Exterior Lighting. Review the 247 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports19 fire reports3 injury reports

Engine complaints

37 reports

Clear category filter

159,000 miles · Jul 2, 2020

Electrical SystemEngine

Read full complaint

ENGINE POWER REDUCED- THIS HAS HAPPENED ON SEVERAL OCCASIONS, WHERE THE ENGINE JUST STOPPED RUNNING WHILE DRIVING, IN TOWN. MAIN WIRING HARNESS WAS REPAIRED THE FIRST TIME BECAUSE INSULATION WAS DETERIORATED AND WIRING WAS STUCK TOGETHER. LESS THAN TWO WEEKS LATER, ENGINE STOPS AGAIN WHILE DRIVING IN TOWN, WAS ABLE TO COAST TO THE SIDE OF ROAD, CAR RESTARTED, TRYING TO GET HOME, CAR DIED AGAIN, WOULD NOT RESTART, TOWED TO AUTO SHOP AGAIN. AUTO REPAIR IS UNABLE TO DIAGNOSE THE PROBLEM, IT WILL RUN GREAT AND JUST RANDOMLY STOP RUNNING WHILE DRIVING, CAR HAS BEEN IN THE SHOP FOR ALMOST 2 WEEKS NOW. NOTHING IS CODING WHEN THEY RUN DIAGNOSTICS. THEY HAVE CHECKED EVERYTHING POSSIBLE! I AM HAVING THEM KEEP THE CAR UNTIL PROBLEM IS RESOLVED BECAUSE I AM SCARED TO DRIVE IT AND END UP IN A WRECK. I HAVE BEEN FORTUNATE THAT I WAS IN TOWN WHEN THIS HAS HAPPENED, THAT I WAS IN TOWN AND MY GRANDKIDS WERE NOT IN THE CAR WITH ME! THIS IS A VERY SERIOUS SAFETY RISK!!! THANK GOODNESS I DIDN'T GO ON A PLANNED 12 HOUR TRIP TO COLORADO! NOTE: I HAVE ALREADY PUT $6500.00 IN REPAIRS WITHIN THE LAST YEAR BECAUSE OF RANDOM ISSUES WITH THE VEHICLE.

NHTSA ODI #11337172

Mileage unknown · Aug 6, 2019

Engine

OIL LEAKING FROM THE FRONT OF THE ENGINE. I THINK ITS AN INTERNAL LEAK

NHTSA ODI #11241922

Mileage unknown · May 24, 2019

Air BagsEngineSteering

Read full complaint

POWER STEERING RANDOMLY GOES OUT AND RETURNS CAUSING JERKY LURCHING TURNS COUPLE YEARS NOW SINCE REACHING OVER 100K MILEAGE, HAVE 173K MILES CURRENTLY. IS NOW LEAKING FLUID. PCV VALVE REPLACED TWICE, NOT RECALLED BUT MECHANICS HAVE SAID IT'S COMMON FOR MY VEHICLE, CAUSES HESITATION WHILE IDLING LIKE IT'S TRYING TO STALL OUT. HAVE HAD TO PUT FOOT ON BRAKE AND REV GAS AT STOPLIGHTS. AIRBAG LIGHT HAS BEEN ON FOR YEARS, PASSENGER SIDE DOESN'T DETECT. ALTHOUGH RECALL, DEALERSHIP WANTS TO CHARGE DIAGNOSTIC FEES EVEN WHEN I HAD DONE FOR FREE AT LOCAL PARTS STORE AND GAVE THEM CODE, THEY SAY HAVE TO DO THEIR OWN. PASSENGER WINDOW DOES NOT ROLL DOWN, BUT DOES ROLL UP, WITH DRIVER'S SIDE CONTROLS, DOES WORK WITH PASSENGER SIDE CONTROLS. SOMETIMES DRIVER'S SIDE WINDOW STICKS TOO EITHER UP/DOWN HAVE TO BANG ON DOOR FOR IT TO ENGAGE. SPEAKERS HAVEN'T WORKED PROPERLY IN YEARS EITHER.

