Exterior Lighting. Review the 247 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports19 fire reports3 injury reports

What owners actually said

633 reports

85,000 miles · Dec 6, 2014

Electronic Stability Control (esc)EnginePower Train

Read full complaint

APPROXIMATELY APRIL OF 2014 WE HAD THE FIRST INCIDENT: WHILE DRIVING ON THE HIGHWAY, AT SPEED, THE TRANSMISSION SEEMED TO "POP" INTO NEUTRAL (NO CHANGE OF GEARSHIFT LEVER, JUST ENGINE REVVED). AS THE TRUCK NO LONGER HAD POWER, WE MANAGED (THANK GOODNESS) TO GET THE TRUCK TO THE SHOULDER AVOIDING HIGHWAY TRAFFIC. MOVED GEARSHIFT LEVER TO PARK AND THEN BACK TO DRIVE WITH NO CHANGE - ENGINE JUST REVVED AS IN NEUTRAL. TURNED THE TRUCK OFF AND CALLED FOR A TOW. WHILE WAITING FOR SAME, WE TURNED THE TRUCK BACK ON, AND TRANSMISSION SEEMED TO FUNCTION NORMALLY. BROUGHT THE TRUCK TO BOTH WIND GAP CHEVROLET (PLACE OF PURCHASE) AS WELL AS AN INDEPENDENT AAMCO - VERDICT WAS THE SAME: BROKEN "WAVE PLATE" AND A NEW TRANSMISSION WAS NEEDED AT A COST OF OVER $3000.00. PROBLEM CONTINUES TO THIS DATE. WHEN WE REFERENCED THE ENDLESS ONLINE COMPLAINTS OF SAME, GM WAS UNMOVED, ALTHOUGH THE POWER TRAIN WARRANTY WAS STILL IN EFFECT. VERY DANGEROUS - LOSE POWER AT HIGHWAY SPEED WITH MULTIPLE CLOSE CALLS!!!! HEADLIGHTS: HEADLIGHTS, BOTH LOW AND HIGH BEAM, CONTINUALLY BURN ANYWHERE FROM MINUTES TO DAYS AFTER BEING REPLACED. SWITCH ASSEMBLIES HAVE BEEN REPLACED, CANNOT GET LOW BEAMS TO ILLUMINATE AT TIMES, THEN NO HEADLIGHTS AT TIMES. VERY DANGEROUS. AGAIN, ENDLESS ONLINE COMPLAINTS OF THE SAME ISSUE. SUNROOF: ENDLESS ISSUES WITH THE SUNROOF LEAKING AND SOAKING THE FLOORBOARDS ON BOTH DRIVERS AND PASSENGER SIDES. TAKEN TO WIND GAP CHEVROLET, TOLD WE NEED TO HAVE SUNROOF REPLACED. AGAIN, ENDLESS ONLINE COMPLAINTS OF THE SAME ISSUE. BASED ONLINE AND ON THIS NHTSA SITE: IT SEEMS THAT THESE ARE SERIOUS AND DANGEROUS ISSUES WITH THIS VEHICLE!!!!! RECENT HEADLIGHT RECALL ON SIMILAR VEHICLES FOR THE SAME ISSUE. WHY IS THIS VEHICLE NOT RECALLED FOR TRANSMISSION/POWER TRAIN AND HEADLIGHT ISSUES!?!? *TR

NHTSA ODI #10662562

138,000 miles · Nov 25, 2014

Air BagsService BrakesVehicle Speed Control

ABOUT EVERY 5 MIN BEEPING SOUND WOULD SOUND AND DASHBOARD STATED,SERVICE AIR BAG,SERVICE BRAKES/STABILIZER & WOULD CUTOFF CRUISE CONTROL.HEADLIGHTS VERY DIM AT NIGHT. *TR

