IllustrationTHE LOCK/LATCH ON MY CAR'S PASSENGER DOOR IS DEFECTIVE AND THE RECALL 90V18400 DID NOT FIX THE PROBLEM. THE DOOR IS DIFFICULT TO OPEN AND COULD EASIY FAIL ANY DAY AND TRAP MY PASSENGER IN THE CAR. THE SAME THING IS HAPPENING TO THE FRONT DRIVERS DOOR. THE MANUFACTUER WILL NOT FIX THE PROBLEM AT NO CHARGE. *AK
1990 Subaru Legacy
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1990 Subaru Legacy do not stand out strongly from the model-year median of 77.
About this comparison →How this year compares
Owner complaints by model year
Compare all Legacy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 81 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Latches/locks/linkages. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports4 injury reports
What owners actually said
81 reportsTHE CV BOOTS ON THE FRONT OF THE VEHICLE CONSTANTLY NEED REPLACING. *AK
THE VEHICLE'S DOOR LOCKS EXPERIENCED THE DEFECT STATED IN RECALL 90 V 184 000 BUT IT'S VIN WAS OUTSIDE OF THE REMEDY SCOPE. THE DEALERSHIP REFUSED TO REPAIR THE DOOR. *NLM
HEADLIGHT DEVICE IS PLASTIC, MAKING IT HARD TO SEE WHEN TURNING HEADLIGHTS ON. DEALERSHIP IS NOT AWARE OF PROBLEM.*AK THE PLASTIC LENS MATERIAL BECOMES SIGNIFICANTLY LESS TRANSPARENT WITH TIME, DIMINISHING VISABILITY AT NIGHT. THE ADJACENT TURN SIGNAL LENS HAS NOT AGED. THIS INDICATES TO CONSUMER THAT THE HEADLIGHT LENS IS …
Read full complaint
HEADLIGHT DEVICE IS PLASTIC, MAKING IT HARD TO SEE WHEN TURNING HEADLIGHTS ON. DEALERSHIP IS NOT AWARE OF PROBLEM.*AK THE PLASTIC LENS MATERIAL BECOMES SIGNIFICANTLY LESS TRANSPARENT WITH TIME, DIMINISHING VISABILITY AT NIGHT. THE ADJACENT TURN SIGNAL LENS HAS NOT AGED. THIS INDICATES TO CONSUMER THAT THE HEADLIGHT LENS IS NOT MADE FROM THE SAME MATERIAL AS THE TURN SIGNAL LENS. *JG
CONSUMER STATES THE FRONT PASSENGER DOOR WOULD LOCK ITSELF WHENEVER THE DOOR IS SHUT. THE DEALER AND THE MANUFACTURER WERE NOTIFIED. NLM
I HAVE A 1990 SUBARU LEGACY. EACH TIME I TRY TO EXIT THE CAR THE DOORS LOCK AUTOMATICALLY. IT HAS AUTOMATIC DOOR LOCKS THAT ARE ACCUATED BY PUSHING THE DRIVERS DOOR LOCK. I HAVE HAD THE LOCK APART AND THE PROBLEM WITH ALL 4 OF MY DOOR IS THAT A SINGLE SPRING IN THE LOCK MECHANISM IS RESPONSIBLE FOR HAVING THE INSIDE DOOR HAND…
Read full complaint
I HAVE A 1990 SUBARU LEGACY. EACH TIME I TRY TO EXIT THE CAR THE DOORS LOCK AUTOMATICALLY. IT HAS AUTOMATIC DOOR LOCKS THAT ARE ACCUATED BY PUSHING THE DRIVERS DOOR LOCK. I HAVE HAD THE LOCK APART AND THE PROBLEM WITH ALL 4 OF MY DOOR IS THAT A SINGLE SPRING IN THE LOCK MECHANISM IS RESPONSIBLE FOR HAVING THE INSIDE DOOR HANDLE RETURN TO THE CLOSED POSITION AND TO HAVE THE LOCK BUYYON STAY OPEN. THE HANDLE IS ATTACHED TO THE BOTTOM HALF OF THE SPRING AND THAT PART OF THE SPING KEEPS THE DOOR LOCK OPEN. WELL, THE