NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
382 reports86,000 miles · Feb 9, 2009
Unknown Or Other
WHILE DRIVING ON THE FREEWAY WITH MY 5 YEAR OLD DAUGHTER DURING THE MORNING COMMUTE, TRANSITIONING FROM ONE HWY 24 TO I-80 IN THE EMERYVILLLE / BERKELEY AREA IN CALIFORNIA, OUR SATURN 2000 LW WAGON SUDDENLY LOST POWER. I WAS ABLE TO PULL OVER TO THE SHOULDER BUT COULD NOT RESTART THE CAR. I WAS TOWED TO MY MECHANIC, WHO DIAGNO…
Read full complaint
WHILE DRIVING ON THE FREEWAY WITH MY 5 YEAR OLD DAUGHTER DURING THE MORNING COMMUTE, TRANSITIONING FROM ONE HWY 24 TO I-80 IN THE EMERYVILLLE / BERKELEY AREA IN CALIFORNIA, OUR SATURN 2000 LW WAGON SUDDENLY LOST POWER. I WAS ABLE TO PULL OVER TO THE SHOULDER BUT COULD NOT RESTART THE CAR. I WAS TOWED TO MY MECHANIC, WHO DIAGNOSED THE PROBLEM AS A BROKEN TIMING CHAIN AND TOLD ME THE ENGINE WOULD HAVE TO BE REPLACED. I UNDERSTAND THIS IS A FREQUENT PROBLEM WITH THIS ENGINE AND THAT OTHER YEARS OF THIS MODEL HAVE BEEN RECALLED FOR THIS REASON. *TR
NHTSA ODI #10258004
78,000 miles · Feb 5, 2009
Engine And Engine Cooling
2000 SATURN L-SERIES TIMMING CHAIN BROKE ENGINE NO GOOD. *TR
NHTSA ODI #10257595
89,000 miles · Jan 23, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 SATURN L SERIES. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND WAS TOWED TO A LOCAL REPAIR SHOP. THE MECHANIC STATED THAT THE TIMING CHAIN LED TO ENGINE FAILURE. THE VEHICLE WAS REPAIRED AT THE COST OF $2,300. THE FAILURE AND CURRENT MILEAGES WERE 89,000.
NHTSA ODI #10256134
71,000 miles · Jan 8, 2009
Engine And Engine Cooling
I WAS PICKING MY KIDS UP FROM THE BABYSITTERS WHEN I HEARD A TICKING NOISE. LET ME REMIND YOU THAT I HADN'T ANY ENGINE PROBLEMS BEFORE THIS DAY. ANYWAY, I HEARD THE TICKING NOISE AS I WAS PULLING UP TO THE SITTERS HOUSE AND CUT MY CAR OFF. RESTARTED THE CAR AND THE NOISE WAS LOUDER. TOOK MY CAR TO THE SHOP AND THEY TOLD ME THAT …
Read full complaint
I WAS PICKING MY KIDS UP FROM THE BABYSITTERS WHEN I HEARD A TICKING NOISE. LET ME REMIND YOU THAT I HADN'T ANY ENGINE PROBLEMS BEFORE THIS DAY. ANYWAY, I HEARD THE TICKING NOISE AS I WAS PULLING UP TO THE SITTERS HOUSE AND CUT MY CAR OFF. RESTARTED THE CAR AND THE NOISE WAS LOUDER. TOOK MY CAR TO THE SHOP AND THEY TOLD ME THAT MY TIMING CHAIN WAS BROKEN AND THAT MY ENGINE HAD TO BE REPLACED. I DON'T UNDERSTAND WHY THIS WAS NOT COVERED UNDER SATURN BECAUSE MY CAR ONLY HAS 70K MILES. IT'S A 2000 SATURN LS2 AND IT WAS RUNNING FINE UP UNTIL THIS DATE. THERE WAS NO SIGN OF THIS PROBLEM BEFORE IT HAPPENED AND I JUST DON'T UNDERSTAND WHY I SHOULD HAVE TO PAY $3600 OUT MY POCKET BUT SATURN WILL TAKE NO RESPONSIBILITY FOR THIS MAJOR PROBLEM. CAN YOU HELP ME OUT? WHAT IF THIS WOULD HAVE HAPPENED WHILE I WAS ON THE HIGHWAY WITH MY KIDS AND AN ACCIDENT HAPPENED? *TR
