IllustrationWINDSHIELD HAS TWO CRACKS ON OPPOSITE SIDES EXTENDING FROM BOTTOM OF WINDSHIELD UPWARDS. ONE APPEARS TO BE IMPACT-RELATED. THE OTHER DOES NOT. CRACKS ARE EXTENDING TOWARD THE LOCATION OF THE SUBARU EYESIGHT SAFETY SYSTEM CAMERAS.
2018 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2018 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1560–25K
6525–50K
1350–75K
575–100K
2100–150K
0150K+
241 reports with mileage · 252 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports6 injury reports
What owners actually said
493 reportsTL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT STATED WHILE DRIVING 8 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING WHICH RESULTED IN THE VEHICLE CRASHING INTO A PARKED VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (SUBARU WHITE PLAINS 258 E MAIN ST, ELMSFORD, NY 1…
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT STATED WHILE DRIVING 8 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING WHICH RESULTED IN THE VEHICLE CRASHING INTO A PARKED VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (SUBARU WHITE PLAINS 258 E MAIN ST, ELMSFORD, NY 10523, (844) 338-8731) WHERE IT'S AWAITING DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 18,000.
THE WINDSHIELD IS PITTED AND CRACKED I FIRST NOTICED THE PITTING IN 03/2018 AND IT IS CONTINUALLY GETTING WORSE. THE WINDSHIELD NOW NEEDS TO BE REPLACED AS IT HAS A HUGE CRACK IN IT!
VEHICLE HAS 50K MILES. WINDOW MOTOR ON DRIVER WINDOW REPLACED TWICE. KEEPS FAILING. ALSO UNEVEN TREAD WEAR ON BRAND NEW TIRES INDICATING SOMETHING WRONG WITH VEHICLE.
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT STATED THAT AFTER LEAVING THE VEHICLE PARKED AND UNDRIVEN FOR SEVERAL DAYS, THE VEHICLE FAILED TO START-UP. THE VEHICLE HAD TO BE JUMP STARTED. THE CONTACT TOOK THE VEHICLE TO SMITH CAIRNS SUBARU - YONKERS (900 CENTRAL PARK AVE, YONKERS, NY 10704, (914) 377-8100) WHO REPLA…
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT STATED THAT AFTER LEAVING THE VEHICLE PARKED AND UNDRIVEN FOR SEVERAL DAYS, THE VEHICLE FAILED TO START-UP. THE VEHICLE HAD TO BE JUMP STARTED. THE CONTACT TOOK THE VEHICLE TO SMITH CAIRNS SUBARU - YONKERS (900 CENTRAL PARK AVE, YONKERS, NY 10704, (914) 377-8100) WHO REPLACED THE BATTERY TWICE HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 4,000.
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT BECAME AWARE OF A CRACK TO THE LOWER WINDSHIELD. THE CONTACT TOOK THE VEHICLE TO HERITAGE SUBARU CATONSVILLE (6624 BALTIMORE NATIONAL PIKE SUITE A, BALTIMORE, MD 21228, (844) 224-1954) WHO STATED THAT THE REPAIR WAS NOT COVERED UNDER WARRANTY. THE VEHICLE HAD NOT BEEN REPA…
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT BECAME AWARE OF A CRACK TO THE LOWER WINDSHIELD. THE CONTACT TOOK THE VEHICLE TO HERITAGE SUBARU CATONSVILLE (6624 BALTIMORE NATIONAL PIKE SUITE A, BALTIMORE, MD 21228, (844) 224-1954) WHO STATED THAT THE REPAIR WAS NOT COVERED UNDER WARRANTY. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THE REPAIR WAS NOT COVERED UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
HAVE HAD MY 2018 SUBARU FORESTER FOR ALMOST 4 YEARS NOW AND IT HAS APPROX. 29855 MILES. BEFORE THE CRACK APPEARED I HAD NO DAMAGE TO MY WINDSHIELD. WHILE DRIVING DOWN THE INTERSTATE, I HEARD A A SLIGHT POP ALMOST LIKE A BOTTLE DENT POPPING OUT BECAUSE OF CARBONATION AT THE TIME THEIR WERE NO OTHER VEHICLES TRAVELING IN MY VICINI…
Read full complaint
HAVE HAD MY 2018 SUBARU FORESTER FOR ALMOST 4 YEARS NOW AND IT HAS APPROX. 29855 MILES. BEFORE THE CRACK APPEARED I HAD NO DAMAGE TO MY WINDSHIELD. WHILE DRIVING DOWN THE INTERSTATE, I HEARD A A SLIGHT POP ALMOST LIKE A BOTTLE DENT POPPING OUT BECAUSE OF CARBONATION AT THE TIME THEIR WERE NO OTHER VEHICLES TRAVELING IN MY VICINITY, SHORTLY AFTER HEARING THE NOISE MY PASSENGER NOTICED THE CRACK.
