2020 Subaru Forester

My vehicle has repeatedly required being jump-started after sitting for a period of time. Recently it has become a safety issue because the engine is designed to turn off at times in order to traffic to improve fuel efficiency. After research, Subaru has a known issue with the DCM system used to power the optional (subscription based) Starlink system. This system uses 3G signals to provide emergency assistance; however 3G signal has been decommissioned and the system is unable to connect to a tower and never stops trying. This creates a parasitic drain on the battery that can (and has) prevents the car from being able to restart from a stopped position.

Vehicle continuously suffers a total loss of power (engine shuts off) while driving, creating obvious hazard to the user of the car and other drivers. This continues to happen without warning and often while driving through intersections and other dangerous situations. No warning lights precede these events. We brought the vehicle to the Subaru dealership and, after testing/diagnosing the problem, they informed us the vehicle needs a larger battery (which also requires installation of a larger battery tray) than the one that came equipped with the vehicle from the manufacturer. No aftermarket modifications have been made to the battery or electrical systems and the current battery is the size and type recommended by Subaru in the owner’s manual; the dealership, however, advises that that battery is insufficient and needs to be changed for a larger-sized battery.

Since purchasing my vehicle in June of 2020, I have replaced the windshield every 6-7 months for spontaneously cracking. In April of 2023 I filed a claim with Subaru of America and was instructed to make an insurance claim and my deductible would be reimbursed. As of December 1, 2023 my windshield has cracked yet again. I have had a windshield inspection done every time it has been replace, no defects or rock chips were identified. This will be the 6th windshield I have had replaced.

Check engine light came on, low temp light stays on, Eyesight disabled, lane departure, emergency breaking, etc have all been disabled due to the issue. I took it to the local autobody shop and they found code p0128 | Coolant Thermostat Issue. This has caused all safety features to become disabled as mentioned above. I was told by the local shop that I need to go to the dealership. I have not brought it to the dealership yet however, after looking online I found that this is a common issue with this make and model vehicle however, nothing has been done by Subaru to recall the component. I am going to bring the car to a dealership however, I'm upset that Subaru hasn't acted on the information that they have a faulty component in this vehicle. I am very concerned with cost of repairs since I am being forced to go to the dealer.

The Thermo Control Valve failed at 33,945 miles. Because of this, the heater, Eye Sight, Cruise Control, Lane Assist, and Collision Brake did not work. The engine was then only running at "Sport" mode. It did not regulate the heat to the oil and could've caused sludge. The problem was confirmed by a Subaru Dealer Service Shop. I only noticed this problem when the blue thermometer light came on the dash board. Usually I wait about 5 min and once the car is warmed up the light goes away. This time the blue thermometer warning light did not turn off and stayed on for the remainder of the trip. When the car was restarted on the same day the engine check light came on. Eye Sight, Lane assist and Collision assist lights were on.

Windshield spontaneously cracked from the base into the wiper area. There was no previously known damage. This impacts driver visibility and weakens the windshield. I have not had the windshield inspected by another party and did not observe any warnings. I have since learned online that this is an ongoing issue with some Subaru windshields.

While driving, most of the dash errors lights lit up- alerting me that the Eyesight Warning, RAB ( Reverse Auto Braking) and other safety functions were disabled. The Check Engine light was on and a flashing S next to it. Cold Engine light was illuminated as well. Dealer diagnosed with a faulty Thermal Control Valve, which somehow disabled all safety features. This is a common failure of Subarus and a recall is needed.