NHTSA ODI #10254324
33,000 miles · Dec 30, 2008
Electrical System
WHILE CAR WAS STILL UNDER GM WARRANTY, VEHICLE IGNITION SWITCH WOULD GET STUCK SUCH THAT THE CAR WOULD NOT START. THIS HAPPENED SEVERAL TIMES INTERMITTENTLY BUT EACH TIME WOULD EVENTUALLY FREE UP. TOOK CAR TO DEALER WHERE PURCHASED AND PROBLEM WAS NOT DUPLICATED AT THAT TIME. I BELIEVE I ALSO TOOK TO SATURN DEALER BUT THEY ALS…
Read full complaint
WHILE CAR WAS STILL UNDER GM WARRANTY, VEHICLE IGNITION SWITCH WOULD GET STUCK SUCH THAT THE CAR WOULD NOT START. THIS HAPPENED SEVERAL TIMES INTERMITTENTLY BUT EACH TIME WOULD EVENTUALLY FREE UP. TOOK CAR TO DEALER WHERE PURCHASED AND PROBLEM WAS NOT DUPLICATED AT THAT TIME. I BELIEVE I ALSO TOOK TO SATURN DEALER BUT THEY ALSO COULD NOT REPLICATE. THIS CONTINUED TO HAPPENED PERIODICALLY AND CAR EVENTUALLY PASSED OUT OF WARRANTY. RECENTLY, THE PROBLEM HAPPENED AGAIN BUT IT WILL NOT START AT ALL. HAD TO TOW IT TO THE CLOSEST SHOP AND REPAIR THE CYLINDER. CALLED SATURN AND THEY ARE UNWILLING TO ASSIST WITH THE REPAIR AT THIS TIME. THEY WILL NOT CONSIDER ANY ASSISTANCE UNLESS I TOW THE CAR TO THE DEALER (AROUND $100) AND PAY THERE DIAGNOSTIC FEES BUT, AGAIN, OFFER NO PROMISE THAT THEY WILL HELP IN ANY WAY EVEN IF THEY CONFIRM THE PROBLEM. *TR
NHTSA ODI #10253237
79,000 miles · Dec 14, 2008
Exterior Lighting
THE 2000 SATURN L-SERIES HAS AN EXISTING RECALL FOR HAZARD WARNING SWITCH ASSEMBLY REPLACEMENT (SATURN REFERS TO IT AS #00-C-03, JAN. 4, 2005); HOWEVER, MY VEHICLE IS OUTSIDE THE VIN SERIES FOR THAT RECALL. NEVERTHELESS, MY VEHICLE EXHIBITED THE SYMPTOMS DESCRIBED IN THAT RECALL (TURN SIGNAL INTERMITTENTLY INOPERATIVE; HAZARD W…
Read full complaint
THE 2000 SATURN L-SERIES HAS AN EXISTING RECALL FOR HAZARD WARNING SWITCH ASSEMBLY REPLACEMENT (SATURN REFERS TO IT AS #00-C-03, JAN. 4, 2005); HOWEVER, MY VEHICLE IS OUTSIDE THE VIN SERIES FOR THAT RECALL. NEVERTHELESS, MY VEHICLE EXHIBITED THE SYMPTOMS DESCRIBED IN THAT RECALL (TURN SIGNAL INTERMITTENTLY INOPERATIVE; HAZARD WARNING SWITCH SOMETIMES MADE A LOUD "BUZZING" SOUND, ESPECIALLY IN VERY COLD WEATHER); I CONTACTED SATURN; HOWEVER, SINCE VEHICLE WAS OUTSIDE RECALL VIN RANGE, THEY WOULD NOT ADDRESS THE PROBLEM AS A RECALL ISSUE (I WOULD HAVE HAD TO BRING THE VEHICLE IN AND PAY FOR THE SERVICE MYSELF). INSTEAD, I ACQUIRED AND INSTALLED THE REPLACEMENT HAZARD WARNING SWITCH FROM A SATURN DEALER AND INSTALLED IT ACCORDING TO THE RECALL NOTICE INSTRUCTIONS. SINCE THAT TIME, THE PROBLEM HAS NOT RECURRED. *TR