DOOR LOCK PORTION OF THE SPRING IS WORN OUT AND EVERY TIME YOU USE THE DOOR HANDLE FROM THE INSIDE, THE WEAK HALF OF THE LOCK SPRING CLOSES THE LOCK. I AM A BATTALION CHIEF FOR A LOCAL FIRE DEPARTMENT AND I CAN ONLY IMAGINE WHAT KIND OF A PROBLEM ONE MIGHT HAVE TRYING TO GET OUT OF THIS CAR IN A HURRY. I HAVE CONTACTED SUBARU WITH NO RELIEF. THE LOCAL DEALERSHIP SAYS IT IS A COMMON PROBLEM IN THE 1990 - 1994 MODELS. OUR LOCAL PARTS HOUSES HAVE ALSO SAID THAT IT IS A PROBLEM. I HAVE OTHER OWNERS THAT SAY THE SAME. IT IS $200.00 A DOOR TO REPAIR. PLEASE CONTACT ME ON THIS. THANKS [XXX][XXX]OR[XXX]. *AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
LOCKS ON DOOR WILL LOCK EVEN WHEN UNLOCKING DOORS. LOCKS WILL AUTOMATICALLY LOCK BACK UP. CONSUMER HAS TO HOLD LOCK U, AND THEN PUSH THE DOOR OPEN TO GET OUT OF VEHICLE. CONTACTED DEALER. *AK *YH
I NOTICED ANOTHER INCIDENT ON THE DATABASE REPORTING THIS SAME FAILURE. THE PLASTIC SHIELD TRAPS DEBRIS AGAINST THE FILLER PIPE CAUSING THE PIPE TO RUST THROUGH. I DON'T KNOW HOW MANY '90 SUBARU LEGACYS ARE STILL ON THE ROAD, BUT I SUSPECT (GIVEN THE SEVERITY OF THE RUST), THAT ALMOST ALL OF THEM HAVE THIS SAME CONDITION. EV…
Read full complaint
I NOTICED ANOTHER INCIDENT ON THE DATABASE REPORTING THIS SAME FAILURE. THE PLASTIC SHIELD TRAPS DEBRIS AGAINST THE FILLER PIPE CAUSING THE PIPE TO RUST THROUGH. I DON'T KNOW HOW MANY '90 SUBARU LEGACYS ARE STILL ON THE ROAD, BUT I SUSPECT (GIVEN THE SEVERITY OF THE RUST), THAT ALMOST ALL OF THEM HAVE THIS SAME CONDITION. EVEN IF THEY HAVEN'T RUSTED THROUGH TO THE POINT OF LEAKING, THEY MAY EASILY RUPTURE UPON IMPACT. *AK
BOTH FRONTAL PASSIVE RESTRAINT BELTS FAIL TO OPERATE, WILL NOT GO AROUND THE TRACKS, LEAVING DRIVER AND PASSENGER WITHOUT ANY RESTRAINT IF VEHICLE GETS INVOLVED IN A CRASH. MANUFACTURER CONTACTED, AND WILLING TO GO HALF IN REPAIRS. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
VEHICLE HAS A MASTER DOOR LOCK BUTTON ON DRIVER'S SIDE. 2 REAR DOORS LOCK WHEN DOOR IS CLOSED. PASSENGER'S DOOR SHOULD NOT LOCK ONCE IT'S CLOSED. LOCK KNOB HAS TO BE HELD UP TO OPEN ANB CLOSE THE DOOR. CONSUMER HAS GOTTEN LOCKED OUT A FEW TIMES BECAUSE OF THE PROBLEM. *AK
Official recalls
494V052000 · Power Train:manual Transmission
Mar 23, 1994
WHEN THE VEHICLE IS DRIVEN CONTINUOUSLY UNDER EXTREMELY COLD TEMPERATURES (-22 DEGREES F.) AND HIGH HUMIDITY WEATHER CONDITIONS, THE TRANSMISSION BREATHING (AIR) VENT CAN BE BLOCKED DUE TO MOISTURE FREEZING AT THE OIL LEVEL GAUGE. IF THIS OCCURS, PRESSURE INSIDE THE TRANSMISSION CASE WILL INCREASE AND PUSH OUT THE REAR OIL SEAL, CAUSING TRANSMISSION OIL LEAKAGE. THE LACK OF LUBRICATION CAN BURN THE INTERNAL COMPONENTS OF THE TRANSMISSION, CAUSE THE TRANSMISSION TO SEIZE AND THE VEHICLE TO COME TO A SUDDEN STOP.
