← New search

2004 Subaru Forester

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2004 Subaru Forester do not stand out strongly from the model-year median of 131.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Forester years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

188 reports with mileage · 31 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel/propulsion System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Suspension. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports4 fire reports7 injury reports

Fuel/propulsion System complaints

63 reports
Clear category filter
123,000 miles · May 1, 2018
Fuel/propulsion System

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT NOTICED AN ODOR OF FUEL AND A LEAK COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A DEALER. THE MANUFACTURER WAS…

Read full complaint

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT NOTICED AN ODOR OF FUEL AND A LEAK COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

NHTSA ODI #11091135

145,000 miles · Mar 18, 2018
Fuel/propulsion System

MY FORESTER HAS BEGUN TO SMELL LIKE GAS WHEN IT IS TURNED ON WHILE IT IS COLD OUTSIDE. A FUEL LINE IS LEAKING ON THE RIGHT SIDE FUEL RAIL. THE FUEL IS LEAKING RIGHT NEXT TO THE EXHAUST MANIFOLD AND THE TURBO (SEE, REALLY HOT PARTS, SEE ALSO, DANGEROUS). THIS IS A WELL KNOWN ISSUE WITH THE CAR AND IS A SERIOUS SAFETY HAZARD. I DO…

Read full complaint

MY FORESTER HAS BEGUN TO SMELL LIKE GAS WHEN IT IS TURNED ON WHILE IT IS COLD OUTSIDE. A FUEL LINE IS LEAKING ON THE RIGHT SIDE FUEL RAIL. THE FUEL IS LEAKING RIGHT NEXT TO THE EXHAUST MANIFOLD AND THE TURBO (SEE, REALLY HOT PARTS, SEE ALSO, DANGEROUS). THIS IS A WELL KNOWN ISSUE WITH THE CAR AND IS A SERIOUS SAFETY HAZARD. I DO NOT BELIEVE IT IS RIGHT TO REQUIRE OWNERS TO PAY HUNDREDS TO THOUSANDS OF DOLLARS TO KEEP THEIR CARS FROM BURSTING IN TO FLAMES. PLEASE SEE ALL THE OTHER COMPLAINTS ON THIS SAME ISSUE AND DO SOMETHING TO PROTECT AND REIMBURSE THE OWNERS OF THE VEHICLES FOR THIS SAFETY ISSUE. THANK YOU.

NHTSA ODI #11080085

Mileage unknown · Feb 8, 2018
Fuel/propulsion System

LEAKING FUEL LINE UNDER MANIFOLD, FUEL SMELL VERY STRONG AND LEAKS INTO ENGINE BAY.

NHTSA ODI #11071717

201,000 miles · Jan 4, 2018
Fuel/propulsion System

GOT UP TO AND STARTED MY CAR TO GET IT WARMED UP SINCE IT WAS 8 F OUTSIDE. 20 MINUTES LATER WHEN I GOT INTO THE CAR THERE WAS A STRONG SMELL OF GAS. UPON INSPECTION OF THE ENGINE COMPARTMENT I FOUND THAT THERE WAS A FUEL LINE ON THE DRIVERS SIDE DRIPPING GASOLINE ONTO THE ENGINE BLOCK, WHERE IT WAS POOLING. WHILE SEARCHING…

Read full complaint

GOT UP TO AND STARTED MY CAR TO GET IT WARMED UP SINCE IT WAS 8 F OUTSIDE. 20 MINUTES LATER WHEN I GOT INTO THE CAR THERE WAS A STRONG SMELL OF GAS. UPON INSPECTION OF THE ENGINE COMPARTMENT I FOUND THAT THERE WAS A FUEL LINE ON THE DRIVERS SIDE DRIPPING GASOLINE ONTO THE ENGINE BLOCK, WHERE IT WAS POOLING. WHILE SEARCHING ONLINE FOR INFO ON THIS, I FOUND THAT THIS IS A COMMON ISSUE WITH EARLY 2000'S SUBARUS, EVEN TO THE EXTENT THAT THEY RECALLED THE WRX MODELS FOR THIS EXACT REASON, BUT MADE NO MENTION OF THEIR OTHER MODELS.