NHTSA ODI #10251733
159,263 miles · Dec 2, 2008
Engine And Engine Cooling
MY MECHANIC GAVE ME INFORMATION ABOUT A RECALL THAT IS BEING DONE ON 2000 AND UP SATURNS ON THE TIMING CHAIN, HOWEVER SATURN HAS YET TO ACCEPT THAT AS A RECALL. I SPOKE WITH SOMEONE FROM NHTSA AND THEY DIRECTED ME TO SATURN WHO AGAIN DIRECTED ME BACK HERE TO FILE A COMPLAINT. I WOULD LIKE TO KNOW IF THIS IS GOING TO BE RECALLED…
Read full complaint
MY MECHANIC GAVE ME INFORMATION ABOUT A RECALL THAT IS BEING DONE ON 2000 AND UP SATURNS ON THE TIMING CHAIN, HOWEVER SATURN HAS YET TO ACCEPT THAT AS A RECALL. I SPOKE WITH SOMEONE FROM NHTSA AND THEY DIRECTED ME TO SATURN WHO AGAIN DIRECTED ME BACK HERE TO FILE A COMPLAINT. I WOULD LIKE TO KNOW IF THIS IS GOING TO BE RECALLED. *TR
NHTSA ODI #10250537
149,000 miles · Nov 9, 2008
Engine And Engine Cooling
MY SON WAS DRIVING MY 2000 SATURN LS2 AT 30 MPH, WHEN THE CAR SUDDENLY DIED AND WOULD NOT START. UPON FURTHER INVESTIGATION, THE WAS NO COMPRESSION WHEN TURNING OVER THE VEHICLE. MY MECHANIC HAS TOLD ME THAT THE TENSIONER ARM HOLDING THE TIMING BELT SHATTERED. THE TIMING BELT ON THIS VEHICLE HAD BEEN REPLACED BY THE DEALERSHI…
Read full complaint
MY SON WAS DRIVING MY 2000 SATURN LS2 AT 30 MPH, WHEN THE CAR SUDDENLY DIED AND WOULD NOT START. UPON FURTHER INVESTIGATION, THE WAS NO COMPRESSION WHEN TURNING OVER THE VEHICLE. MY MECHANIC HAS TOLD ME THAT THE TENSIONER ARM HOLDING THE TIMING BELT SHATTERED. THE TIMING BELT ON THIS VEHICLE HAD BEEN REPLACED BY THE DEALERSHIP 18 MONTHS PRIOR. LUCKILY, MY SON WAS ON A LIGHTLY TRAVELED RESIDENTIAL STREET AT THE TIME OF THE MALFUNCTION AND WAS NOT INJURED NOR WERE HIS PASSENGERS. *TR
NHTSA ODI #10248210
96,275 miles · Oct 31, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 SATURN L-SERIES WAGON. THE CONTACT STATED THAT THE TIMING CHAIN SLIPPED ON THE VEHICLE. THE RECALL FOR THE 2001 SATURN L-SERIES DESCRIBED THE IDENTICAL FAILURE SHE WAS EXPERIENCING. THE DEALER STATED THAT THE REPAIR WOULD COST $900; HOWEVER, SATURN OFFERED TO TAKE $100 OFF THE COST BECAUSE THE FAILU…
Read full complaint
