2014 Subaru Outback

1. The under carriage has corroded creating a safety hazard. Senior dealer representative indicated verbally that 2010-2014 models years are the most prone. 2. If the under carriage fails the engine and transmission could fall out of the car potentially creating a serious issue. 3. The dealer brought the issue to my attention after performing an inspection of the car. 4. I was unaware of the issue until the dealer brought the issue to my attention. 2014 Subaru Outback.  The car has been taken care of in a manner that exceeds the manual recommendations including always flushing the underside of the chassis during washes; especially the winter season. The car was taken to a dealer to have the intake manifold gasket looked at. The dealer took the opportunity to raise the car in the air, conduct an inspection and reported that the front carriage assembly is rusting away and considered dangerous. The Service Manager indicated that the model years 2010 to 2014 exhibit a high-degree of corrosion to the supportive member which holds the engine and transmission in place and if it fails could cause an extremely dangerous situation.  What if any information has NHTSA compiled regarding these issues and Subaru's use of an under-designed, defectively manufactured part that could potentially cause a serious accident if the support structure collapsed?  And if the NHTSA has conducted any research into this issue is there any option for a consumer to recoup or require Subaru to cover the cost of replacement which according to two Subaru Dealers is approximately $4,200. Below is a recap of the repair costs including parts and labor: CRADLE FRM CP OBK 2-3 Day QT 1 $842.66 20202AJ04B ARM ASSY F RH In Stock QT 1$173.41 901000346 BOLT FLG 14X128 In Stock QT 2 $8.18 / $16.36 20420XA000 LINK AY F STABILIZER In Stock QT 2 $72.85 / $145.70 20202AJ05B ARM ASSY F LH In Stock QT 1 $173.41 901000060 BOLT FLANGE In Stock QT 2 $2.88 / $5.76 The labor is calculated at 13.5 Hours @ $189.00

I was in a store parking lot, putting purchases into the trunk of my 2014 Subaru Outback. The rear gate had been opened for about five minutes. As I was leaning into the trunk, as I'd just done 2 or 3 times, with no warning I suffered, a sudden forceful blunt impact on the back of my head. I was so startled, I didn't know for a second what had happened, then realized, I couldn't move, as the rear gate was on top of me. I lifted it up off my head. It was quite heavy as there was no help from the hydraulic arms. I stepped back, while holding the gate/door, and let it go. It rapidly slammed shut. I tried to open it again, and realized the hydraulic arms were not activating to lift it. Each time it is opened, it only stays open for as long as I hold it and then slams closed. It is clear how I or my family could have been seriously injured or killed. If I had looked up to close the gate in the second preceding the failure, the gate would have come down on my face. I or a family member could have had hands or arms crushed when the gate crashed down, and would have been trapped under the gate until help came. I have not used the trunk since the incident as am trying to get Subaru to repair it this week. The problem remains, exactly the same and can be replicated by anyone. There were no warning messages that this was coming and no previous signs that the hydraulic system was going to imminently malfunction and fail. I have seen other reports by Subaru Outback owners that they have had similar failures with their gates and one was almost identical to my situation.

Driving at highway speeds with over half a tank of gas and car just shut down, no warning lights, no noise just shut down and lost all control. Fortunately was able to safely move to shoulder. Sat there for a few minutes, called subaru dealer (no suggestions though i now know there is a recall (NHTSA 21V587000) for an identical problem in newer subaru outbacks and also plenty of online sites suggesting this has happened to other outbacks. Car restarted and we were able to complete our ride home, very scary to think of what could have happened if we were in a different situation of traffic or highway conditions.