NHTSA ODI #11209626

80,000 miles · Feb 14, 2019

Electrical SystemElectronic Stability Control (esc)EngineFire

Read full complaint

ISSUES WITH MY OUTLOOK ALTERNATOR CAUGHT ENGINE ON FIRE, ELECTRICAL ISSUES WITH STABILIZER/TRACKING CONTROLS, WINDOWS/MIRROR AND MAINLY CHECK ENGINE LIGHT COMES ON WHILE DRIVING AND TRANSMISSION SLIPS INTO LOW OR 2ND GEAR. I HAD TO PULL TO EMERGENCY LANE AND HAVE VEHICLE TOWED TWICE. DEALER STATES ITS AN ISSUE WITH OBD/OBI CODES AND CLEARS CODE. VEHICLE CONTINUES TO DO THIS ALMOST DAILY, WEEKLY. WATER LEAKS THROUGH SUNROOF, FRONT WINDOW GLASS, UNDER DASH ON FEET OF DRIVER AND PASSENGER; WATER LEAKS VIA DVD SYSTEM WHILE DRIVING AND STATIONARY. ALTERNATOR CAUGHT ON FIRE WHILE DRIVING AND I COASTED INTO A DRIVEWAY AND LIFTED HOOD THE FLAMES STARTED, FIRE DEPT. CONTACTED IMMEDIATELY TO PUT OUT. DAMAGE TO VEHICLE WIRES, TUBES, ETC UNDER HOOD. PASSENGER SIDE FRONT WINDOW AND MIRROR WILL NOT PUSH OUT OF ROLL DOWN DUE TO ELECTRICAL ISSUE DRIVING AND STATIONARY. RECALL ON STRUTS FOR AUTO LIFT GATE, BUT REAL ISSUE IS MODULE TO LIFT LIFTGATE WAS A FEE TO BE REPAIRED. WHAT DID RECALL COVER WITH LIFT GATE? THESE ISSUES HAPPEN NO STOP SINCE 2012 WHEN VEHICLE WAS PURCHASED USED. I DROVE ON INTERSTATE AND AND CHECK ENGINE LIGHT CAME ON, TRANSMISSION WENT TO LOW GEAR AND I ALMOST WAS HIT BECAUSE VEHICLE JERKED WHEN THIS HAPPENED AND POWER/SPEED INSTANTLY DROPPED.

NHTSA ODI #11180048

160,000 miles · Oct 7, 2018

EnginePower TrainService Brakes

Read full complaint

BOUGHT FROM STERLING MOTORS IN WATERTOWN SD, IN 2017. TRADE IN WAS 2000, PLUS 500 DOLLARS CASH, FOR A 2008 SATURN OUTLOOK XR AWD. LOAN WAS FOR 10000 AFTER THE 2500 TRADE/PAYMENT. HAD 160000 MILES NOW HAS 180000. WITHIN LESS OF A WEEK CHECK ENGINE LIGHT COMES ON, STABILITRAC, SERVICE AIR BAG, TIMING CHAIN, TRACTION CONTROL ALL CAME ON. AS OF 2018 WE HAVE REPLACED ALL FOUR TIRES, BRAKES. STRUTS, ROTORS, TIE RODS, BATTERY, CO2 SENSOR, THERMOSTAT, AND A FEW OTHER THINGS. IT STILL NEEDS POWER STEERING PUMP, TIMING CHAIN FIX, CV JOINTS REPLACED AND WHO KNOWS WHAT ELSE. I'VE COMPLAINED TO THE DEALER AND HE TOLD ME I CAN NOT TRADE BACK, AND WHEN WE BOUGHT IT HE SAID IT PASSED THE SUSPECTION TEST AND CLAIMED NOTHING WAS WRONG WITH IT. HE HAD TO TOP OF THE POWER STEERING FLUID AS IT WAS WHINING AND LOW, SAID THAT IT WAS BECAUSE THEY FLUSHED IT. SO NOW UPON TURNING IT HAS THIS WEIRD RUBBING VIBRATION AND LOUD SOUND, IT SHAKES AT ALL SPEEDS, IT LOSES POWER WHILE DRIVING STUTTERS AT LOW SPEEDS, PASSENGER WINDOW BUTTON DON'T WORK, LOUD NOISES WHEN IDLING, WHINING NOISE FROM POWER STEERING EITHER JUST FROM STATIONARY OR DRIVING. IT TAKES FOREVER TO PASS SOMEONE AS IT ALMOST STALLS WITH THE GAS PEDAL ALL THE WAY TO THE FLOOR. IT HAS A WEIRD CHEMICAL SMELL WHEN USING HEATER. THIS SATURN OUTLOOK IS UNRELIABLE, VERY UNSAFE EVEN AFTER FIXING WHAT I HAD ALREADY FIXED. I HAVE AN INVOICE FOR THE REPAIRS FROM WATERTOWN FORD DEALERSHIP IN SOUTH DAKOTA. STERLING MOTORS WILL NOT HELP, SAID THEY COULD FIX BUT I HAVE TO PAY FOR PARTS AND WORK. HE SOLD ME A LEMON AND HE DOESN'T CARE ABOUT THE SAFETY OR WELLBEING OF ME, MY CHILDREN OR OTHERS ON THE ROAD. TALK TO THE LOAN PLACE AND ALL THEY SAID IS I HAVE AN AGREEMENT TO PAY REGARDLESS IF THE CAR WORKS OR NOT. I'M CURRENTLY 2 MONTHS BEHIND. I CAN'T AFFORD ANOTHER 700-3000 FIX WHILE PAYING 300 A MONTH FOR A SUV THAT IS UNSAFE TO DRIVE.