TL*THE CONTACT OWNS A 2000 SATURN L-SERIES WAGON. THE CONTACT STATED THAT THE TIMING CHAIN SLIPPED ON THE VEHICLE. THE RECALL FOR THE 2001 SATURN L-SERIES DESCRIBED THE IDENTICAL FAILURE SHE WAS EXPERIENCING. THE DEALER STATED THAT THE REPAIR WOULD COST $900; HOWEVER, SATURN OFFERED TO TAKE $100 OFF THE COST BECAUSE THE FAILURES WERE RECOGNIZED IN THE FOLLOWING YEAR OF THE SATURN L-SERIES. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 90,000. UPDATED 11/26/08. *LJ UPDATED 12/01/08. *JB
NHTSA ODI #10247352
Mileage unknown · Oct 27, 2008
Fuel System, Other
REPEATED FAILURE OF THE STARTING OF MY CAR, 2000 SATURN LS2. PASSLOCK SECURITY SYSTEM IS THE PROBLEM. FOR NO REASON AT ALL, THE SECURITY FEATURE TRIGGERS AND DE-ACTIVATES THE FUEL PUMP FOR 10 MINUTES. HAS BEEN HAPPENING FOR THE PAST TWO YEARS, MULTIPLE TIMES A MONTH. MY CAR HAS BEEN "DEAD" IN THE DRIVEWAY NOW FOR TWO DAYS AS…
Read full complaint
REPEATED FAILURE OF THE STARTING OF MY CAR, 2000 SATURN LS2. PASSLOCK SECURITY SYSTEM IS THE PROBLEM. FOR NO REASON AT ALL, THE SECURITY FEATURE TRIGGERS AND DE-ACTIVATES THE FUEL PUMP FOR 10 MINUTES. HAS BEEN HAPPENING FOR THE PAST TWO YEARS, MULTIPLE TIMES A MONTH. MY CAR HAS BEEN "DEAD" IN THE DRIVEWAY NOW FOR TWO DAYS AS THE SECURITY FEATURE WILL NOT DE-ACTIVATE. ONLY WAY TO FIX IS FOR A DEALERSHIP TO REPAIR, BUT NOT A GUARANTEED FIX. COST ANYWHERE FROM $300 TO $500 TO FIX. NUMEROUS BLOG SITES CONTAIN SAME COMPLAINT FROM LOTS OF GM OWNERS. IF ANYONE IS PUT INTO AN EMERGENCY SITUATION AND THE PASSLOCK SECURITY FEATURE FAILS, THAT PERSON IS STUCK FOR 10 MINUTES OR MORE. THERE IS NO FIX TO BE FOUND. GM NEEDS TO RECALL AND FIX THE PROBLEM! VISIT THIS FORUM SITE FOR NUMEROUS COMPLAINTS ABOUT THE SAME THING I'M MENTIONING ABOVE: HTTP://WWW.TOPIX.COM/FORUM/AUTOS/CHEVROLET-IMPALA/T30R7CEJ84KTJEL1M. *TR
NHTSA ODI #10246843
Official recalls
6Jun 2, 2005
ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.
Consequence & remedy
Consequence: THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP) OR TAIL LAMPS. A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL TWO NEW TAIL LAMP REINFORCING SOCKET ADAPTERS AND SOCKETS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876.
Jun 23, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L L4 (L61) ENGINES, A FAILURE OF THE IGNITION CONTROL MODULE MAY CAUSE DETERIORATION IN IDLE QUALITY, REDUCTION IN OVERALL ENGINE POWER, AND THE VEHICLE MAY BE HARD TO START. CONTINUED OPERATION OF THE VEHICLE AFTER SUCH AN IGNITION MODULE FAILURE WILL RESULT IN THE "SERVICE ENGINE SOON" LIGHT FLASHING, AND MAY LEAD TO SECONDARY FAILURES OF THE CATALYTIC CONVERTER, OXYGEN SENSOR, AND EXHAUST RESONATOR.
