this crack. Looking online and this is an incredibly common issue and frustration. I'm attempting to have Subaru replace it themselves but I worry the next one will crack in the same amount of time. In all my years of driving and owning cars, I have never experienced a cracked windshield before.

The contact owns a 2022 Subaru Outback. The contact stated that while reversing out of his garage, the vehicle made an abnormal sound, and while the transmission was shifted into reverse (R), the vehicle rapidly accelerated, crashing into a tree. The contact stated the vehicle made the abnormal sound again and rapidly accelerated forward, crashing into a fence. The contact sustained injuries to his head and received medical attention. A police report was filed. The vehicle was towed to a collision center. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,000. The VIN was not available. The contact stated the vehicle changed gears and right foot wasn't close to the accelerator during the crash. Medical attention was not required because the head injury was not severe.

The problem is with the windshield. On 12/26/22 a crack about 8" long appeared spontaneously on the passenger side running from the edge straight towards the middle. I drove the car that day and noticed at dusk that another crack appeared, starting at the bottom edge in front of the driver and running upward towards the middle. Both of these occurred with no noticeable impacts from stones. Both cracks have continued to grow over time. I contacted the dealer on 12/31/22 , where they took pictures and notified Subaru. Three weeks later Subaru wanted more, better pictures so the dealer took more. After receiving no response, three weeks later I contacted Subaru through their website. Their response to contact me still has not been fulfilled. Given the nature of these cracks, the expense and safety issues of having extensive cracks, I decided to contact NHSTA.

I was driving, approximately 50 miles per hour, when my windshield cracked from top center down and across the driver's side obscuring my view and startling me. Nothing struck my windshield and there are no divets or marks other than a clean crack that looks like a stress fracture. There were no other vehicles near me and I was on a paved road. My car is 6 months old with 3300 miles on it.

The Outback Wilderness comes stock with Yokohama Geolandar A/T 225/65R17. There was 13,300 miles on it from factory new tires. At interstate speed of about 75mph, the tread appears to have fully separated from the sidewalls. The tread was closely inspected for any debris by myself, my dealer, and others and no tire punctures are present. We believe this tire has a manufacturers defect and would like to have it inspected if possible. We have kept the tread, despite asking dealer to save all part of tire, the still managed to lose the part from the rim, thought there as not much left from the accident, it was virtually destroyed. Very unusual in all my years of driving.

The windshield cracked without provocation of a rock or any impact, just cold weather. I don’t feel that the windshield of my “ski car” should just crack if the weather gets cold. I was up skiing at our local mountain before this occurred and heard concerning sounds from the windshield. Lo and behold a few weeks later it cracked on its own.

The contact owns a 2022 Subaru Outback. The contact stated that while driving approximately 1 to 2 mph on two occasions into a parking spot, the vehicle hesitated then accelerated and crashed into a pole. There were no warning lights illuminated. There were no reported injuries, air bag deployment, or fire. A police report was filed. The vehicle was taken to a collision shop. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was contacted and had an investigator inspect the vehicle but was unable to duplicate the failure. The failure mileage was approximately 700. The VIN was not available.

This has happened many times since my vehicle ownership in May. Today for example I am on the highway cruising along (cruise control set) and alarms start going off, the vehicle lurches as it self-disables safety features one by one - Cruise control shuts off automatically - check engine light on, reverse auto breaking disabled, lane assist disabled, Collision avoidance disabled, entire eyesight system disabled. (and I'm sure more I am missing) I have contacted Subaru of America many times about this fault, they have yet to respond appropriately to my inquiries (usually they dont respond at all or simply tell me something about the factory stereo?). The only fix I've found is removing the gas cap tapping it a few times and resetting (to the "one-click") tightness. After multiple start/stops the codes will clear and life will resume with safety features. This incident today was 204.3 miles into my gas tank, not sure how the gas cap is related but something is definitely wrong. If it truly is the gas cap they could simply have a small icon on the 11" display vs disabling every safety feature- While I am DRIVING!