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT STATED THAT THE WINDSHIELD CRACKED TWICE WITHIN A WEEK. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING APPROXIMATELY 45 MPH, A HORIZONTAL CRACK DEVELOPED ON THE DRIVER'S SIDE OF THE WINDSHIELD WITHOUT IMPACT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACE…
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT STATED THAT THE WINDSHIELD CRACKED TWICE WITHIN A WEEK. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING APPROXIMATELY 45 MPH, A HORIZONTAL CRACK DEVELOPED ON THE DRIVER'S SIDE OF THE WINDSHIELD WITHOUT IMPACT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE WINDSHIELD. FOUR DAYS LATER, THE CONTACT STATED THAT AS HE WAS MERGING ONTO A HIGHWAY AT 60 MPH, THE CONTACT HEARD A CRACK AND SAW A SPIDER WEB CRACK HAD FORMED IN THE MIDDLE OF THE DRIVER'S SIDE WINDSHIELD. THE CONTACT STATED THAT THE CRACKS OBSTRUCTED THE DRIVER'S VISION TO SAFELY OPERATE THE VEHICLE. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 25,500.
WHILE IN MOTION ON A HIGHWAY, OUR WINDSHIELD HAS CRACKED TWICE IN UNDER 24,000 MILES. THESE WERE TWO SEPARATE WINDSHIELDS - THE ORIGINAL AND THE REPLACEMENT FROM A SUBARU DEALERSHIP. WE CAN ASSUME A TINY ROCK HIT THE WINDSHIELD SINCE WE WERE ON A HIGHWAY - HOWEVER, IT APPEARS THAT IT DOES NOT TAKE MUCH FOR THE WINDSHIELD TO CRAC…
Read full complaint
WHILE IN MOTION ON A HIGHWAY, OUR WINDSHIELD HAS CRACKED TWICE IN UNDER 24,000 MILES. THESE WERE TWO SEPARATE WINDSHIELDS - THE ORIGINAL AND THE REPLACEMENT FROM A SUBARU DEALERSHIP. WE CAN ASSUME A TINY ROCK HIT THE WINDSHIELD SINCE WE WERE ON A HIGHWAY - HOWEVER, IT APPEARS THAT IT DOES NOT TAKE MUCH FOR THE WINDSHIELD TO CRACK. THIS SAME SCENARIO HAS HAPPENED TO OUR WINDSHIELD TWICE. OUR CAR WAS NOT FOLLOWING CLOSELY BEHIND ANOTHER CAR OR LARGE VEHICLE THAT COULD HAVE BEEN KICKING UP DEBRIS.
TL* THE CONTACT OWNS A 2018 SUBARU FOSTER. THE CONTACT STATED WHILE PARKING HER VEHICLE SHE SHIFTED INTO PARK, THE VEHICLE ACCELERATED AND CRASHED INTO A BUILDING. THE CONTACT MENTIONED NO WARNING LIGHT WAS ILLUMINATED AND NO STRANGE SOUND HAPPENED BEFORE THE CRASH. THE VEHICLE FAILED TO DEPLOY THE AIR BAGS. THE CONTACT SUSTAINE…
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FOSTER. THE CONTACT STATED WHILE PARKING HER VEHICLE SHE SHIFTED INTO PARK, THE VEHICLE ACCELERATED AND CRASHED INTO A BUILDING. THE CONTACT MENTIONED NO WARNING LIGHT WAS ILLUMINATED AND NO STRANGE SOUND HAPPENED BEFORE THE CRASH. THE VEHICLE FAILED TO DEPLOY THE AIR BAGS. THE CONTACT SUSTAINED WHIPLASH AND NECK PAIN BUT NO MEDICAL ATTENTION WAS REQUIRED. EMERGENCY OFFICIALS WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE 'S FRONT BUMPER AND HEADLIGHT WAS DAMAGED AND THE BUILDING DOOR WAS BROKEN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. FAILURE MILEAGE WAS APPROXIMATELY 65,000. THE VIN WAS NOT AVAILABLE.
Official recalls
321V587000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
19V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
18V455000 · Equipment:other:labels; Tires
Jul 10, 2018
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Additional source detail variants (2)
Equipment:other:labels
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Tires
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.