NHTSA ODI #10660891

91,634 miles · Nov 23, 2014

Air BagsElectrical System

Read full complaint

IN MARCH OF THIS YEAR I TURNED MY 2008 SATURN OUTLOOK INTO HALEY GMC IN MIDLOTHIAN VA TO FIX A RECALL CONCERNING AN AIR BAG WARNING LIGHT THAT WAS ON IN THE CAR. AIR BAG RECALL 14030 WAS PERFORMED, HOWEVER, THE WARNING LIGHT WAS STILL ON IN THE CABIN. SERVICE DEPARTMENT AT HALEY INFORMED ME THAT THE RECALL WAS PERFORMED PER GM SPECIFICATIONS HOWEVER, THE WARNING LIGHT WAS STILL ON DUE TO A FAULTY PASSENGER PRESENCE MODULE (DIAGNOSTIC CODE: B0081). AT THE TIME OF THIS REPAIR I HAD AN EXTENDED WARRANTY UNDER THE GMPP (GENERAL MOTORS PROTECTION PLAN) WHICH WAS STILL VALID UNTIL AUGUST OF 2014 OR 107,000 MILES WHICH EVER CAME FIRST. I WAS TOLD BY GMPP THAT THIS MODULE WAS NOT COVERED UNDER MY CURRENT WARRANTY. SINCE THIS VISIT I HAVE TAKEN MY COMPLAINT THROUGH NOT ONLY THE DEALERSHIP BUT THROUGH CORPORATE GM ON TWO SEPARATE OCCASIONS PLEADING WITH THEM THAT THIS WAS A SAFETY RELATED ISSUE NOT A WARRANTY ISSUE. GM HAS STATED TO ME THAT THIS IS NOT A SAFETY RELATED ISSUE AND THAT THIS PART IS NO LONGER COVERED UNDER WARRANTY. THEY WANT ME TO PAY THEM $900 FOR THIS REPAIR AND I REFUSE TO PAY THEM BECAUSE THIS REPAIR SHOULD BE COVERED UNDER GENERAL MOTORS. THIS SAME ISSUE HAS BEEN REPORTED BY NUMEROUS OTHER GM VEHICLES BESIDES THE SATURN OUTLOOK, INCLUDING THE GMC ACADIA AND SATURN SKY. I WOULD LIKE TO GET ASSISTANCE FROM YOUR DEPARTMENT IN CHALLENGING BACK TO GM TO GET THIS ISSUE ADDRESSED FOR I AM DRIVING AROUND IN AN UNSAFE VEHICLE THAT THERE IS A GOOD CHANCE THAT IF A PASSENGER IS TRAVELING WITH ME IN THE FRONT OF THE VEHICLE THAT THE AIR BAG WILL NOT GO OFF IN A FRONTAL COLLISION. *TR

NHTSA ODI #10660310

85,000 miles · Nov 21, 2014

EngineService Brakes

DASHBOARD INFORMATION CENTER WARNINGS OF STABILITRACK AND SERVICE BRAKES WITH AUDIBLE CHIMES DURING DRIVING. WENT TO DEALERSHIP AND FOUND OUT THAT THE MASTER CYLINDER WAS LEAKING INTO BRAKE BOOSTER. NO EVIDENCE OF BRAKE LEAK EVER. SEEMS TO BE ONGOING FAILURE WITH THIS MODEL OF ALL OF GM PRODUCT LINES AND A VERY EXPENSIVE REPAIR…

Read full complaint

NHTSA ODI #10660071

125,000 miles · Nov 14, 2014

Power Train

Read full complaint

TRANSMISSION FAILURE DUE TO FRACTURED WAVE PLATE 3/5. THE 6T70/75 6-SPEED AUTOMATIC TRANSMISSION MAY EXPERIENCE NO REVERSE AND SLIP/FLARE/HARSH SHIFTS IN 3RD AND/OR 5TH GEAR. CODES P0776 CLUTCH PRESSURE CONTROL (PC) SOLENOID 2 STUCK OFF AND P0842 TRANSMISSION FLUID PRESSURE (TFP) SWITCH 1 CIRCUIT LOW VOLTAGE MAY BE SET. THE 35R CLUTCH WAVE PLATE MAY BE BROKEN, ALLOWING THE PISTON TO OVERSTROKE, CAUSING THE PISTON TO LEAK AND RESULTING IN LOSS OF APPLY ON VEHICLES WITH GREATER THAN 25,000 MILES. DURING THE REPAIR PROCESS IT IS IMPORTANT TO INSTALL THE WAVE PLATE IN THE PROPER ORIENTATION TO PREVENT THE POSSIBILITY FOR THE FAILURE TO RE-OCCUR. INSTALL THE ROUNDED EDGE OF THE NEW WAVE PLATE INTERNAL SPLINES FACING THE 35R PISTON. NOTE: THE SAME TSB APPLIES TO 2007-2009 GMC ACADIA, 2007-2009 PONTIAC G5, 2008-2009 PONTIAC TORRENT, 2008-2009 BUICK ENCLAVE, 2008-2009 CHEVROLET EQUINOX AND MALIBU, AND 2009 CHEVROLET TRAVERSE, EQUIPPED WITH THE 6T70/75 6-SPEED AUTOMATIC TRANSMISSION (RPO MH2, MH4, MH6 AND MY9). *TR

