IllustrationWHEN THE GAS TANK IS FILLED ABOVE HALF A TANK, FUEL LEAKS ONTO THE GROUND IN LARGE AMOUNTS NEAR THE REAR OF THE VEHICLE. THIS IS EXTREMELY DANGEROUS SINCE A SPARK OR CIGARETTE WOULD CAUSE AN EXPLOSION. *TR
1997 Subaru Legacy
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1997 Subaru Legacy do not stand out strongly from the model-year median of 77.
About this comparison →How this year compares
Owner complaints by model year
Compare all Legacy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 23 of 139 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports2 fire reports7 injury reports
Fuel System, Gasoline complaints
7 reportsMY FUEL FILLER RUSTED OFF @ THE FUEL TANK CAUSING IT TO LEAK ON THE GROUND WHEN THE TANK IS NEARLY FULL.I HAVE READ OTHER COMPLAINTS ABOUT THIS PROBLEM.IT'S A BIG JOB FOR A DIY.YOU NEED TO DROP THE REAR DIFFERENTIAL , DRIVE SHAFT , MUFFLER , ETC..IS THIS SOMETHING SUBARU COVERS COST WISE? *TR
GASOLINE FILLER TUBE ON SUBARU LEGACY MODELS (1994 & 1997) RUST OUT AND CAUSE VERY SERIOUS DANGER FROM POSSIBLE FIRE/EXPLOSION DUE TO LEAKING FUEL. THIS APPEARS TO BE A VERY COMMON PROBLEM FOR SUBARU OWNERS AND COSTLY ($350+) TO REPAIR. THIS PART WAS REPLACED ON BOTH A 1994 AND A 1997 SUBARU LEGACY AND THE REPAIR SHOP INDICATE…
Read full complaint
GASOLINE FILLER TUBE ON SUBARU LEGACY MODELS (1994 & 1997) RUST OUT AND CAUSE VERY SERIOUS DANGER FROM POSSIBLE FIRE/EXPLOSION DUE TO LEAKING FUEL. THIS APPEARS TO BE A VERY COMMON PROBLEM FOR SUBARU OWNERS AND COSTLY ($350+) TO REPAIR. THIS PART WAS REPLACED ON BOTH A 1994 AND A 1997 SUBARU LEGACY AND THE REPAIR SHOP INDICATED THAT THIS IS A COMMON PROBLEM THAT THEY HAVE DEALT WITH QUITE OFTEN. I FEEL THE PROBLEM IS VERY DANGEROUS AND SHOULD BE ADDRESSED BY THE MANUFACTURER. *TR
AFTER A GAS FILL-UP, I NOTED A LARGE WET SPOT UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. BECAUSE IT SMELLS LIKE GAS, I TOOK IT TO MY AUTHORIZED SUBARU MECHANIC AND WAS ADVISED THAT THE FILLER NECK WAS LOOSE. IN ORDER TO FIX THE MANUFACTURER DEFLECTIVE, HE WOULD HAVE TO REMOVE THE REAR AXLE. SINCE THE CAR IS 11 YEARS OLD WI…
Read full complaint
AFTER A GAS FILL-UP, I NOTED A LARGE WET SPOT UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. BECAUSE IT SMELLS LIKE GAS, I TOOK IT TO MY AUTHORIZED SUBARU MECHANIC AND WAS ADVISED THAT THE FILLER NECK WAS LOOSE. IN ORDER TO FIX THE MANUFACTURER DEFLECTIVE, HE WOULD HAVE TO REMOVE THE REAR AXLE. SINCE THE CAR IS 11 YEARS OLD WITH OVER 83K MILES, THE CAR IS OF COURSE OUT OF WARRANTY. HOWEVER, IN MY OPTION, MY 1997 SUBARU LEGACY GT SEDAN IS NOW CONSIDERED UNSAFE TO DRIVE UNDER ANY SPEED. I RECOMMENDED THAT SUBARU TAKES THE INITIATE BY ISSUING A RECALL BEFORE SOMEONE DIES AS RESULT OF THIS MANUFACTURER DEFLECTIVE. *TR
TL*THE CONTACT OWNS A 1997 SUBARU LEGACY. THE VEHICLE IS LEAKING GASOLINE FROM THE FILLER TUBE. THE DEALER STATED THAT THE REPAIR WOULD BE THE CONTACT'S RESPONSIBILITY BECAUSE THERE WAS NO SAFETY RECALL. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 140,000 AND FAILURE MILEAGE WAS 136,000.
