Exterior Lighting. Review the 154 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports10 fire reports7 injury reports

Electrical System complaints

115 reports

Clear category filter

80,000 miles · Apr 27, 2012

Electrical SystemEngine And Engine CoolingStructure

Read full complaint

1) CAR NO LONGER SHIFTS OUT OF FIRST GEAR (AUTOMATIC TRANSMISSION). 2) CAR CONTINUES TO RUN FOR UP TO 30 SECONDS WHEN THE KEY IS REMOVED. DEALER STATES THAT A WATER LEAK BEGINNING AT THE SUNROOF LEAKS WATER ONTO THE FUSE AREA IN THE ENGINE COMPARTMENT CAUSING FAILURES REQUIRING A FUSE BOX REPLACEMENT. THE VEHICLE HAS HAD LEAKS LEAVING WATER ON THE HEADLINER, FRONT SEATS, FRONT DRIVER AND FRONT PASSENGER FLOORS IN THE PAST ALL REPAIRED BY THE DEALER UNDER WARRANTY. DEALER CHARGES SO FAR ARE $500 TO REPAIR THE LEAK, $500 TO REPLACE THE FUSEBOX, AND STILL NOT SURE ANY OF THOSE REPAIRS HAVE RESOLVED THE TWO INITIAL ISSUES. *TR

NHTSA ODI #10456708

40,000 miles · Apr 26, 2012

Air BagsElectrical SystemStructure

Read full complaint

I NOTICED MY OUTLOOK LEAKING WATER 3 MOS. AFTER I BOUGHT IT. THE AIRBAGS ON PASSENGER SIDE STOPPED WORKING. THE CAR WOULD NOT SHUT OFF IN THE GARAGE. THE DEALER STATES ITS A LEAK THAT HAS ALLOWED WATER TO RUIN THE ELECTRONICS ALL OVER THE VEHICLE. THIS IS A PROBLEM ALL OVER THE INTERNET. NO ONE CAN FIX IT.THEY HAVE 7 TECH BULLETINS...STILL NO FIX. THE DEALERSHIP WANTS 1500.00 TO "START" LOOKING INTO THE PROBLEM. PLEASE HELP ME! I CAN'T DRIVE A MOLDY CAR WITH INTERMITTENT AIRBAGS AND POSSIBLE POWER STEERING MALFUNCTION WITH MY KIDS IN THE CAR! THIS WILL BANKRUPT ME. WHAT DO I DO?? NO ONE ONLINE HAS FOUND A SOLUTION...JUST 1000'S OF DOLLARS AND SCARY SITUATIONS ON THE ROAD (DEFROST BLOWERS BREAKING, LOSING POWER STEERING, ENGINE QUITTING, WATER DUMPING ON THEIR LAPS). PLEASE MAKE THEM RECALL THIS OR HELP US FIX IT! *TR

NHTSA ODI #10456522

52,020 miles · Apr 1, 2012

Electrical SystemStructure

Read full complaint

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

NHTSA ODI #10453710

25,644 miles · Feb 2, 2012

Air BagsElectrical SystemEngine And Engine Cooling

Read full complaint

WE BOUGHT THE CAR JAN 8 OF 2010 AND WAS STILL UNDER FULL WARRANTY- AFTER THE FIRST MONTH I BROUGHT INTO SATURN AND TOLD THEM OF ALL ISSUES. THEY SAID THEY GOT IT ALL FIXED IN JUNE OF 2010 BROUGHT IT IN AGAIN FOR BASICALLY SAME ISSUES AND THEY SAID THEY FIXED EVERYTHING AGAIN AND WERE ALSO CLOSING DOWN THAT DAY SO WERE HURRYING ME OUT THE DOOR. AFTER THAT HAD SAME ISSUES (ESPECIALLY STEERING WHEEL AND ENGINE PROBLEMS,OIL LEAKS, ALONG WITH ELECTRICAL PROBLEMS) AND WE WERE DIRECTED TO GO CHEVY SINCE SATURN WAS GONE. EXPRESSED TO THEM SAME ISSUES WITH STEERING WHEEL ETC. THEY ALSO FIXED A RECALL ON THE ELECTRICAL SYSTEM. AND FIXED POWER STEERING PUMP THAT WAS BROKE TWO MONTHS LATER HAD SAME ISSUES WITH STEERING AND ENGINE AND AIRBAG SENSOR AND BROUGHT IT AGAIN AND THEY ALSO FIXED ANOTHER RECALL, IN THE HEADLAMP. (WE HAVE ALL DOCUMENTS) NOW THE WHOLE TRANSMISSION IS OUT AND OIL LEAKS AGAIN SO SINCE IT STILL UNDER POWER TRAIN THEY ARE FIXING THEM BUT GM WILL NOT APPROVE THEM TO FIX THE STEERING COLUMN THAT NEEDS TO BE REPLACE NOR THE AIRBAG SENSOR ISSUE. WE HAVE CALLED THEM EVERYDAY AND SENT THEM OVER ALL OUR PAPERWORK THE LAST TWO YEARS SHOWING THAT THE STEERING COLUMN AND AIRBAG SENSOR HAVE BEEN AN ISSUE SINCE BEFORE OUR FULL WARRANTY WAS UP. I JUST WANT MY CAR TO BE SAFE AND FEEL LIKE I AM IN A DEATH TRAP AND STILL OWE A LOT OF MONEY ON IT. IT IS A TOTAL LEMON AND I AM STUCK WITH IT THESE ISSUES WERE FROM THE START WHEN THE CAR WAS STILL UNDER FULL WARRANTY. *KB

