2019 Subaru Outback

WE WERE DRIVING ON A RESIDENTIAL STREET AT APPROXIMATELY 25 MILES PER HOUR. THE PASSENGER SLAPPED AT A MOSQUITO WITH HIS OPEN HAND AND THE WINDSHIELD CRACKED WITH A LOUD SOUND AND WITH A SPIDER WEB PATTERN ON IMPACT THE PASSENGER'S HAND WAS NOT RED, DID NOT HURT, AND DID NOT DEVELOP A BRUISE. THIS WAS HIGH IN THE UPPER RIGHT HAND CORNER AND THE CRACKS ARE SPREADING ACROSS THE ENTIRE WINDSHIELD. THE CAR IS A 2019 SUBARU AND HAS LESS THAN 9000 MILES ON. IT WAS PURCHASED IN SEPTEMBER 2018 AND WAS NOT DRIVEN DURING THE WINTER MONTHS THE WINDSHIELD WAS FREE OF ANY DINGS OR SCRATCHES. THIS IS BEING REPORTED BECAUSE OF OUR CONCERN THAT IF A SIMPLE SLAP ON THE INSIDE CAN BREAK THE WINDSHIELD, A ROCK THROWN BY ANOTHER VEHICLE COULD COME THROUGH THE WINDSHIELD AND HIT A PERSON. WE HAVE A WINDSHIELD REPLACEMENT GUARANTEE SO THE WINDSHIELD WILL BE REPLACED AT NO COST, BUT WE ARE NOT COMFORTABLE HAVING IT REPLACED WITH AN ORIGINAL SUBARU WINDSHIELD. I HAVE PICTURES BUT I CANNOT GET THEM TO DOWNLOAD TO THIS SITE.

MY VEHICLE WAS PARKED IN MY DRIVEWAY. I CAME OUT OF MY HOME TO GET READY TO DRIVE WHEN I NOTICED THE WINDSHIELD CRACKED. IT BEGINS WITH A VERTICAL SPLIT OF THE GLASS WITH NO SIGN OF A POINT OF IMPACT FROM DEBRIS. CAUSE: UNKNOWN. I CALLED THE DEALERSHIP AND EXPLAINED THAT I HAD NOT BEEN DRIVING NOR HAD A ROCK HIT MY WINDSHIELD. THEY SAID THAT IT WOULD TAKE THEM A WEEK FOR THEM TO GET A REP AND SERVICE MANAGER TO INSPECT. THE CRACK HAD SINCE GROWN BY THE TIME THEY SAW THE VEHICLE. THEY SAID IT WOULD NOT BE COVERED UNDER WARRANTY TO REPLACE THE WINDSHEILD.

SPONTANEOUS WINDSHIELD CRACK THAT ORIGINATED DIRECTING UNDERNEATH WINDSHIELD WIPER ON PASSENGER SIDE WHILE PARKED OUTSIDE. WINDSHIELD WAS CLEANED HOURS BEFORE CRACK APPEARED, AND NO IMPERFECTIONS WERE OBSERVED; VEHICLE NOT DRIVEN OR MOVED. GOT IN VEHICLE IN EVENING AND CRACK WAS PRESENT EXPANDING ALMOST THE ENTIRE SIDE OF PASSENGER VIEW.

OUR NEW 2019 OUTBACK EXPERIENCED A WINDSHIELD CRACK WHILE DRIVING WITHOUT ANY INDICATION OF IMPACT OF A FOREIGN OBJECT. THE CRACK APPEARED IMMEDIATELY AFTER TURNING ON THE DEFOG SYSTEM WHILE DRIVING. THE LOCAL DEALER INSISTED THAT THE CRACK WAS DUE TO OUTSIDE INFLUENCE AND NOT WINDSHIELD MATERIAL FAILURE. AFTER CONTACTING SUBARU OF AMERICA THE WINDSHIELD WAS REPAIRED AS A COURTESY AT THE DEALERSHIP.

SMALL ROCK HIT LOWER LEFT CORNER OF WINDSHIELD, APPROXIMATELY 2 INCHES FROM EDGE. CONTINUED DRIVING. SUDDENLY, ENTIRE WINDSHIELD CRACKED ACROSS APPROXIMATELY 70% OF GLASS WITHIN 5 MINUTES, OBSTRUCTING VIEW. INITIAL IMPACT WAS TINY CHIP, BARELY VISIBLE WITHOUT CLOSE INSPECTION. NORMAL DRIVING CONDITIONS, HIGHWAY, 60MPH, DRY ROAD & WEATHER, BEFORE SUNRISE. SINGLE OWNER VEHICLE, 10K MILES. COMPLAINT ALSO FILED WITH SUBARU.