FUEL TANK FILLER PIPE ROTTED OUT. PLASTIC SHIELD OVER FILLER NECK TRAPS SAND. STEEL FILLER PIPE RUSTS WHERE WET SAND IS TRAPPED AGAINST IT. INTERMITTENT FUEL LEAK DEPENDING ON FUEL LEVEL WAS THE FIRST SYMPTOM OF PROBLEM (MARKS ON DRIVEWAY). ONLY FUEL IN FILLER PIPE LEAKS. DEALERSHIP STAFF SUGGESTED THIS IS A COMMON OCCURREN…
Read full complaint
FUEL TANK FILLER PIPE ROTTED OUT. PLASTIC SHIELD OVER FILLER NECK TRAPS SAND. STEEL FILLER PIPE RUSTS WHERE WET SAND IS TRAPPED AGAINST IT. INTERMITTENT FUEL LEAK DEPENDING ON FUEL LEVEL WAS THE FIRST SYMPTOM OF PROBLEM (MARKS ON DRIVEWAY). ONLY FUEL IN FILLER PIPE LEAKS. DEALERSHIP STAFF SUGGESTED THIS IS A COMMON OCCURRENCE. *NM
WHILE STOPPING VEHICLE HEARD GAS SPLASHING VIOLENTLY IN THE TANK, THERE WERE NO BAFFLES IN THE TANK THAT WOULD CONTAIN THE FUEL FOR SPLASHING WHILE DRIVING. OWNER IS VERY CONCERNED FOR HIS SAFETY IN CASE OF A SEVERE IMPACT TO THE VEHICLE AS MAY HAPPEN IN ATRAFFIC ACCIDENT. *AK
Official recalls
501V216000 · Suspension:front:springs:coil Springs
Jun 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.
Consequence & remedy
Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
98V091000 · Suspension:front:springs:leaf Spring Assembly:hanger,bracket
May 4, 1998
VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.
Consequence & remedy
Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.
98V035000 · Vehicle Speed Control
Feb 20, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE THROTTLE SHAFT BALL BEARING ON THE SENSOR SIDE OF THE THROTTLE BODY ASSEMBLY WAS NOT INSTALLED IN CERTAIN THROTTLE BODIES.
Consequence & remedy
Consequence: OPERATION OF A VEHICLE WITH A MISSING THROTTLE SHAFT BEARING CAN EVENTUALLLY LEAD TO AN INCOMPLETE RETURN OF THE THROTTLE VALVE RESULTING IN A HIGH IDLING CONDITION.
Remedy: DEALERS WILL INSPECT THE THROTTLE BODY AND REPLACE THE THROTTLE ASSEMBLY IF THE BEARING IS MISSING.
98V042000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Feb 20, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. DUE TO POOR WELDS, IGNITION KEYS CAN STICK, SHIFT LEVERS/LINKAGES CAN BREAK AND SHIFT LEVERS CAN MOVE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE UNEXPECTED MOVEMENT OF THE VEHICLE INCREASING THE RISK OF A CRASH OR PROPERTY DAMAGE.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT LEVER ASSEMBLIES (EXCEPT THE HANDLE GRIP).
97V210000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT CLEARANCE WITHIN THE HAZARD WARNING LIGHT SWITCH HOUSING CAN CAUSE A BINDING BETWEEN THE ACTUATING BUTTON AND THE HOUSING.
Consequence & remedy
Consequence: THE SWITCH COULD STICK IN AN INTERMEDIATE POSITION WHEN DEACTIVATING, RESULTING IN THE TURN SIGNALS BECOMING INOPERABLE.
Remedy: DEALERS WILL INSTALL A MODIFIED HAZARD WARNING SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE99067 · Electrical System
Opened Nov 1, 1999 · Closed May 31, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 5,820 COMPLAINTS CONCERNING A VARIETY OF ELECTRICAL SYSTEM FAILURES THAT RESULT IN THE VEHICLE STALLING.OUR COMPLAINT ANALYSIS INDICATES THAT THE MAJORITY OF THESE COMPAINTS ARE CAUSED BY ALTERNATOR FAILURE.IN SOME INSTANCES, THE VEHICLE IS COMPLETELY DEAD AND WILL NOT RESTART.BASED ON OUR INVESTIGATION AND THE MANUFACTURER'S RESPOMSE, ODI IS CLOSING THIS INVESTIGATION BECAUSE THE MANUFACTURER HAS AGREED TO PERFORM THE OWNER NORTIFICATION PROGRAM CITED ABOVE, INCLUDING QUARTERLY NOTIFICATIONS TO ODI.THIS PROGRAM ALLOWS OWNERS TO GET THEIR ALTERNATOR REPLACED FOR FREE.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR THIS MATTER CLOSELY, AND THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.