Consequence & remedy
Consequence: FAILURE OF THE RESONATOR WILL CAUSE INCREASED EXHAUST NOISE. PROLONGED OPERATION OF THE VEHICLE FOLLOWING A RESONATOR FAILURE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL (1) REPLACE THE IGNITION CONTROL MODULE, (2) REPLACE THE IGNITION CONTROL MODULE AND SPARK PLUGS, OR (3) REPLACE THE IGNITION CONTROL MODULE, SPARK PLUGS, AND UPDATE THE POWERTRAIN CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN ON AUGUST 4, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000, PROMPT 3.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Dec 2, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. FUEL TANK ASSEMBLIES IN THESE VEHICLES HAVE AN OVER PRESSURE RELIEF (OPR) VALVE THAT CAN BECOME STUCK OPEN IN A FRONTAL COLLISION. IF THE VEHICLE ROLLS OVER, FUEL SPILLAGE COULD OCCUR.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL PERMANENTLY SEAL THE OUTLET PORT OF THE OPR VALVE.
Jul 26, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES MAY HAVE BEEN PRODUCED WITH AN INOPERATIVE VALVE WITHIN THE FUEL TANK ASSEMBLY.
Consequence & remedy
Consequence: IF A VEHICLE WITH AN INOPERATIVE VALVE WERE INVOLVED IN A ROLLOVER, FUEL SPILLAGE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE VEHICLES TO ENSURE THAT THE FUEL TANK ASSEMBLY VALVE IS OPERATING AS INTENDED. THEY WILL REPLACE THE FUEL TANK ASSEMBLY IF NECESSARY.
Jul 26, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." BECAUSE OF A PROBLEM IN THE HAZARD WARNING SWITCH ASSEMBLY, THE TURN SIGNAL LAMPS MAY NOT WORK OR MAY WORK INTERMITTENTLY WHEN THE DRIVER USES THE TURN SIGNAL LEVER OR HAZARD WARNING SWITCH. IF THE VEHICLE TURN SIGNAL INDICATORS ARE NOT FLASHING, THEN THE TURN SIGNAL LAMPS MAY NOT BE FLASHING.
Consequence & remedy
Consequence: OTHER DRIVERS MAY NOT BE ALERTED THAT THE VEHICLE IS TURNING AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE08061 · Timing Chain Breaks, Engine Stall
Opened Oct 16, 2008 · Closed Apr 8, 2009
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON MAY 22, 2008, THEOFFICE OF DEFECTS INVESTIGATION (ODI) WAS PETITIONED BY THE NORTH CAROLINA CONSUMERS COUNCIL (NCCC) TO BROADEN THE SCOPE OF SAFETY RECALL 07V-519, WHICH WAS CONDUCTED BY GENERAL MOTORS CORPORATION (GM) FOR MODEL YEAR (MY) 2001 SATURN L-SERIES VEHICLES EQUIPPED WITH THE L61 2.2L ENGINE AND BUILT DURING A 4-MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001 (DP08-002). ON OCTOBER 16, 2008, ODI GRANTED DP08-002 AND OPENED PE08-061 TO INVESTIGATE TIMING CHAIN FAILURES RESULTING IN ENGINE STALL WHILE DRIVING (SWD) IN THE SATURN L-SERIES VEHICLES EQUIPPED WITH L61 ENGINES AND THAT USED THE SAME DESIGN TIMING CHAIN AND TIMING CHAIN LUBRICATION SYSTEM AS THE RECALLED VEHICLES.A REDESIGNED TIMING CHAIN AND LUBRICATION SYSTEM WERE IMPLEMENTED LATE IN MY 2002 PRODUCTION (MAY 1, 2002).HENCE, THE SUBJECT VEHICLES FOR THIS INVESTIGATION ARE ALL MY 2000 THROUGH 2002 SATURN L-SERIES VEHICLES EQUIPPED WITH 2.2L L61 ENGINES AND BUILT PRIOR TO MAY 2002 THAT WERE NOT INCLUDED IN RECALL 07V-519. IN THIS INVESTIGATION, ODI ANALYZED UPDATED COMPLAINT AND WARRANTY CLAIMS DATA FOR TIMING CHAIN FAILURES RESULTING IN INCIDENTS OF ENGINE STALL WHILE DRIVING, WHICH COMPRISE SLIGHTLY OVER HALF OF ALL TIMING CHAIN FAILURES OCCURRING IN THE SUBJECT VEHICLE POPULATION.