Exterior Lighting. Review the 247 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports19 fire reports3 injury reports

What owners actually said

633 reports

84,000 miles · Sep 24, 2019

Air BagsElectrical System

Read full complaint

WHEN I FIRST GOT THE VEHICLE IN 2017 IT WAS ALWAYS PARKED IN THE GARAGE SO THE PROBLEM WASN'T NOTICED UNTIL I STOPPED USING THE GARAGE. WHEN IT RAINS A LOT WATER IS LEAKING THROUGH THE FRONT SUNROOF WHICH IS THEN DRAINING UNDERNEATH THE HOOD OF THE CAR IN THE ELECTRICAL AREA AND FINALLY LEAKING THROUGH THE FRONT PASSENGER SIDE FLOOR BOARDS. IT CAUSED ELECTRICAL ISSUES WITH THE OUTLOOK BECAUSE OF THE INITIAL SUNROOF 'CLOG'. ALSO THE CAR COULD BE DRIVEN BUT WHEN YOU TURNED OFF THE VEHICLE IT WOULD NOT SHUT DOWN. I'VE SEEN MANY ISSUES OF THE SAME PROBLEM THAT OTHER OWNERS ARE HAVING AS WELL WITH THEIR OUTLOOKS. IF THE NUMBERS ARE THERE FROM PEOPLE COMPLAINING I'M NOT UNDERSTANDING WHY THIS HASN'T BEEN INVESTIGATED AND TURNED INTO A RECALL. WHAT STARTS AS A SUNROOF LEAK CAN EASILY AND QUICKLY LEAD TO THOUSANDS OF DOLLARS WORTH OF REPAIRS BECAUSE THE WATER IS LEAKING UNDER THE HOOD AREA.

NHTSA ODI #11257808

Mileage unknown · Aug 6, 2019

Engine

OIL LEAKING FROM THE FRONT OF THE ENGINE. I THINK ITS AN INTERNAL LEAK

NHTSA ODI #11241922

67,430 miles · Jul 4, 2019

Power Train

Read full complaint

DEAR NHTSA, PLEASE FIRST REFER TO THIS KNOWN ISSUE: NHTSA ID NUMBER: 10126145 MANUFACTURER COMMUNICATION NUMBER: GCUS-9-2635 14404B ' SPECIAL COVERAGE.BULLETIN. THIS WAS AN OFFER FROM GM TO REPAIR THIS KNOWN DEFECT IF IT OCCURED EITHER BEFORE 120K MILES OR 10 YEARS. MY WIFE'S 2008 SATURN OUTLOOK IS USED FOR KID TRANSPORTATION AND LOCAL TRIPS MOSTLY SO SHE NEVER PUTS ON THAT MUCH MILEAGE. THIS VEHICLE WENT INTO SERVICE IN OR AROUND 10/2008. ON OR AROUND MARCH 1, 2019 HER OUTLOOK BEGAN TO EXPERIENCE ISSUES CONSISTENT WITH THIS GM TSB, FAILURE OF THE 35R WAVE PLATE, A KNOW ISSUE DOCUMENTED BY GM.THE THING WOULD JERK AND SHAKE IN REVERSE, WOULD EITHER FAIL TO SHIFT INTO 3RD OR 5TH OR IF IT DID, WHINE AND SHOW NO ACCELERATION IN THE LEAST. IT HAPPENED ABOUT 10 TIMES, ON LOCAL ROADS AND ON THE HIGHWAY, VERY DANGEROUS. I TOOK THE VEHICLE IN TO OUR LOCAL CHEVY DEALER AND WAS TOLD THAT THE TRANSMISSION WAS SHOT, ONLY 67K MILES AND IT NEEDED TO BE REPLACED. I ASKED THE SERVICE WRITER ABOUT HAVING THE TRANSMISSION REPAIRED RATHER THAN REPLACED. HE REALLY RECOMMENDED A FACTORY REBUILT UNIT. WE WERE LITERALLY 120 DAYS, 4 MONTHS OUTSIDE OF THE WARRANTY COVERAGE PERIOD ON THIS ISSUE. SATURN/GM WOULD NOT BUDGE AND TOLD ME THAT AT SOME POINT I HAD TO OWN THE RESPONSIBILITY OF THE REPAIR! REALLY? ON A KNOW ISSUE THAT WAS OUTLINED IN THE TSB AS, "UPON FAILURE ONLY" SHOULD I BRING MY VEHICLE IN FOR REPAIR. HOW IS THIS FAIR? I HAVE NO IDEA WHAT I EXPECT FROM THE NHTSA, BUT TO SIMPLY KNOW THAT GM SHOULD HAVE HONORED THE REPAIR OR REPLACEMENT, IT WAS ONLY FOUR MONTHS PAST THE CUT OFF AND IT IS A KNOW ISSUE. THANKS FOR LISTENING, I DO PLAN TO FILE A SMALL CLAIMS CASE AND CONTACT ANY AND ALL CONSUMER PROTECTION AGENCIES ABOUT THIS MATTER. (XXXXX) REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11229465