NHTSA ODI #11138849

100,000 miles · Feb 16, 2018

EngineService BrakesUnknown Or Other

Read full complaint

I HAVE 1 REAR BRAKE GOING OUT. THE WINDSHIELD LEAKS LIKE A SIEVE. I HAVE A LEAK SOMEWHERE NEAR MY RADIATOR. AND I'M TOLD THE CHIP IN MY TRANSMISSION IS GOING OUT ON ME. I HAVE MY DASH BOARD SCREECHING BLOODY MURDER AT ME AND MY EARS SWELL AND I LOOK LIKE I HAVE THE MUMPS. I HAVE TAKEN IT TO THE LOT I'M BUYING FROM AND THEY SHRUG AND SAY OH WELL. THIS IS UNACCEPTABLE. I RARELY IF EVER GO ON THE FREEWAY. I PARK OFF THE STREET. I USE THE ALARM SYSTEM RELIGIOUSLY. AND IT'S OVER HEATING WHERE THE BATTERY IS.

NHTSA ODI #11073263

Mileage unknown · Jun 28, 2017

Air BagsElectronic Stability Control (esc)Engine

MY SATURN 2008 ENGINE LIGHT IS FLASHING AND MY SUV IS RUNNING BAD, MY AIRBAG SERVICE LIGHT IS ON AND MY TRACTION LIGHT IS ALSO ON.

NHTSA ODI #11002054

116,000 miles · Dec 22, 2016

Electronic Stability Control (esc)EnginePower Train

Read full complaint

11/17/2016 REPLACED 2 TRANSMISSION IN TWO YEARS WITHIN A FEW WEEKS AFTER GETTING THE CAR BACK FROM REPAIR SHOP WIFE WAS DRIVING TO WORK ON 12/16/16 THE CAR STOP RUNNING ON THE EXPRESSWAY. DEALER STATES THROTTLE BODY WAS FREEZING DO TO CONDENSATION BUILDING UP WITHIN THROTTLE BODY STATED THIS IS COMMON IN THESE CARS. AGAIN GOT THE CAR BACK AFTER SPENDING A TON MORE MONEY GETTING IT FIXED HAD TO TAKE IT RIGHT BACK ENGINE LIGHT CAME BACK ON WITHIN 20MI OF DRIVING. DON'T WASTE YOU TIME BUYING THESE LEMON CARS. *TR

NHTSA ODI #10937079

84,415 miles · Dec 1, 2016

EngineFire

Read full complaint

TL* THE CONTACT OWNS A 2008 SATURN OUTLOOK. WHILE DRIVING APPROXIMATELY 45 MPH, THE LOW PRESSURE WARNING INDICATOR ILLUMINATED AND THE VEHICLE LOST ACCELERATION. THE CONTACT CONTINUED TO DRIVE AND HEARD A LOUD POP BEFORE THE VEHICLE STALLED. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND EXITED THE VEHICLE BEFORE FLAMES ERUPTED IN THE ENGINE COMPARTMENT. THE FIRE EXTINGUISHED ON ITS OWN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT OPERABLE, AND WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,415.

NHTSA ODI #10929429

136,000 miles · Nov 25, 2016

EnginePower TrainSteering

Read full complaint

DURING TRANSIT ON INTERSTATE THE ENGINE STOP PROVIDING POWER TO THE TRANSMISSION AND RPM DECREASED TO 1,000 WHILE DECELERATING THE VEHICLE FROM 70MPH TO 45MPH MAKING IT DIFFICULT TO CHANGE LANES TO PULL OFF THE ROAD ALMOST RESULTING IN A FATAL MOTOR VEHICLE ACCIDENT. AFTER ABOUT 30-45 SECONDS THE ENGIN REENGAGED. 30 MINUTES LATER THE VEHICLES SYSTEM ALERTED THAT THE TRANSMISSION IS OVERHEATING AND RECOMMENDED THAT WE PLACE THE VEHICLE IN NUTRAL. THIS IS THE SECOND TIME THIS HAS HAPPENED.

NHTSA ODI #10927848

Official recalls

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

14V118000 · Air Bags:side/window

Mar 17, 2014

General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

Consequence & remedy

Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.

Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12003 · Loss Of Headlamp Illumination

Opened Jun 4, 2012 · Closed Jul 24, 2014

Status: closed (inferred from source dates) · Exterior Lighting:headlights

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

Electrical System

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Engine And Engine Cooling:engine

Engine And Engine Cooling

Visibility:windshield Wiper/washer

Visibility:windshield Wiper/washer:switch/wiring