PURCHASED NEW 2019 SUBARU OUTBACK. WHEN PARKED IN THE GARAGE OVERNIGHT AFTER JUST A COUPLE WEEKS A STRESS CRACK BEGAN TO FORM FROM THE TOP OF THE WINDSHIELD GOING DOWN. THE NEXT DAY IT WAS OUTSIDE ON A HOT DAY AND THE CRACK BEGAN TO GET WORSE. NO IMPACT ON WINDSHIELD FROM ROCK OR ANYTHING ELSE. MAY BE CAUSED FROM HEAT? VEHICLE WAS STATIONARY IN BOTH CASES.

JUST EXPERIENCED MY SECOND SPONTANEOUS CRACK WITHIN FOUR SIX MONTHS WHERE THE WINDSHIELD NEEDED TO BE REPLACED ON MY 2019 SUBARU OUTBACK. THE CRACK STARTS AT THE BOTTOM OF THE WINDSHIELD BELOW THE WIPER BLADES AND THE CRACK EXPANDS UPWARD APPROXIMATELY 12-18 INCHES. IT IS BEYOND MESHY THESE WINDSHIELDS HAVE TO BE REPLACED SO OFTEN AND IT IS MY OPINION THEY ARE MADE WITH MATERIALS THAT CANNOT STAND UP TO DAY TO DAY TEMPERATURE CHANGES OF NEW ENGLAND. THE CAR WAS PARKED ALL WEEKEND AND HAD NO CRACK. HOWEVER, ON MONDAY MORNING, THE CRACK WAS THERE.

PLEASE REVIEW AND ESCALATE THIS MANUFACTURING DEFECT. THE SAME ISSUE RESULTED IN A CLASS ACTION LAWSUIT IN CALIFORNIA. I PURCHASED MY 2019 SUBARU OUTBACK ON 12.31.18. AFTER WORK IN MID APRIL OF 2019, I RETURNED TO MY PARKED CAR. UNLOCKED AND ENTERED THE VEHICLE FROM THE DRIVER'S SIDE. I LOWERED THE SUN SHADE AND NOTICED A LARGE CRACK IN THE FRONT WINDSHIELD. IT STARTED AT THE BOTTOM EDGE OF THE GLASS ON THE DRIVER SIDE, ARCED UP AND CURVED TOWARDS THE PASSENGER SIDE OF THE CAR. NO OTHER DAMAGE WAS NOTICED INSIDE. I GOT OUT OF THE CAR AND CHECKED IT FOR ANY ADDITIONAL DAMAGE AND CHECKED THE WINDSHIELD FROM THE OUTSIDE. THERE DID NOT APPEAR TO BE ANY OTHER DAMAGE THAN THE CRACKED WINDSHIELD AND A MINISCULE LEFT PASSENGER DOOR DING. AS IF THE EDGE OF ANOTHER CAR DOOR CAME IN CONTACT WITH MY SUBARU. NO ROAD HAZARDS OR DEBRIS WAS ENCOUNTERED ON THE WAY TO OR FROM WORK. I NOTIFIED THE DEALERSHIP, HILEY SUBARU OF FORT WORTH, AND REQUESTED TO HAVE THE WINDSHIELD REPLACED DURING MY NEXT SERVICE APPOINTMENT INDICATING THIS WAS A MANUFACTURING DEFECT UNDER WARRANTY. AT THE SERVICE APPOINTMENT, THEY DECLINED TO REPLACE THE WINDSHIELD UNDER WARRANTY.

I PURCHASED THIS VEHICLE BRAND NEW MARCH 2019. I DEVELOPED A CRACK THAT STARTED AT THE BASE OF THE WINDSHIELD, CLOSER TO THE PASSENGER SIDE, THAT QUICKLY SPREAD THROUGHOUT THE WINDSHIELD 3 MONTHS AFTER PURCHASING AND WITH LESS THAN 6K MILES. IT APPEARED TO BE FROM A SMALL STONE CHIP. THE POINT OF IMPACT WAS VERY MINIMAL AND I HAVE HAD OTHER VEHICLES THAT HAVE HAD MUCH LARGER CHIPS THAT HAVE 'SPIDERED' BUT NEVER SPREAD AS RAPIDLY AS THIS CRACK ON MY NEW OUTBACK. I WORKED WITH MY INSURANCE TO HAVE THE WINDSHIELD REPLACED, TOTAL COST WAS OVER $800. I DROVE THE CAR 4 TIMES IN 3 DAYS AFTER GETTING IT REPLACED, ALL ON PAVED ROADS. THIS MORNING I DEVELOPED A CRACK AT THE TOP OF THE WINDSHIELD RIGHT IN THE MIDDLE THAT QUICKLY SPREAD THROUGHOUT THE WINDSHIELD AGAIN. THEIR APPEARS TO BE A SMALL SANDSTONE CHIP THAT MAY HAVE BEEN THE REASON FOR THE CRACK. I AM TAKING IT BACK TO THE PLACE THAT REPLACED IT AND HOPING IT'S COVERED UNDER THE WARRANTY OF THE RECENT REPLACEMENT. THIS ISSUE NEEDS TO BE RESOLVED BY SUBARU BECAUSE IT SOUNDS LIKE IT'S A VERY COMMON PROBLEM.