Electronic Stability Control (esc)Service Brakes, Hydraulic
I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT AND "SERVICE STABILITY SYSTEM". ALL ARE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNERS MANUAL) TEMPORARILY CAUSES THE LIGHTS AND MESSAGES TO TURN OFF, BUT THEY ALWAYS RET…
Read full complaint
I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT AND "SERVICE STABILITY SYSTEM". ALL ARE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNERS MANUAL) TEMPORARILY CAUSES THE LIGHTS AND MESSAGES TO TURN OFF, BUT THEY ALWAYS RETURN LATER. THIS PROBLEM IS WELL DOCUMENTED IN SATURN FORUMS AND IS HAPPENING WITH MANY, MANY OWNERS. *TR
NHTSA ODI #10432537
34,500 miles · Sep 2, 2008
Service Brakes, Hydraulic
I HAVE A 2006 SATURN RELAY. IT WAS AN EXECUTIVE DRIVEN CAR AND WAS PURCHASED WITH 400 MILES ON IT AND THE WARRANTY TRANSFERRED OVER TO ME. THE TRACTION CONTROL ON THIS VEHICLE IS DEFECTIVE. WHEN THE TRACTION CONTROL ENGAGED IT WOULD KNOCK OUT THE STABILITY CONTROL, TRACTION CONTROL, AND ABS SYSTEM. ALTHOUGH I HAVE BREAKS, TH…
Read full complaint
I HAVE A 2006 SATURN RELAY. IT WAS AN EXECUTIVE DRIVEN CAR AND WAS PURCHASED WITH 400 MILES ON IT AND THE WARRANTY TRANSFERRED OVER TO ME. THE TRACTION CONTROL ON THIS VEHICLE IS DEFECTIVE. WHEN THE TRACTION CONTROL ENGAGED IT WOULD KNOCK OUT THE STABILITY CONTROL, TRACTION CONTROL, AND ABS SYSTEM. ALTHOUGH I HAVE BREAKS, THEY ARE MANUAL BREAKS. AT FIRST SATURN SAID THE SYSTEM IS WORKING TO FACTORY SPECS UNTIL IT HAPPENED TO THEIR VEHICLE. THEN ALL OF A SUDDEN THERE WAS A PROBLEM WITH MINE. I DO NOT FEEL SAFE IN THE CAR BECAUSE, I SHOULD NOT HAVE TO WORRY ABOUT WHAT KIND OF BREAKING SYSTEM I HAVE WHEN TRYING TO ENGAGE MY BREAKS. I DO NOT WANT TO CAUSE HARM TO ANYONE OR HAVE ANY ACCIDENT CAUSED BY THIS RESULT IN DEATH. I DO NOT WANT HARM TO ME OR MY LOVED ONES EITHER. NO ONE AT SATURN OR SATURN OF GREENFIELD SENSES THE URGENCY OF THIS SITUATION. IT ISN'T UNTIL I COMPLAINT THAT I AT LEAST GET SOME TYPE OF ACTION, ALTHOUGH IT RESULTS IN THE SYSTEM FAILING AGAIN. I HAVE MY CAR IN TO HAVE THIS ISSUE FIXED EARLIER THIS SUMMER. THIS PAST WEEKEND, THE SYSTEM FAILED THREE TIMES IN TWO DAYS. NOT A GOOD RESULT. I NEED THIS DOCUMENTED SO THAT IN THE EVENT I AM INVOLVED IN A SERIOUS ACCIDENT, I WILL NOT BE ACCUSED OF NOT DISCLOSING THIS SITUATION. I CAN SAY THAT I DID AND NO ONE TOOK IT SERIOUSLY WHICH WILL PROBABLY RESULT IN A LONG MESSY LEGAL BATTLE. I HAVE DONE MY PART, BUT SATURN OF GREENFIELD AND GM (SATURN) HAS FAILED TO DO THEIRS. *TR
NHTSA ODI #10240568
12,500 miles · Jul 20, 2006
Service Brakes, Hydraulic
I WAS TRAVELING ON AZ STATE ROUTE 87 ON A 6 PERCENT DOWNGRADE. I HAD APPLIED THE BRAKES A TOTAL OF 3 TIMES FOR NO MORE THAN 3 TO 5 SECONDS AT A TIME, THIS OCCURRED OVER A 5 MINUTE TIME FRAME. ON THE THIRD APPLICATION THE BRAKES BEGAN TO CAVITATE VERY BADLY. THIS CAUSED THE VEHICLE TO SWAY AND BRAKES FADED OUT. THE BRAKES M…
Read full complaint
I WAS TRAVELING ON AZ STATE ROUTE 87 ON A 6 PERCENT DOWNGRADE. I HAD APPLIED THE BRAKES A TOTAL OF 3 TIMES FOR NO MORE THAN 3 TO 5 SECONDS AT A TIME, THIS OCCURRED OVER A 5 MINUTE TIME FRAME. ON THE THIRD APPLICATION THE BRAKES BEGAN TO CAVITATE VERY BADLY. THIS CAUSED THE VEHICLE TO SWAY AND BRAKES FADED OUT. THE BRAKES MADE A RUBBING SOUND FOR THE NEXT SEVERAL DAYS. WHEN BRAKES ARE APPLIED WHILE TURNING THEY MAKE A GRINDING SOUND/FEEL. THE VEHICLE WAS TAKEN INTO SATURN OF ARROWHEAD PEORIA, AZ ON 07/06/06. THEY STATED NOTHING WAS FOUND WRONG WITH BRAKES. THEY SAID IT IS COMMON FOR BRAKES TO FADE ON THIS VEHICLE GOING DOWN HILL. THEY STATED WE SHOULD DOWNSHIFT TO COMPENSATE. THEY CAN NOT EXPLAIN WHY BRAKES MAKE SOUND WHILE TURNING, THEY SAY BRAKES ARE FINE. I PERSONALLY BELIEVE PROBLEM IS THAT BRAKE ROTORS ARE TO SMALL FOR SIZE OF VEHICLE. THAT THEY HEAT UP TO QUICKLY AND FADE OUT AND ROTORS BEGIN TO WARP. THIS IS A DESIGN FLAW THAT CAN BE CORRECTED BY INCREASING ROTOR SIZE AND BRAKE SHOE SIZE, THERE IS PLENTY OF ROOM IN WHEEL WELL. *NM
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
2006 Saturn Relay Problems, Complaints & Recalls | Skip That Year
Illustration