NHTSA ODI #10446305

Mileage unknown · Jan 4, 2012

Electrical SystemExterior Lighting

Read full complaint

THE DRIVER'S SIDE HEADLIGHT WILL WORK FOR AWHILE BUT THEN IT WILL APPEAR TO BE "BURNT OUT". THE SAME THING HAS HAPPENED TO THE PASSENGER SIDE HEADLIGHT SEVERAL TIMES. THE LIGHTS WILL START WORKING AGAIN (AT LEAST TEMPORARILY) WHEN I SWITCH FROM THE "AUTO" LIGHT SETTING TO "MANUAL" AND BACK AGAIN. I HAVE READ ON SEVERAL DIFFERENT WEBSITES THAT THIS IS A COMMON PROBLEM WITH THE CAUSE BEING THE WIRING HARNESS FOR THE LIGHTS. THIS APPEARS TO BE A DEFECT IN THE PARTS/MATERIALS USED AND SHOULD HAVE A RECALL ON IT. I CAN'T AFFORD TO PAY WHAT THE DEALERSHIP IS ASKING TO REPAIR IT, SO FOR NOW I CAN'T DO ANY NIGHT TIME DRIVING WITHOUT GETTING A TRAFFIC CITATION/TICKET. *TR

NHTSA ODI #10442382

60,700 miles · Jan 2, 2012

Electrical System

MY KEY KEEPS GETTING STUCK IN THE IGNITION, MY HUSBAND HAS TO DISCONNECT THE BATTERY TO GET IT OUT, I HAVE TOLD GM ABOUT THE PROBLEM THEY SAY THAT THEY ARE NOT AWARE OF THE PROBLEM BUT WHEN I GO ONLINE I SEE HUNDREDS OF POSTS ABOUT THEIR VEHICLES HAVING THE SAME PROBLEM. I'M SURE THAT THEY DO KNOW ABOUT IT. THE VEHICLE IS NOT IN…

Read full complaint

NHTSA ODI #10442070

52,000 miles · Nov 18, 2011

Electrical SystemExterior Lighting

DRIVER SIDE HEADLIGHT WORKS INTERMITTENTLY. GM DEALER INSTRUCTED ME THAT THE WIRING HARNESS WAS BROKEN AT THE PLUG WHERE IT PLUGS INTO THE LIGHT SOCKET. IT SEEMS THAT THERE ARE OTHER OWNERS EXPERIENCING THE SAME PROBLEM AND DO NOT ABOUT THIS SIGHT TO FILE THE COMPLAINT. I HAVE READ ON OTHER FORUMS AND KNOW THIS FOR SURE AND I…

Read full complaint

NHTSA ODI #10436420

30,000 miles · Nov 9, 2011

Electrical SystemExterior Lighting

PASSENGER SIDE LOW BEAM HEADLAMP SOCKET/WIRING HARNESS MELTED. BOTH (DRIVER SIDE / PASSENGER SIDE) LOW BEAM HEADLAMP SOCKET/WIRING HARNESS HAVE MELTED IN THE PAST TWO YEARS. LIGHT BULB WAS OEM BULB AND WAS NOT BURNT OUT. NSTB NEEDS TO ISSUE RECALL AND GET GM TO REPLACE WITH MORE SUITABLE SOCKET/WIRING HARNESS. *TR

NHTSA ODI #10435025

60,000 miles · Nov 9, 2011

Electrical SystemExterior Lighting

DRIVERSIDE LOW BEAM HEADLAMP SOCKET/WIRING HARNESS MELTED. THIS IS THE 2ND TIME THIS HAS OCCURRED (PASSENGER SIDE LOW BEAM HEADLAMP SOCKET/WIRING HARNESS WAS REPLACED AT SATURN DEALERSHIP IN 2009. *TR

NHTSA ODI #10435024

70,040 miles · Nov 7, 2011

Electrical SystemExterior Lighting

PASSENGER SIDE HEADLAMP IS BURNT OUT AND THE HOUSING IS MELTED. I HAVE READ SEVERAL COMPLAINTS OF THE SAME PROBLEM ONLINE AND FEEL THIS IS A SAFETY ISSUE WITH THIS CAR. AN ELECTRICAL FIRE IS A POSSIBILITY! *TR

NHTSA ODI #10434801

Official recalls

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

07V062000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Feb 21, 2007

ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.

Remedy: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12003 · Loss Of Headlamp Illumination

Opened Jun 4, 2012 · Closed Jul 24, 2014

Status: closed (inferred from source dates) · Exterior Lighting:headlights

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

Electrical System

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Engine And Engine Cooling:engine

Engine And Engine Cooling

Visibility:windshield Wiper/washer

Visibility:windshield Wiper/washer:switch/wiring