2014 Subaru Forester

VEHICLE STALL ON A FLAT STRAIGHT HIGHWAY WITH SPEED AROUND 40MPH. THE ENGINE THEN SHUTDOWN AFTER THE STALLING. LOW FUEL LIGHT IS ON EVEN GAS IS MORE THAN HALF TANK. THEN THE HILL ASSIST LIGHTS IS ON. I PULLED OVER, RESTART THE ENGINE AND DRIVE HOME. TWO DAYS LATER, THE SAME ISSUE HAPPEN ON HIGHWAY, THIS TIME THE TRAVEL SPEED IS 55MPH ON A FLAT STRAIGHT HIGHWAY.

DURING A BRAKE CHECK, THE MECHANIC DISCOVERED THE RIGHT PASS SPRING WAS BROKEN ON MY 48K MILE FORESTER. HE FELT IT WAS A SAFETY ISSUE AS THE PART COULD HAVE BROKEN OFF COMPLETELY AND POSSIBLE INJURED SOMEONE ELSE OR CAUSED AN ACCIDENT. THE PARTS ON OTHERS CARS OF THE SAME MODEL ALL BREAK AT THE SAME POINT, IT SEEMS, AND THE OPINION IS THAT THE SPRINGS ARE RUSTING FROM THE INSIDE OUT (SEE ATTACHED IMAGE OF BROKEN SPRING.) ON ONLINE FORUMS, I SEE THIS IS NOT AN ISOLATED INCIDENT AND MY MECHANIC HAS SEEN MANY OTHERS WITH THE BROKEN SPRINGS IN FORESTERS OF THE SAME YEAR. I CALLED SUBARU AMERICA, MENTIONED THAT I BELIEVE THIS SHOULD NOT HAPPEN IN SUCH A NEWISH CAR, AND MORE CONCERNING IT'S A SAFETY ISSUE. THEY AGREED TO PAY FOR THE PART ONLY, NOT THE LABOR SINCE IT WAS NOT DONE AT A DEALER. BECAUSE THEY ARE REIMBURSING OWNERS, THEY SEEM TO REALIZE THIS IS AN ISSUE. I BELIEVE THIS IS A WIDE SPREAD ISSUE, AND DESERVES A LOOK BY THE NHTSA. THANKS FOR YOU CONSIDERATION.

MY 2014 SUBARU FORRESTER WAS PARKED IN MY DRIVEWAY WHEN A VERY LOUD SOUND OCCURRED. THE REAR, DRIVER COIL SPRING BROKE AND THREE PIECES OF METAL WERE ON THE FLOOR. THE CAR BODY DROPPED AND THE TIRE WAS ALMOST HITTING THE WHEEL WELL. I TOOK IT TO MY LOCAL MECHANIC WHO WAS VERY SURPRISED THAT ON A RELATIVELY NEW CAR THE COIL SPRING BROKE. I DID AN INTERNET SEARCH AND DISCOVERED THAT THIS WAS A VERY COMMON COMPLAINT ABOUT THE 2014 FORRESTER COIL SPRINGS. THEY WERE CLEARLY DEFECTIVE BUT SUBARU WAS NOT HELPFUL IN COVERING ANY OF THE REPLACEMENT COSTS ESPECIALLY BECAUSE BOTH HAD TO BE REPLACED.