NHTSA ODI #11058587

160,000 miles · Dec 30, 2017
Fuel/propulsion System

GAS SMELL COLD WEATHER CAR IDOLING

NHTSA ODI #11057668

125,000 miles · Dec 12, 2017
Fuel/propulsion System

JUST LIKE 60 OR SO OTHER 03-05 FORESTER XT OWNERS, I'M EXPERIENCING THE FUEL LEAK FROM THE RUBBER FUEL LINE WHERE IT CLAMPS ON TO THE METAL LINE TO THE FRONT DRIVERS SIDE INJECTOR. JUST LIKE EVERYONE ELSE, THE ISSUE ONLY OCCURRED WHEN TEMPERATURES DROPPED BELOW ABOUT 20F - UNCOINCIDENTALLY, IN MY OPINION, THIS WAS THE FIRST NEW …

Read full complaint

JUST LIKE 60 OR SO OTHER 03-05 FORESTER XT OWNERS, I'M EXPERIENCING THE FUEL LEAK FROM THE RUBBER FUEL LINE WHERE IT CLAMPS ON TO THE METAL LINE TO THE FRONT DRIVERS SIDE INJECTOR. JUST LIKE EVERYONE ELSE, THE ISSUE ONLY OCCURRED WHEN TEMPERATURES DROPPED BELOW ABOUT 20F - UNCOINCIDENTALLY, IN MY OPINION, THIS WAS THE FIRST NEW ENGLAND WINTER THIS CAR HAD EVER SEEN. SUBARU HAS ISSUED A RECALL FOR WRX WITH THE SAME EXACT ISSUE INVOLVING THE SAME EXACT HARDWARE. GET ON IT SUBARU, THIS IS COMPLETELY UNACCEPTABLE AND AN EXTREMELY DANGEROUS DESIGN FLAW. YOU'VE ALREADY FESSED UP TO THE ISSUE WITH OTHER VEHICLES USING THE EJ255 NOW DON'T FORGET ABOUT US FOZZY OWNERS.

NHTSA ODI #11054095

60,000 miles · Sep 25, 2017
Fuel/propulsion System

CAR HAS A STRONG GAS ODOR IN THE CAB WHEN TEMPERATURE DROPS TO 20 DEGREES AND BELOW. OCCURING ON COLD START AND CONTINUING IN MOTION ON LOCAL AND HIGHWAY DRIVING. AFTER A FEW UNSUCCESSFUL FIXES BY AUTHORIZED SUBARU SERVICE PROBLEM STILL EXISTS FOR THREE YEARS SOA NEEDS TO RECOGNISE THIS GAS LEAK FOR THIS MODEL AND YEAR AS A RE…

Read full complaint

CAR HAS A STRONG GAS ODOR IN THE CAB WHEN TEMPERATURE DROPS TO 20 DEGREES AND BELOW. OCCURING ON COLD START AND CONTINUING IN MOTION ON LOCAL AND HIGHWAY DRIVING. AFTER A FEW UNSUCCESSFUL FIXES BY AUTHORIZED SUBARU SERVICE PROBLEM STILL EXISTS FOR THREE YEARS SOA NEEDS TO RECOGNISE THIS GAS LEAK FOR THIS MODEL AND YEAR AS A RECALL AND PERMINENT FIX PLEASE HELP

NHTSA ODI #11025492

126,000 miles · Mar 15, 2017
Fuel/propulsion System

THERE IS A RAW GAS SMELL INSIDE THE CAR WHEN PARKED, OR STOPPED WHILE THE CAR IS RUNNING IN COLD WEATHER.

NHTSA ODI #10966013

76,000 miles · Feb 3, 2017
EngineFuel/propulsion System

FUEL LEAK IN LINES ABOVE ENGINE BUT BELOW INTAKE DURING COLDER WEATHER. FUEL FUMES PULLED INTO VEHICLE BY HEATING SYSTEM.

