2008 Subaru Outback

THIS ISSUE IS ON THE TOPIC OF A RECALL: "BRAKE PIPE CORROSION" NHTSA CAMPAIGN: 14V311000 SUBARU SERVICE CAMPAIGN: WQK47 SUBARU OF AMERICA IS REFUSING TO PROPERLY HONOR THIS RECALL, AS THEY WILL ONLY COVER THE REPLACEMENT OF CORRODED BRAKE LINES IF THEY ARE ACTUALLY LEAKING. THIS IS AN UNACCEPTABLE CRITERION FOR BRAKE LINE REPLACEMENT, AS IT IS AN EXTREMELY UNSAFE FAILURE MODE WITH POTENTIALLY-LETHAL CONSEQUENCES. I HAVE ATTACHED A PICTURE OF A CORRODED AREA OF THE BRAKE LINES ON MY 2008 OUTBACK, AN AREA UNDER THE FUEL TANK WHICH IS EXPLICITLY COVERED BY THIS RECALL. AS CAN BE SEEN, THEY ARE TERRIFYINGLY CORRODED AS A DIRECT RESULT OF SUBARU'S IMPROPER RUST-PROOFING OF THIS AREA. THEY WILL START LEAKING AT ANY MOMENT. INCLUDED IN THE RECALL IS A PRELIMINARY MEASURE TO APPLY SOME RUST-PROOFING COATING TO THE AREAS IN QUESTION. IF THAT ACTION IS TAKEN, THE RECALL IS CONSIDERED 100% RESOLVED PERMANENTLY. THIS RESOLUTION CRITERION IS ABSOLUTELY UNACCEPTABLE, AS THE RECALL MAY NOT BE DONE BY A VEHICLE OWNER UNTIL THE BRAKE LINES ARE SIGNIFICANTLY CORRODED BUT JUST BEFORE THEY START LEAKING DUE TO CORROSION. THE ONLY ACCEPTABLE RESOLUTION TO A RECALL FOR CORRODED BRAKE LINES IS THE REPLACEMENT OF THOSE BRAKE LINES, NOT SOME MEAGER BAND-AID THAT SUBARU IS EFFECTIVELY CLAIMING IS A PERMANENT FIX TO THE ISSUE. THAT IS NOT TRUE AT ALL, AS BRAKE LINES WILL CONTINUE TO CORRODE TO A DEGREE EVEN IF THEY HAVE SOME COATING ON THEM, ESPECIALLY SINCE THE COATING CAN WEAR OFF. THIS RECALL WAS SUPPOSEDLY ADDRESSED ON MY PARTICULAR VEHICLE BY CITYSIDE SUBARU OF BELMONT, MA. HOWEVER, 2.5 YEARS LATER, THERE IS OBVIOUSLY NO RUST-PROOFING COATING REMAINING. EITHER THE DEALERSHIP DIDN'T DO THE RECALL PROPERLY (OUT OF SCOPE OF THIS ISSUE SUMBISSION TO THE NHTSA), OR THE COATING WORE AWAY COMPLETELY. HOWEVER, IT LOOKS LIKE IT'S THE FORMER OF THOSE TWO.

BRAKE LINES CORRODED, FAILED STATE INSPECTION. BRAKE LINES HAD BEEN SERVICE UNDER SUBARU RECALL TWICE AND SPRAYED WITH A COATING. TREATING INFERIOR, CORRODED BRAKE LINES DOES NOT FIX THE PROBLEM. BRAKE LINES SHOULD HAVE BEEN REPLACED UNDER THE RECALL. I HAVE GOTTEN NO SATISFACTION FROM EITHER THE DEALER OR SUBARU AMERICA. THIS IS NOT AN UNCOMMON ISSUE FOR SUBARU.

TL* THE CONTACT OWNS A 2008 SUBARU OUTBACK. WHILE DRIVING 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE FAILED TO STOP. THE VEHICLE WAS TAKEN TO GLANZMANN SUBARU (95 OLD YORK RD, JENKINTOWN, PA 19046, 215-885-8282) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V311000 (SERVICE BRAKES, HYDRAULIC), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE RECALL HAD BEEN PERFORMED ONCE AND COULD NOT BE DONE AGAIN. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. THE VIN WAS NOT AVAILABLE.