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA SHOWS THAT VEHICLES PRODUCED WITH THE SUBJECT TIMING CHAIN AND LUBRICATION SYSTEM EXPERIENCED ELEVATED FAILURE RATES WHEN COMPARED WITH THE MY 2002 THROUGH 2003 VEHICLES USING THE REVISED COMPONENTS.HOWEVER, THE ANALYSIS ALSO SHOWED THAT THE MY 2001 SATURN L-SERIES VEHICLES RECALLED IN 07V-518 EXPERIENCED A SIGNIFICANTLY HIGHER RATE OF TIMING CHAIN FAILURES THAN THE SUBJECT VEHICLES.THE COMPLAINT RATE FOR TIMING CHAIN FAILURES RESULTING IN SWD WAS APPROXIMATELY 5 TIMES HIGHER FOR THE RECALLED VEHICLES,19.2 INCIDENTS PER THOUSAND VEHICLES (IPTV), THAN FOR THE SUBJECT VEHICLES, 3.7 IPTV.THE WARRANTY CLAIMS RATE FOR CHAIN FAILURES RESULTING IN SWD WAS OVER 3 TIMES HIGHER FOR THE RECALLED VEHICLES, 2.4 PERCENT, THAN FOR THE SUBJECT VEHICLES, 0.7 PERCENT.THE COMPLAINT AND WARRANTY RATES FOR THE SUBJECT VEHICLES WERE SIMILAR TO RATES RECORDED IN OTHER RECENTLY CLOSED INVESTIGATIONS FOR CONDITIONS THAT COULD RESULT IN SWD WITH NO ENGINE RE-START, EA07-015 AND EA07-018.ANALYSIS OF ALL COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS FOUND NO ALLEGATIONS OF CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AFTER APPROXIMATELY 7 TO 9 YEARS IN SERVICE. ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM TIMING CHAIN FAILURES IN THE SUBJECT VEHICLES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND ALMOST ALWAYS RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE SEVERITY OF STALLING INCIDENTS.HOWEVER, ANALYSIS OF SWD FAILURE RATES IN THE SUBJECT VEHICLES SHOW THAT THEY HAVE OCCURRED AT MUCH LOWER RATES THAN WERE OBSERVED IN THE RECALLED POPULATION.IN ADDITION, THE SWD COMPLAINT AND WARRANTY RATES FOR THE SUBJECT VEHICLES ARE SIMILAR TO RATES OBSERVED IN PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES THAT WERE CLOSED WITH NO ACTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
DP08002 · Timing Chain FAILURE-STALL
Opened Jun 18, 2008 · Closed Oct 16, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JUNE 6, 2006, ODI OPENED AN INVESTIGATION OF TIMING CHAIN FAILURE RESULTING IN ENGINE STALL WHILE DRIVING WITH NO RESTART IN APPROXIMATELY 20,514 MODEL YEAR (MY) 2001 SATURN L-SERIES VEHICLES EQUIPPED WITH 2.2L ENGINES (L61) BUILT FROM NOVEMBER 2000 THROUGH FEBRUARY 2001 (EA06-009).THE VEHICLES BUILT DURING THOSE MONTHS EXHIBITED HIGHER FAILURE RATES THAN SIMILARLY EQUIPPED VEHICLES BUILT BEFORE AND AFTER.GM INTRODUCED A NEW TIMING CHAIN DESIGN IN