I WALKED BEHIND THE VEHICLE THAT WAS PARKED ON SIDE OF THE STREET, AND PRESSED THE BUTTON THAT ACTIVATES THE POWERED TAILGATE AND CAUSES IT TO OPEN. AS THE TAILGATE WAS OPENING, THE LEFT TAILGATE GAS LIFT SUPPORT BROKE OFF FROM THE TAILGATE. WHEN THE TAILGATE REACHED ITS MAXIMUM HEIGHT, IT SLAMMED DOWN IN AN UNRESTRAINED MANNER. NOW WHENEVER I TRY TO USE THE AUTOMATIC TAILGATE, IT OPENS TO THE MAXIMUM HEIGHT, THEN ABRUPTLY AND WITHOUT WARNING SLAMS DOWN WITH GREAT FORCE, WITH A POTENTIAL TO INJURE SOMEONE.*DT CONSUMER STATED PUSHED BUTTON TO RAISE LIFTGATE; APPEARED THAT WHEN LIFTGATE REACHED MAXIMUM HEIGHT, IT CAME CRASHING DOWN. COMPLAINANT WAS STANDING BACK WAITING FOR THE LIFTGATE TO OPEN WHEN INCIDENT HAPPENED. TRIED TO OPEN THE LIFTGATE USING BUTTON AGAIN A COUPLE MORE TIMES; LIFTGATE WOULD OPEN, BUT WOULD COME CRASHING DOWN AGAIN WHEN IT REACHED MAXIMUM HEIGHT. LOOKED TO SEE WHAT WAS THE PROBLEM AND SAW ON DRIVER'S SIDE THAT THE STRUT WAS BROKEN AT THE SIDE WHERE THE BALL JOINT CONNECTS TO THE VEHICLE. SAW RUST ALL AROUND THE BALL AND THE TOP PART OF THE BALL HAD SHEARED OFF. UNSCREWED THE REMAINDER OF THE STRUT TO REMOVE. USED THE PROGRAM ON THE VEHICLE TO ADJUST THE MAXIMUM HEIGHT OF THE LIFTGATE SO THAT IT DIDN'T OPEN AS MUCH (APPROXIMATELY 3-5' LOWER) AND THEN IT WOULD OPEN WITHOUT CRASHING DOWN. ORDERED A LIFTGATE REPLACEMENT PART ONLINE AND REPAIRED HIMSELF. NO PROBLEMS SINCE. DID NOT REPLACE THE PASSENGER SIDE STRUT. CONSUMER WILL SEND PHOTOS OF NEW DRIVER'S SIDE AND ORIGINAL PASSENGER SIDE REAR LIFTGATE STRUTS AT CONNECTOR POINTS. *JB *DT *TR

THE RIGHT REAR SUSPENSION ON THE CAR COLLAPSED SOMETIME BETWEEN 6/29/19 AND 7/4/19. WE DID NOT PUT WEIGHT ON THE CAR. THE COIL SPRING JUST SHEARED SOMEHOW. THE CAR HAS 76K MILES ON IT AND HAS BEEN IN MI FOR THE LAST 3 YEARS. THE MECHANIC COULD NOT FIGURE OUT HOW THIS HAPPENED, AND WE ARE FRANKLY PUZZLED TOO. WE ARE NOT THE ONLY ONES WHO THIS HAS HAPPENED TO. HTTPS://WWW.CARGURUS.COM/CARS/DISCUSSION-T61866_DS789686

REAR PASSENGER SIDE SPRING COIL WAS BROKEN I DON'T KNOW WHEN. MY MECHANIC SAW IT WHEN SHE WAS REPLACING MY BREAKS. EVERY PERSON I SPOKE TO ABOUT THIS SAID IT HAD NEVER HAPPENED TO THEM, EVEN WITH CARS THEY BASICALLY RAN INTO THE GROUND, LET ALONE A 5 YEAR OLD CAR. MOST OF THE COMPLAINTS ABOUT 2014 FORESTERS ON NHTSA SEEMED TO BE ABOUT THIS SAME ISSUE. I BROUGHT IT TO THE DEALER, SINCE MOST GARAGES DIDN'T HAVE THE PARTS NEEDED, AND I WAS HOPING THAT SUBARU WOULD PAY SINCE THEY SEEMED TO USE SHODDY STEAL ON THE SPRINGS THAT RUSTED PREMATURELY. SUBARU OF WAKEFIELD IN MA GAVE ME THE BEST DEAL OF ANY IN MA THAT I TALKED TO, I PAY FOR ONE SIDE ($750 FOR WHEEL BEARINGS, STRUT AND COIL) AND SUBARU PAID FOR THE OTHER. MAKE SURE TO MENTION ALL THE COMPLAINTS ON NHSTA THAT SEEMED TO HELP ME GET THIS DEAL.