STICKY, MELTING DASHBOARD, SHINY AND REFLECTIVE IN DIRECT SUNLIGHT CREATING VISIBILITY PROBLEMS, UNSURE HOW IT WILL REACT IF PASSENGER AIRBAG MUST BE DEPLOYED THRU DETERIORATING DASHBOARD, AFFECTING RESALE VALUE. DASHBOARD LITERALLY COMES OFF ON HANDS OR WIPING RAGS, POSSIBLE RELEASE OF CHEMICALS INTO INTERIOR? SUBARU WILL ONLY ADDRESS 1/3 OF THE DEFECT REPAIR COST. TOTAL AVERAGE COST FOR REPLACEMENT IS APPROX $1500-1600.00, ACTUAL DASHBOARD ITSELF RETAILS FOR $502.50 FROM DEALERS AND IS APARENTLY AVAILABLE WITHIN A FEW DAYS WHEN ORDERED. SUBARU GAVE CREDIT FOR $500.00, ALMOST COVERING THE COST OF THE DASHBOARD / COVER ONLY*** APPROX. $1000 .00 IN LABOR MUST BE PAID BY CUSTOMER. CAR IS IN OTHERWISE IMMACULENT CONDITION. THIS IS A DEFECT AFFECTING SAFETY, AND IS A KNOWN PROBLEM WITH SUBARU EFFECTING ALL OF THIS MODEL AND SIMILAR MODELS WITH HIGH SUN EXPOSURE. IT IS ALSO CROSS MANUFACTURER AFFECTED, IE; TOYOTA, NISSAN, ETC. THEY HAVE TAKEN THE ROLE OF RECALL AND REPLACE. SUBARU HAS NOT TO DATE. SUBARU IS AWARE THAT THIS IS A SERIOUS PROBLEM YET REFUSES TO ACCEPT FULL RESPONSIBILITY FOR.

RECEIVED RECALL NOTICE FOR BRAKE LINE, TOOK TO DEALER AND THEY APPLIED ANTI CORRESIVE. APPROX 16 MONTHS LATER BRAKE LINE BLEW WHILE DRIVING HOME FROM ON A CITY STREET. TOWED TO DEALERSHIP AND THEY ASKED SUBARU TO COVER UNDER RECALL BUT WAS DENIED DUE TO HIGH MILAGE. BRAKE LINE WAS LEAKING WHERE ANTI CORRESIVE WAS APPLIED. HAVE HEARD IF OTHERS HAVING SAME PROBLEM. WE IN 3 OTHER SUBARUS ARE UNDER THE SAME RECALL AND HAVE CONCERNS.

CAR CHECK ENGINE LIGHT ON, ALONG WITH TRACTION LIGHT ON, CRUISE LIGHT ON. CAN'T SHUT ANY OFF. CAR ACTUALLY GETS VERY HOT TO THE TOUCH DRIVERS SIDE NEAR FENDER HEADLIGHT. COULD START ON FIRE! DANGEROUS! THINK THERE IS A RECALL ON FRONT OXYGEN SENSOR, ONLY IF TURBO? REDICULOUS! SHOULD BE ALL NOT JUST TURBO MODEL! ALSO HAD TO REPLACE HEAD COVER GASKET AND EVERYTHING THAT GOES WITH THAT 5/17/2017 108,900 MILES. THAT SHOULD BE A RECALL ALSO.

THERE'S SEEMS TO BE A COMMON ISSUE WITH THE WIRING ON 2005-2009 SUBARU OUTBACK/LEGACY MODELS THAT AFFECTS BOTH THE AIRBAG AND THE LOCKING MECHANISM. I HAVE SEEN MULTIPLE THREADS ONLINE WHERE THE AIRBAG INDICATOR LIGHT COMES ON SPECIFICALLY INDICATING THAT THE PASSENGER AIRBAG MAY BE AFFECTED AND SENSORS MAY BE FAULTY? THERE IS ALSO A COMMON ERROR IN THE ELECTRICAL SYSTEM IN WHICH WHEN YOU LOCK THE CAR - ALL LOCKS ACTIVATE WITH THE EXCEPTION OF THE REAR TAILGATE WHICH POSES A SAFETY RISK OR TOTAL THEFT OF THE CAR. THESE PROBLEMS OCCUR UPON VEHICLE IGNITION AND WHEN THE CAR IS ON OR OFF (FOR THE LOCKING)

I WAS STOPPED ON A SIDE STREET, WAITING FOR A TRAFFIC LIGHTTIP CHANGE AROUND 9:50AM ON SUNDAY, JUNE 17, IN DENVER, CO. THERE WERE CARS IN FRONT OF ME AND ONE IN BACK BUT NONE OF US WERE MOVING. SUDDENLY, AND WITHOUT WARNING, MY DRIVER'S SIDE WINDOW COMPLETELY SHATTERED. IT HAD BEEN HALF OPEN BEFORE THIS HAPPENED WITH NO MECHANICAL ISSUES. GLASS SPRAYED IN AND OUT OF THE CAR. I HAD SEVERAL SMALL CUTS. THERE WAS NO EVIDENCE OF ANYTHING HITTING OR BEING THROWN AT THE WINDOW.