Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports4 fire reports3 injury reports

Air Bags complaints

3 reports

Clear category filter

45,000 miles · Feb 28, 2014

Air BagsElectrical SystemCrash

Read full complaint

IN FEBRUARY, 2007 AND IN APRIL OF 2008 I WAS INVOLVED SEPARATE FRONT END CRASHES WHILE DRIVING MY 2003 SATURN L300. IN BOTH INSTANCES SEATBELT RESTRAINTS WERE USED (AS ALWAYS), BUT THE AIR-BAGS FAILED TO DEPLOY. FORTUNATELY, NO ONE WAS INJURED. IN BOTH INSTANCES, I BELIEVED THAT I WAS FORTUNATE THE AIR-BAGS DIDN'T OPEN BECAUSE OF THE EXPENSE INVOLVED REPAIRING A DEPLOYED AIR-BAG. IN LATE FEBRUARY-2014, GENERAL MOTORS ANNOUNCED A LARGE RECALL OF NUMEROUS VEHICLES (SATURN ION, SATURN VUE, CHEVY COBALT AND OTHER VEHICLES WHICH ARE SIMILAR TO MY 2003 SATURN L300) SITTING A DEFECTIVE IGNITION SWITCH WHICH DISABLES THE ACTIVATION OF THE VEHICLES AIRBAGS WHEN IT IS INVOLVED AN ACCIDENT! 13 DEATHS HAVE BEEN ATTRIBUTED TO THE DEFECTIVE SWITCH, THUSFAR. ALTHOUGH THE 2003 SATURN L300 IS NOT INCLUDED IN THE RECALL, I BELIEVE IT SHOULD BE INCLUDED BECAUSE OF THE AIR-BAG ISSUE THAT I EXPERIENCED TWICE WITH MY L300. IN ADDITION, THERE IS A STARTING PROBLEM WITH THE IGNITION SWITCH, WHICH HAS ARISEN SINCE I'VE OWNED THIS CAR THAT HAS HAPPENED NUMEROUS TIMES DURING THE LAST 4-5 YEARS. EACH DAY THE L300 STARTS FINE THE FIRST TIME . HOWEVER, WHEN THE VEHICLE IS SHUT OFF, (TO GET GASOLINE OR TO GO INTO A STORE) THE VEHICLE WILL FAIL TO RE-START. AFTER WAITING ANYWHERE FORM 15 MINUTES TO 1-1/2 HOURS, THE CAR WILL START LIKE NOTHING IS WRONG. ALTHOUGH THIS HAPPENS MOSTLY IN THE COLD WEATHER IT HAS ALSO HAPPENED DURING THE SUMMER TIME AS WELL. I BELIEVE THIS IS DUE TO THE SAME DEFECTIVE IGNITION SWITCH/PASS-LOCK SENSOR ISSUE AS THE RECALLED VEHICLES. *TR

NHTSA ODI #10566458

1,000 miles · Jun 18, 2003

Air BagsCrashInjury

WHILE DRIVING AT 20/25 MPH VEHICLE WAS IN A FRONTAL COLLISION AND NONE OF THE AIR BAG DEPLOYED UPON IMPACT.*AK

NHTSA ODI #10024323

Mileage unknown · May 27, 2003

Air BagsCrash

WHILE DRIVING 40 MPH THE VEHICLE WAS INVOLVED IN A FRONT COLLISION YET NEITHER OF THE AIR BAGS DEPLOY. *NLM. *AK

NHTSA ODI #10021617

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE06006 · Timing Chain Failure

Opened Jan 24, 2006 · Closed Jun 6, 2006

Status: closed (inferred from source dates) · Engine And Engine Cooling

ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).