Consequence & remedy
Consequence: SUDDEN STOPS WITHOUT PRIOR WARNING CAN CAUSE VEHICLE OCCUPANTS TO BE THROWN AROUND THE VEHICLE AND CAUSE LOSS OF VEHICLE CONTROL WHICH CAN RESULT IN AN ACCIDENT.
Remedy: DEALERS WILL MODIFY THE OIL GAUGE PIPE AND MODIFY THE OIL LEVEL GAUGE (DIPSTICK) OR REPLACE IT, DEPENDING ON THE TYPE OF DIPSTICK IN THE VEHICLE.
91V082000 · Power Train:automatic Transmission
May 30, 1991
UNDER CERTAIN LOAD CONDITIONS, THE PARK GEAR MAY NOT DISENGAGE IMMEDIATELY WHEN THE TRANSMISSION LEVER IS MOVED FROM PARK TO REVERSE.
Consequence & remedy
Consequence: DELAYED RELEASE OF TRANSMISSION FROM PARK CAUSES DELAYEDAND POSSIBLY ABRUPT VEHICLE MOVEMENT THAT COULD RESULT IN LOSS OF VEHICLECONTROL AND AN ACCIDENT.
Remedy: INSTALL A MODIFIED PARKING BRAKE PAWL TO PREVENT DELAYED RELEASE INTO REVERSE GEAR.
90V184000 · Latches/locks/linkages:doors:latch
Oct 16, 1990
TORQUE OF LATCH SCREWS ON FRONT DOORS MAY LOOSEN OVER TIME DUE TO A GAP BETWEEN THE LATCH BASE PLATE AND INNER DOOR PANEL UNDER THE SCREW HEAD.
Consequence & remedy
Consequence: THE AFFECTED DOOR MAY NOT BE OPENED FROM INSIDE,PREVENTING EXIT FROM THAT DOOR.
Remedy: REPLACE FRONT DOOR LATCH SCREWS WITH "LOCK-TIGHT" SCREWS.
90V110000 · Visibility:defroster/defogger/hvac System
Jun 4, 1990
THE DEFROSTER LEVER PIN OF THE DEFROSTER SHUTTER DOOR MAY BECOME DISLOCATED AND ALLOW THE SHUTTER TO CLOSE, PREVENTING DEFROSTER FROM FUNCTIONING.
Consequence & remedy
Consequence: NON-FUNCTIONING DEFROSTER WOULD ADVERSELY AFFECT DRIVERVISIBILITY.
Remedy: INSTALL A POSITIONING STOPPER DEVICE TO PREVENT DISLOCATION OF DEFROSTER LEVER PIN TO ASSURE DEFROSTER OPERATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE94051 · Hood Latch Failure
Opened Jun 29, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE91039 · Reverse Delayed Engagement
Opened Jan 23, 1991 · Closed May 30, 1991
Status: closed (inferred from source dates) · Power Train:automatic Transmission
There is no summary currently available
Additional source detail variants (2)
Power Train:automatic Transmission
There is no summary currently available
Power Train:automatic Transmission
There is no summary currently available