PRODUCTION IN MAY 2002.ODI CLOSED ITS INVESTIGATION AFTER GM INITIATED A SAFETY RECALL ON NOVEMBER 7, 2007 (RECALL 07V-519). ON MAY 22, 2008, THE NORTH CAROLINA CONSUMERS COUNCIL (NCCC) SUBMITTED A DEFECT PETITION TO ODI REQUESTING THE EXPANSION OF RECALL 07V-519 TO INCLUDE ALL MY 1999 THROUGH 2003 SATURN L-SERIES VEHICLES WITH 2.2L ENGINES USING THE SAME TIMING CHAIN DESIGN AS THE RECALLED POPULATION.THE PETITION STATES THAT THE NCCC CONTINUES TO RECEIVE COMPLAINTS FROM CONSUMERS THAT HAVE HAD A TIMING CHAIN FAIL IN VEHICLES BUILT OUTSIDE THE PRODUCTION RANGE COVERED BY THE RECALL.THE PETITION ALSO NOTES THAT ODI HAS CONTINUED TO RECEIVE COMPLAINTS.SINCE THE CLOSING OF EA06-009 ODI HAS RECEIVED 80 NEW COMPLAINTS FROM CONSUMERS WHO HAD A TIMING CHAIN FAIL IN A MY 2000 THROUGH 2002 SATURN L-SERIES WITH THE 2.2L ENGINE THAT WERE NOT COVERED BY RECALL 07V-519 AND WERE BUILT PRIOR TO THE TIMING BELT CHANGE IN MAY 2002.THE COMPLAINTS DESCRIBE THE SAME FAILURE MODE AS THE RECALLED POPULATION WHERE THE TIMING CHAIN CAN BREAK SUDDENLY AND WITHOUT WARNING, RESULTING IN ENGINE DAMAGE AND LOSS OF MOTIVE POWER.THE DEFECT PETITION HAS BEEN GRANTED. A PRELIMINARY EVALUATION (PE08-061) HAS BEEN OPENED.
PE06006 · Timing Chain Failure
Opened Jan 24, 2006 · Closed Jun 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).
DP05008 · Timing Chain Failure
Opened Dec 20, 2005 · Closed Feb 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ANALYSIS UNDERTAKEN IN RESPONSE TO THE PETITION IDENTIFIED 26 COMPLAINTS ALLEGING TIMING CHAIN FAILURES IN MY 2000-2003 SATURN L-SERIES VEHICLE EQUIPPED WITH THE 2.2L L4 ENGINE.MOST COMPLAINTS OF TIMING CHAIN FAILURE REPORTEDLY RESULTED IN A SUDDEN LOSS OF ENGINE POWER AND STALLING.ODI ALSO NOTED THAT CERTAIN MY 2002-2003 SATURN VUE AND MY 2003 SATURN ION MODEL VEHICLES WITH THE 2.2L ENGINE VEHICLESCOVERED BY A TECHNICAL SERVICE BULLETIN (03-06-01-017) THAT ADDRESSED TIMING CHAIN DESIGN AND SERVICE PROCEDURE CHANGES, EXHIBITED NO COMPLAINTS OF TIMING CHAIN FAILURE.ODI WILL GRANT THE PETITION AND OPEN A PRELIMINARY EVALUATION TO ASSESS THE FREQUENCY, TREND, SCOPE AND SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.REFER TO PE06-006.
PE05010 · Inoperative Tail Lamps
Opened Feb 15, 2005 · Closed Jun 3, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
GENERAL MOTORS HAS DECIDED THAT A SAFETY RELATED DEFECT EXISTS ON CERTAIN MODEL SATURN SEDANS AND WAGONS.THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE OR TAIL LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP).GM WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF SATURN VEHICLES TO INSTALL A REINFORCING SOCKET ADAPTER (AND CORRESPONDING NW SOCKET) TO THE BACK OF THE EXISTING LAMP ASSEMBLY.GENERAL MOTORS WILL RECALL 291,652 MY 2000-2002 SATURN LS SEDANS AND MY 2000-2004 SATURN LW WAGONS.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V-245.