NHTSA ODI #10949258

Mileage unknown · Dec 28, 2016
Fuel/propulsion System

THERE IS A TERRIBLE GAS SMELL DURING COLD WEATHER FROM SOME LEAK IN THE FUEL LINE. OTHER SUBARU MODELS HAVE BEEN RECALLED FOR THIS SAME PROBLEM, BUT NOT THE FORESTER. THE SMELL IS SO BAD THAT IT HAS GIVEN ME HEADACHES AND NAUSEA. THE SMELL IS PARTICULARLY AWFUL WHEN THE HEAT IS TURNED ON, WHICH IS PROBLEMATIC SINCE ONE WANTS …

Read full complaint

THERE IS A TERRIBLE GAS SMELL DURING COLD WEATHER FROM SOME LEAK IN THE FUEL LINE. OTHER SUBARU MODELS HAVE BEEN RECALLED FOR THIS SAME PROBLEM, BUT NOT THE FORESTER. THE SMELL IS SO BAD THAT IT HAS GIVEN ME HEADACHES AND NAUSEA. THE SMELL IS PARTICULARLY AWFUL WHEN THE HEAT IS TURNED ON, WHICH IS PROBLEMATIC SINCE ONE WANTS THE HEAT ON WHEN IT'S THAT COLD OUT. SMELL PERSISTS AROUND THE CAR EVEN WHEN IT ISN'T RUNNING AND IS SO BAD I CAN'T PARK IT INSIDE MY ATTACHED GARAGE BECAUSE IT COMES INTO THE HOUSE. SUBARU REALLY NEEDS TO ADDRESS THIS. I HAVE MENTIONED IT TO MY MECHANIC SEVERAL TIMES AND THEY HAVE TRIED TO CORRECT IT BY TIGHTENING FUEL LINE CONNECTIONS, WHICH HAS NOT SOLVED THE ISSUE. THEY TOLD ME ABOUT THE OTHER MODELS BEING RECALLED, AND WHEN I RESEARCHED IT MYSELF I DISCOVERED THAT THERE ARE HUNDREDS (AT LEAST) OF SUBARU FORESTER OWNERS WHO HAVE COMPLAINED ABOUT THE SAME PROBLEM. THIS IS A HEALTH HAZARD. I DON'T THINK ANYONE SHOULD BE BREATHING THESE CONCENTRATED FUMES. SUBARU NEEDS TO DO A RECALL AND REPLACE THESE FAULTY LINES. THIS PROBLEM HAS BEEN ONGOING FOR AT LEAST THE PAST 2 YEARS/WINTERS. MY MOST RECENT VISIT TO THE MECHANIC (TO ADDRESS THE FUEL SMELL AGAIN) WAS DECEMBER 23, 2016.

NHTSA ODI #10937987

Official recalls

2

11V464000 · Suspension:front:control Arm:lower Arm

Sep 6, 2011

SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.

Consequence & remedy

Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.

04V473000 · Engine And Engine Cooling

Oct 1, 2004

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE COVER BOLTS FOR THE ENGINE OIL CONTROL VALVE MAY NOT BE SUFFICIENTLY TIGHTENED, ALLOWING OIL TO LEAK FROM AROUND THE COVER GASKET.

Consequence & remedy

Consequence: IF LEAKING OIL CONTACTS COMPONENTS OPERATING AT HIGH TEMPERATURES, A FIRE COULD RESULT IN THE ENGINE COMPARTMENT.

Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE OIL-FLOW CONTROL VALVE COVER BOLTS. THE RECALL BEGAN ON OCTOBER 8, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE11011 · Front Suspension Control Arm Failure

Opened Apr 7, 2011 · Closed Sep 23, 2011

Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Additional source detail variants (4)

Suspension:front:control Arm:lower Arm

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Suspension:front:control Arm

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Suspension:front

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Suspension

On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.

Go deeper into Subaru Forester problems