NHTSA ODI #10654957

98,000 miles · Nov 12, 2014

Steering

TL* THE CONTACT OWNS A 2008 SATURN OUTLOOK. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS ATTEMPTING TO MAKE A TURN, A LOUD ABNORMAL SQUEAKY NOISE EMITTED FROM THE STEERING COLUMN AND EXCESSIVE FORCE WAS REQUIRED IN ORDER TO TURN THE WHEEL. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE HAD NOT BEEN DIAGNOSED.…

Read full complaint

NHTSA ODI #10654582

100,333 miles · Nov 5, 2014

Air Bags

Read full complaint

MY 2008 SATURN OUTLOOK WAS TAKEN INTO THE DEALER FOR THE "SERVICE AIR BAG RECALL" WHICH WAS RESET BY THE DEALER, THE LIGHT CAME ON THE FOLLOWING DAY..THE CAR WAS TAKEN BACK TO THE DEALER THE FOLLOWING WEEK TO HAVE IT LOOKED AT AGAIN, AS TO WHICH THE DEALER CHARGED US $120.00 TO LOOK AT IT THIS TIME WHICH IS ABSURD, SINCE THIS IS A RECALL WHY SHOULD WE OWNERS HAVE TO PAY ANYTHING..THEY INFORMED US THAT IT WAS A BAD SENSOR UNDER THE SEAT AND THAT IT WAS NOT COVERED BY THE WARRANTY...THE DEALER INFORMED US THAT IT WOULD COST $965.00 TO BE FIXED, I'VE BEEN DOING RESEARCH AND COME TO MY FINDINGS MANY OTHER OWNERS OF THE SAME VEHICLE HAVE HAD THE SAME PROBLEM, AND THE SAME ISSUE WITH THE DEALER HAVING THE OWNER PAY FOR THIS PROBLEM..THIS PROBLEM WITH THE VEHICLE SHOULD BE COVERED BY THE DEALER NOT US OWNERS, SINCE IT IS A RECALL, THEY WILL NOT REPLACE A LOVED ONE IF THERE IS AN ACCIDENT WILL THEY? OF COURSE NOT. *TR

NHTSA ODI #10652616

105,000 miles · Oct 15, 2014

Power Train

TL* THE CONTACT OWNS A 2008 SATURN OUTLOOK. THE CONTACT STATED THAT THE VEHICLE FAILED TO REVERSE AND WOULD NOT ACCELERATE OVER 20 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILE…

Read full complaint

NHTSA ODI #10644830

79,000 miles · Sep 25, 2014

Electrical SystemEngineFire

I WAS TRAVELING ABOUT 60 MPH ON HWY. CAR SHUT OFF AND BACK ON, IT WAS ALSO RAINING. SMELT REALLY BAD LIKE A FIRE. WENT STRAIGHT HOME, TOOK CAR TO SHOP THE NEXT DAY. THE WATER LEAK I THOUGHT HAD BEEN FIXED WAS LEAKING INTO THE ELECTRICAL BOARD CAUSED A BURN OUT WHILE I WAS DRIVING BECAUSE IT WAS RAINING. *TR

NHTSA ODI #10639028

77,000 miles · Sep 24, 2014

Vehicle Speed Control

Read full complaint

WHILE DRIVING MY SATURN 2008 OUTLOOK I FELT SOMETHING "SLIP" AND MY CAR WOULDN'T ACCELERATE ANYMORE. I WOULD ACCELERATE ON THE GAS WHICH WOULD JUST CAUSE THE ENGINE TO REV. THE CHECK ENGINE LIGHT CAME ON(THE SERVICE AIRBAG LIGHT WAS ALREADY ON). I WAS BASICALLY STUCK IN THE MIDDLE OF THE ROAD. WE HAVE BEEN TOLD IT MAY BE TRANSMISSION ISSUES AND WILL COST APPROX. $2500.00. AFTER RESEARCHING I HAVE NOTICED I AM NOT THE ONLY ONE WITH THESE ISSUES. A RECALL IS IN ORDER AFTER READING ABOUT THE MANY ISSUES WITH THIS VEHICLE! 77000 MILES AND WE HAVE THIS ISSUE. WE HAVE A 2007 HYUNDAI WHICH WE HAVE NEVER HAD PROBLEMS WITH! *TR

NHTSA ODI #10638761

Official recalls

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

14V118000 · Air Bags:side/window

Mar 17, 2014

General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

Consequence & remedy

Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.

Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12003 · Loss Of Headlamp Illumination

Opened Jun 4, 2012 · Closed Jul 24, 2014

Status: closed (inferred from source dates) · Exterior Lighting:headlights

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

Electrical System

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Engine And Engine Cooling:engine

Engine And Engine Cooling

Visibility:windshield Wiper/washer

Visibility:windshield Wiper/washer:switch/wiring