Additional source detail variants (4)
Electrical System
GENERAL MOTORS HAS DECIDED THAT A SAFETY RELATED DEFECT EXISTS ON CERTAIN MODEL SATURN SEDANS AND WAGONS.THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE OR TAIL LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP).GM WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF SATURN VEHICLES TO INSTALL A REINFORCING SOCKET ADAPTER (AND CORRESPONDING NW SOCKET) TO THE BACK OF THE EXISTING LAMP ASSEMBLY.GENERAL MOTORS WILL RECALL 291,652 MY 2000-2002 SATURN LS SEDANS AND MY 2000-2004 SATURN LW WAGONS.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V-245.
Exterior Lighting:brake Lights
GENERAL MOTORS HAS DECIDED THAT A SAFETY RELATED DEFECT EXISTS ON CERTAIN MODEL SATURN SEDANS AND WAGONS.THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE OR TAIL LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP).GM WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF SATURN VEHICLES TO INSTALL A REINFORCING SOCKET ADAPTER (AND CORRESPONDING NW SOCKET) TO THE BACK OF THE EXISTING LAMP ASSEMBLY.GENERAL MOTORS WILL RECALL 291,652 MY 2000-2002 SATURN LS SEDANS AND MY 2000-2004 SATURN LW WAGONS.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V-245.
Exterior Lighting
GENERAL MOTORS HAS DECIDED THAT A SAFETY RELATED DEFECT EXISTS ON CERTAIN MODEL SATURN SEDANS AND WAGONS.THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE OR TAIL LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP).GM WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF SATURN VEHICLES TO INSTALL A REINFORCING SOCKET ADAPTER (AND CORRESPONDING NW SOCKET) TO THE BACK OF THE EXISTING LAMP ASSEMBLY.GENERAL MOTORS WILL RECALL 291,652 MY 2000-2002 SATURN LS SEDANS AND MY 2000-2004 SATURN LW WAGONS.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V-245.
Exterior Lighting:tail Lights
GENERAL MOTORS HAS DECIDED THAT A SAFETY RELATED DEFECT EXISTS ON CERTAIN MODEL SATURN SEDANS AND WAGONS.THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE OR TAIL LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP).GM WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF SATURN VEHICLES TO INSTALL A REINFORCING SOCKET ADAPTER (AND CORRESPONDING NW SOCKET) TO THE BACK OF THE EXISTING LAMP ASSEMBLY.GENERAL MOTORS WILL RECALL 291,652 MY 2000-2002 SATURN LS SEDANS AND MY 2000-2004 SATURN LW WAGONS.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V-245.
DP05001 · Inoperative Tail Lamps
Opened Feb 10, 2005 · Closed Feb 22, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).
Additional source detail variants (5)
Electrical System
ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).
Exterior Lighting:brake Lights
ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).
Exterior Lighting:brake Lights:switch
ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).
Exterior Lighting:tail Lights
ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).
Exterior Lighting:tail Lights:switch
ON JANUARY 25, 2005, A SAFETY DEFECT PETITION WAS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), REQUESTING AN INVESTIGATION OF INOPERATIVE TAIL LAMPS ON MY 2000-2002 SATURN L-SERIES VEHICLES.THE PETITIONER ALLEGES A DEFECT IN THE DESIGN AND ASSEMBLY OF THE TAIL LAMP ASSEMBLY CIRCUIT BOARD AND LIGHT SOCKET CONTACT.THE PETITIONER IDENTIFIED 47 VEHICLE OWNER QUESTIONNAIRE'S (VOQ'S) ASSOCIATED WITH THE ALLEGED DEFECT, AND ODI CONCURS THAT 40 OF THOSE VOQ'S SATISFY THE SCOPE OF THIS INVESTIGATION.ODI HAS FOUND AN ADDITIONAL 10 VOQ'S RELATED TO THE ALLEGATION.ODI HAS GRANTED THE PETITION AND OPENED A PRELIMINARY EVALUATION (PE05-010).
PE99064 · POST-COLLISION Fuel System Integrity
Opened Oct 27, 1999 · Closed Feb 11, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGE THAT THE FUEL TANK OVER-PRESSURE RELIEF (OPR) VALVE MAY LEAK FUEL IN EXCESS OF FMVSS 301 ALLOWANCES IN A CRASH
Illustration