I WAS ON THE HIGHWAY, AFTER DRIVING A LITTLE MORE THAN TWO HOURS. THE DASH BOARD LIT UP WITH MANY OF THE "TROUBLE LIGHTS". THE BRAKE LIGHT BEGAN FLASHING, EYE SIGHT WAS LIT, MEANING THAT IT WAS NO LONGER ENGAGED. AT OIL TEMP. CHECK ENGINE TRANSMISSION. ALL OF THE ABOVE. I AM LOOKING AT A PICTURE THAT I TOOK SHOWING THE MILEAGE AND THE WARNING LIGHTS. THE CAR CONTINUED TO OPERATE, WITHOUT ANY HESITATION AND I FELT THAT IT MUST "JUST BE AN ELECTRONIC ISSUE". IT HAPPENED TO ME ONCE BEFORE, ABOUT TWO YEARS AGO. I TOOK IT TO AN AUTO PARTS STORE FOR A QUICK DIAGNOSTIC AND THE GUY SAID IT WAS FINE TO DRIVE UNTIL I COULD GET BACK HOME TO THE DEALERSHIP. TWO DAYS LATER, THE WARNING LIGHTS DISAPPEARED! I UNDERSTAND NOW FROM VARIOUS THREADS ON THE INTERNET, THIS IS A COMMON PROBLEM WITH THE SUBARU'S CVT. IT IS SAD BECAUSE THEY APPARENTLY HAVE BEEN INFORMED OF THIS ISSUE AND THEIR ONLY RESPONSE IS A REPAIR TO THE CVT ($1500-2000) OR A NEW TRANSMISSION ALL TOGETHER ($5- 8K). I BOUGHT THIS VEHICLE AS NEW... I HAVE NOT OWNED A SUBARU BEFORE BUT WANTED THE "SECURITY OF A RELIABLE CAR". I DID PURCHASE THE EXTENDED WARRANTY, BUT THIS HAPPENED AFTER THE 100K MILES SO I HAVE NO RECOURSE. PLEASE HELP ALL OF THE SUBARU OWNERS OUT THERE!! IT'S NOT JUST THE OUTBACK MODEL, BUT SEVERAL OF THEIR VEHICLES AND IT SEEMS THAT IT IS SOMETHING THAT HAS BEEN HAPPENING OVER THE YEARS BUT THEY HAVE NOT BEEN MADE TO ADDRESS THIS DESIGN FLAW. SAFETY WISE-- I DON'T KNOW IF THE VEHICLE WILL JUST QUIT IN THE MIDDLE OF TRAFFIC, OR WHAT. WE TRIED THE "GENERAL FIXES" .... UNPLUG THE BATTERY FOR A FEW HOURS; WE PURCHASED A NEW GAS CAP SEAL; BUT NEITHER OF THOSE DID THE TRICK. I WANTED TO SEND MY CASE TO YOU BUT, ALSO, THIS COMING WEEK, I WILL BE DROPPING IT OFF AT THE DEALERSHIP TO SEE WHAT THEY HAVE TO SAY.

SUNROOF DRAINS CLOG CAUSING WATER TO LEAK INTO CAR. THIS OCCURS WHEN RAINING OR WASHING CAR. INTERIOR WINDOWS BECOME VERY FOGGY AND OFTEN TIMES IT IS NECESSARY TO WIPE THEM DOWN WITH A CLOTH. DEALER WAS WILLING TO REMOVE STANDING WATER FROM CAR AND SEATS AS A "ONE TIME COURTESY" AND INDICATED THAT THEY WOULD CLEAR DRAINS DURING EACH CAR SERVICE PERFORMED BY THEM. RECENTLY HAD THE DRAINS CLEANED, WE HAVE HAD 4 FLASH FLOOD WARNINGS SINCE THEN AND WATER CONTINUES TO LEAK INTO THE INTERIOR (BOTH WHEN DRIVING OR STATIONARY). THIS IS A KNOWN PROBLEM TO SUBARU BUT I HAVE YET TO SEE A RECALL. THIS IS CERTAINLY BOTH A SAFETY AND HEALTH ISSUE (VISIBILITY/MOLD/MILDEW). LEAKING HAS OCCURRED DURING THE PAST 3 YEARS, PERHAPS A BIT MORE. WE HAVE A 2006 VOLVO THAT HAS A SUNROOF AND NO LEAKS!

ON FEB 28, 2019 I WAS DRIVING MY 2014 SUBARU OUTBACK ON INTERSTATE 64 ON A STRAIGHT STRETCH AT APPROXIMATELY 70 MPH GOING UPHILL WHEN ACCELERATOR BECAME SUDDENLY AND COMPLETELY UNRESPONSIVE. I WAS IN THE FAR LEFT LANE OF 3 LANES OF TRAFFIC ALSO TRAVELING AT A HIGH RATE OF SPEED AND HAD TO TRY TO GET TO THE EMERGENCY LANE TO THE RIGHT OF THE 3 LANES. I HAD ABSOLUTELY NO RESPONSE WHEN PUSHING ON THE ACCELERATOR PEDAL AND COULD HAVE BEEN HIT BY NUMEROUS SEMI TRAILER TRUCKS. I WAS ABLE TO COAST TO THE RIGHT INTO THE EMERGENCY LANE WHICH WAS A MIRACLE BECAUSE I WAS ON A STEEP UPHILL INCLINE. WHEN I REACHED THE EMERGENCY LANE, I STOPPED THE CAR, SHIFTED INTO PARK, AND BACK INTO DRIVE MODE AND THE ACCELERATOR DID ENGAGE AT THAT POINT. I IMMEDIATELY TOOK THE CAR TO A SUBARU DEALER BUT THEY HAVE NOT DIAGNOSED IT AS OF YET. I HAVE BEEN RESEARCHING ON THE INTERNET TO SEE IF OTHER 2014 OUTBACK OWNERS HAVE THE SAME COMPLAINT AND CAME ACROSS NUMEROUS OTHER COMPLAINTS OF THE SAME PROBLEM ON THE WEBSITE WWW.CARCOMPLAINTS.COM. THOSE COMPLAINING OF THE SAME PROBLEM HAVE NOT HAD ANY SUCCESS WITH A FIX FROM SUBARU. PLEASE LOOK INTO THIS BEFORE SOMEONE IS INJURED OR KILLED AS I COULD HAVE EASILY BEEN TODAY.