190,000 miles · Jun 14, 2019

Electrical SystemStructureUnknown Or Other

Read full complaint

TAKATA RECALL....WATER LEAKS INTO THE CAR BEHIND KICKER PANEL ON PASSENGER SIDE GOING DIRECTLY INTO THE FUSE/RELAY BOX. IT LEAKS IN ALL DOOR JAMS AND THE REAR LIFTGATE AREA. I HAVE PROBLEMS WITH MY CAR NOT SHIFTING. THROWING CODE P2723 WHICH IS TRANSMISSON PRESSURE CONTROL SHIFT SOLENOID E. I BELIEVE ITS DUE TO WATER GETTING INTO THE FUSE BOX BECAUSE THERE IS A CONSTANT DRAIN ON MY BATTERY AND WHEN TESTING THE FUSES WITH A TEST LIGHT NOT ALL OF THEM SEEM TO BE GETTING A GOOD CONNECTION DUE TO ALL THE CORROSION. ALSO SUNROOF LEAKS. ALL DOOR CIRCUITS GET WET. I HAVE TO DRY EVRYTHING OUT BEFORE I CAN START IT. THE CARPET SMELLS AND ITS FULL OF RUST. COMMON SENSE WOULD TELL YOU THAT THIS CANNOT BE GOOD FROM ANY ASPECT. IM TO THE POINT TO GOING UP TO GM AND MAKING THEM LOOK REALLY BAD BECAUSE THIS IS UNACCEPTABLE. I CANNOT BELIEVE WITH SO MANY COMMON PROBLEMS THERE IS YET TO BE A RECALL. I HATE GM AND NEVER WILL I EVER PURCHASE ANY GM PRODUCT NOR WILL I HAVE ANYTHING GOOD TO SAY ABOUT GM. WHEN ALL THIS OCCURED MY CAR WAS OUTSIDE EITHER IN MY DRIVEWAY OR A PARKING LOT OR DRIVING DOWN THE ROAD. I HAVR TO COVER THE CAR UP. THE ENTIRE CAR. I BOUGHT THE CAR SOMETIME LAST YEAR. I NOTICED THIS WAS HAPPENING ABOUT 4-5 MONTHS AFTER PURCHASE. IVE TRIED FIXING IT MYSELF AND I JUST FAIL EVERYTIME AND ITS RIDICULOUS.

NHTSA ODI #11219956

100,000 miles · May 30, 2019

Exterior Lighting

Read full complaint

HEADLIGHT BULB KEEPS BLOWING OUT AND SOMETIMES WHEN CHANGED COMES ON AND OFF INTERMITTENTLY. HAVE CHANGED BULBS NUMEROUS TIMES BUT CONTINUES TO HAPPEN. BULBS SEEM EXTREMELY HOT WHEN THEY BLOW. WE HAVE HAD IT REWIRED NUMEROUS TIMES BUT LOOKS LIKE WIRES FROM HARNESS ARE DIFFERENT GAUGES THAN REPLACEMENTS. THIS IS DANGEROUS BECAUSE I NEVER KNOW WHEN I WILL BE WITHOUT A HEADLIGHT. THEY ARE DIM AND EVEN WHEN REPLACED BY SILVERSTAR ULTRA, THEY REMAIN DIMMER THAN MOST VEHICLES. I KNOW THIS BECAUSE I CAN SEE THEIR HEADLIGHTS MORE THAN MINE WHEN THEY ARE BEHIND ME. I CANNOT SEE THE ROAD HARDLY AT ALL WHEN DRIVING WITH ONE HEADLIGHT.

NHTSA ODI #11216956

Mileage unknown · May 24, 2019

Air BagsEngineSteering

Read full complaint

POWER STEERING RANDOMLY GOES OUT AND RETURNS CAUSING JERKY LURCHING TURNS COUPLE YEARS NOW SINCE REACHING OVER 100K MILEAGE, HAVE 173K MILES CURRENTLY. IS NOW LEAKING FLUID. PCV VALVE REPLACED TWICE, NOT RECALLED BUT MECHANICS HAVE SAID IT'S COMMON FOR MY VEHICLE, CAUSES HESITATION WHILE IDLING LIKE IT'S TRYING TO STALL OUT. HAVE HAD TO PUT FOOT ON BRAKE AND REV GAS AT STOPLIGHTS. AIRBAG LIGHT HAS BEEN ON FOR YEARS, PASSENGER SIDE DOESN'T DETECT. ALTHOUGH RECALL, DEALERSHIP WANTS TO CHARGE DIAGNOSTIC FEES EVEN WHEN I HAD DONE FOR FREE AT LOCAL PARTS STORE AND GAVE THEM CODE, THEY SAY HAVE TO DO THEIR OWN. PASSENGER WINDOW DOES NOT ROLL DOWN, BUT DOES ROLL UP, WITH DRIVER'S SIDE CONTROLS, DOES WORK WITH PASSENGER SIDE CONTROLS. SOMETIMES DRIVER'S SIDE WINDOW STICKS TOO EITHER UP/DOWN HAVE TO BANG ON DOOR FOR IT TO ENGAGE. SPEAKERS HAVEN'T WORKED PROPERLY IN YEARS EITHER.

