2020 Subaru Forester

24th February 2020 - Bought the car from Subaru dealer. Couple of service records prior to May 24, 2022. - May 24, 2022 (9,037 miles) | RO# 806326: The lower oil pan leaked prematurely and had to be completely replaced under warranty. During the same visit, explained LONG BRAKE PEDAL issue, and was given an estimate. - - June 1, 2022 (9,039 miles) | RO# 806767: Just 2 miles after that repair, the oil pan had to be torn apart again because the internal oil level sensor failed and got stuck. - January 19, 2024 (18,854 miles) | RO# 838995: The vehicle suffered a dangerous engine shutdown in the middle of traffic due to the factory Thermo Control Valve defect (TSB 09-80-21). While resolving this safety defect under warranty, the dealer used scare tactics to upsell me $794.23 out of pocket for unrelated maintenance. - July 3rd, 2025 - You can see from invoice records that indicate, customer requesting a quote on repairing the windshield chips, as I learned on 26th August 2026 (during call with Subaru corporate) that it was under extended warranty, dealership offered me a quote and did not volunteer to repair at no cost nor conveyed information on extended warranty. This damage happened twice due to poor quality of Windshield in my car. - 23rd August, 2026 - This 2020 Subaru Forester has experienced repeated failures involving the Auto Start/Stop system. When stopped in traffic, the system shuts the engine off as designed, but on multiple occasions the engine has failed to restart normally when the driver needed to proceed. This has left the vehicle unable to move in active traffic and created a serious risk of collision. The failures have occurred in highly dangerous situations. - 24th August, 2026 - Similar incident happened the next day. - 25th August 2026 (39,000 miles) | Present Day: The lower oil pan seal has failed yet again. Dealership is suggesting a battery replacement. Shared inspection video shows, rusts on bolts, very unusual for a car driven only 39000.

This 2020 Subaru Forester has experienced repeated failures involving the Auto Start/Stop system. When stopped in traffic, the system shuts the engine off as designed, but on multiple occasions the engine has failed to restart normally when the driver needed to proceed. This has left the vehicle unable to move in active traffic and created a serious risk of collision. The failures have occurred in highly dangerous situations, including a busy [XXX], a major [XXX] intersection, and most recently while entering a freeway. In these incidents, surrounding drivers had to brake hard to avoid striking the disabled vehicle. The occupants reasonably feared a serious collision, and the events were potentially life-threatening. The battery was replaced, but the Auto Start/Stop no-restart condition later occurred again, so battery replacement did not resolve the problem. Subaru issued Technical Service Bulletin 16-147-24 on XXX for 2019-2021 Foresters. The bulletin addresses TCM reprogramming related to engine behavior during Auto Start/Stop restart and instructs technicians to reprogram the TCM when the described symptom is reported. However, the bulletin’s warranty section provides reimbursement under the Basic New Car Limited Warranty. For a 2020 vehicle, the original 3-year/36,000-mile basic warranty would ordinarily have expired before this 2024 bulletin was issued. The vehicle is now being evaluated by an authorized Subaru dealer. The condition is intermittent and dangerous because the driver cannot know whether the engine will restart when movement is required. The vehicle is available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

**Component or System:** Subaru EyeSight Driver Assist System (specifically the Pre-Collision Throttle Management system). **Incident Description & Warning Messages:** There were no warning lamps, messages, or symptoms of any problem prior to this failure. The incident occurred while I was stopped at a red light at a busy intersection. When the light turned green, I removed my foot from the brake and pressed the gas pedal to proceed, but the vehicle would not accelerate. The system had engaged a false-positive throttle cut. At that exact moment, the car began beeping repeatedly and the EyeSight logo flashed on the dashboard, incorrectly indicating an obstacle or imminent collision, even though the path in front of my vehicle was completely clear. **Safety Risk:** My safety and the safety of others were put at significant risk because the vehicle was unexpectedly immobilized in an active intersection during a green light. This sudden, unwarranted loss of acceleration created a high risk of being rear-ended by the drivers behind me who were expecting the flow of traffic to resume. **Reproduced, Confirmed, or Inspected:** Because this incident just occurred, the problem has not yet been reproduced or confirmed by a dealer or independent service center. Furthermore, the vehicle has not yet been inspected by the manufacturer, police, or insurance representatives.

My Apple Car Play has never worked since I bought the car new in 2020. The dealership's solution each time I asked about it was for me to get a new plug in cord, update my iPhone settings, and then they can update the system manually. I have taken it in multiple times, and each time it has worked for 2-3 weeks before it no longer works again. This is dangerous because it usually happens mid-drive, and I no longer have the directions of where I am going, without stopping the vehicle. I also have to hold my phone and look at the directions since it does not display on the screen.

My son, [XXX] is currently driving this car. The car only has 29,200 miles so far. Last week, while at the stop light on the hill, he had near fatal accident! Forester suddenly completed shut down. The only functioning part was the brake. My son had to put the car in park and restart the engine. I reported the incident to customer advocate at Subaru and taking the car in for inspection. We never skip any scheduled maintenance. My next maintenance not due until April. I also purchased Subaru safety monitoring software. The car never shows any malfunction. It’s a very serious issue. We strongly suspect it’s related to the start-stop system on this car. We strongly support to override the system at consumer level giving their unreliability. Thank you for your attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The airbag system has a sensor issue and I keep getting warnings from Subaru to get it fixed because it affects the seatbelts. The garage where I take my car says they are unable to get the part needed for the passenger sensor. And, Subaru says they need to replace the whole harness for $6000. Makes me wonder why a safety issue like this one seen in other Subaru’s have been recalled but not my model… Also the start stop feature drains the battery excessively. I have had to replace the battery twice in less than a year. I push the button to stop this feature the minute I get into the car.

While driving on public roads, all dash warning lights illuminated simultaneously. The instrument cluster displayed “EyeSight OFF.” At the same time, the electronic parking brake engaged / the vehicle would not accelerate and required me to stop and shift to Park. The only way to restore drivability was to turn the vehicle off and restart. This has occurred intermittently, including in traffic, creating a serious safety hazard for myself and surrounding drivers.