NHTSA ODI #11209626

134,000 miles · May 10, 2019

Air BagsElectrical SystemElectronic Stability Control (esc)

BAUGBT THE VEHICLE MARCH 10 2019 NO AIR BAG CRACKED STEERING WHEEL SUNROOF LEAKS BAD UNDER GLOVEBOX FUSE SECTION HAS RUST POWDER. STERO GOES ON AND OFF ONLY ONE KEY WORKS TO START ONE WORKS TO OPEN DOOR HEATER DONT WORK IM FRONT. BAUGHT IN PUEBLO COLORADO ONLY DRIVE AS FAR AS WALSENBURG CO AND BACK TO PUEBLO N9 FURTHER BAD GAS M…

Read full complaint

NHTSA ODI #11206779

148,000 miles · Apr 22, 2019

Visibility

TL* THE CONTACT OWNS A 2008 SATURN OUTLOOK. THE CONTACT STATED THAT THE SUN ROOF LEAKED WHEN IT RAINED AND WATER ENTERED THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND REPAIRED TWICE, BUT THE FAILURE RECURRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETE…

Read full complaint

NHTSA ODI #11202955

Mileage unknown · Mar 15, 2019

Electrical SystemUnknown Or Other

MY SUNROOF WAS LEAKING IN MY CAR AND CAUSED AN ELECTRICAL PROBLEM THE AUTO SHOP SAID IT WOULD COST 7000 TO FIX IT

NHTSA ODI #11187093

80,000 miles · Feb 14, 2019

Electrical SystemElectronic Stability Control (esc)EngineFire

Read full complaint

ISSUES WITH MY OUTLOOK ALTERNATOR CAUGHT ENGINE ON FIRE, ELECTRICAL ISSUES WITH STABILIZER/TRACKING CONTROLS, WINDOWS/MIRROR AND MAINLY CHECK ENGINE LIGHT COMES ON WHILE DRIVING AND TRANSMISSION SLIPS INTO LOW OR 2ND GEAR. I HAD TO PULL TO EMERGENCY LANE AND HAVE VEHICLE TOWED TWICE. DEALER STATES ITS AN ISSUE WITH OBD/OBI CODES AND CLEARS CODE. VEHICLE CONTINUES TO DO THIS ALMOST DAILY, WEEKLY. WATER LEAKS THROUGH SUNROOF, FRONT WINDOW GLASS, UNDER DASH ON FEET OF DRIVER AND PASSENGER; WATER LEAKS VIA DVD SYSTEM WHILE DRIVING AND STATIONARY. ALTERNATOR CAUGHT ON FIRE WHILE DRIVING AND I COASTED INTO A DRIVEWAY AND LIFTED HOOD THE FLAMES STARTED, FIRE DEPT. CONTACTED IMMEDIATELY TO PUT OUT. DAMAGE TO VEHICLE WIRES, TUBES, ETC UNDER HOOD. PASSENGER SIDE FRONT WINDOW AND MIRROR WILL NOT PUSH OUT OF ROLL DOWN DUE TO ELECTRICAL ISSUE DRIVING AND STATIONARY. RECALL ON STRUTS FOR AUTO LIFT GATE, BUT REAL ISSUE IS MODULE TO LIFT LIFTGATE WAS A FEE TO BE REPAIRED. WHAT DID RECALL COVER WITH LIFT GATE? THESE ISSUES HAPPEN NO STOP SINCE 2012 WHEN VEHICLE WAS PURCHASED USED. I DROVE ON INTERSTATE AND AND CHECK ENGINE LIGHT CAME ON, TRANSMISSION WENT TO LOW GEAR AND I ALMOST WAS HIT BECAUSE VEHICLE JERKED WHEN THIS HAPPENED AND POWER/SPEED INSTANTLY DROPPED.

NHTSA ODI #11180048

Official recalls

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

14V118000 · Air Bags:side/window

Mar 17, 2014

General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

Consequence & remedy

Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.

Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12003 · Loss Of Headlamp Illumination

Opened Jun 4, 2012 · Closed Jul 24, 2014

Status: closed (inferred from source dates) · Exterior Lighting:headlights

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

Electrical System

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Engine And Engine Cooling:engine

Engine And Engine Cooling

Visibility:windshield Wiper/washer

Visibility:windshield Wiper/washer:switch/wiring