← New search

2007 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2007 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

736 reports with mileage · 140 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 408 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 215 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports0 fire reports24 injury reports

Electronic Stability Control (esc) complaints

11 reports
Clear category filter
Mileage unknown · Aug 9, 2020
Electrical SystemElectronic Stability Control (esc)Service Brakes

🔑 IGNITION. WINDOW' DRIVER SIDE REMOTE

NHTSA ODI #11344155

182,000 miles · May 16, 2020
Electrical SystemElectronic Stability Control (esc)Steering

THE POWER STEERING LIGHT KEEPS COMING ON AND IT IS HARD TO STEER AND THE KEY KEEPS GETTING STUCK IN THE IGNITION. CAR WAS STATIONARY WHEN THE LIGHT TURNED ON. *TR

NHTSA ODI #11324741

173,387 miles · Mar 26, 2020
Electrical SystemElectronic Stability Control (esc)Engine

I NEED TO KNOW WHY YOUR SYSTEM SHOWS NO RECALLS FOR MY VEHICLE USING THE VIN NUMBER, BUT HAS (7) RECALLS IF I USE YEAR/MAKE/MODEL, THE SYSTEM SHOULD ALLOW ME TO RUN THE VIN, SEE ALL RECALLS, AND EVEN REPORT WITH PROOF IF THE RECALL IS COMPLETE, LIKE A CHECK LIST. YOUR SYSTEM IS USELESS IF THE MANUFACTURER IS NOT AGREEING TO THE …

Read full complaint

I NEED TO KNOW WHY YOUR SYSTEM SHOWS NO RECALLS FOR MY VEHICLE USING THE VIN NUMBER, BUT HAS (7) RECALLS IF I USE YEAR/MAKE/MODEL, THE SYSTEM SHOULD ALLOW ME TO RUN THE VIN, SEE ALL RECALLS, AND EVEN REPORT WITH PROOF IF THE RECALL IS COMPLETE, LIKE A CHECK LIST. YOUR SYSTEM IS USELESS IF THE MANUFACTURER IS NOT AGREEING TO THE RECALLS UNDER THE YEAR/MAKE/MODEL AND ASSIGNING THE RECALLS TO THE VIN TO GRANT APPROVAL TO DEALERS TO REPAIR, A DEALER WILL NOT COMPLETE A GM RECALL UNLESS GM APPROVES OF THE RECALL FOR A PARTICULAR VIN. I HAVE ELECTRICAL ISSUES WITH MY VEHICLE THAT FALLS IN THE CATEGORY OF THE RECALLS, BUT I'M NOT PAYING OUT OF POCKET FOR THESE REPAIRS, WHEN THEY ARE KNOWN SAFETY ISSUES.

NHTSA ODI #11319384

Mileage unknown · Dec 9, 2018
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

THROTTLE BODY POSITION SENSOR AGAIN AND AGAIN CAUSES MAJOR LOSS OF POWER AND SOMETIMES RESULTS IN STALLING OUT IN SECONDS

NHTSA ODI #11157100

Mileage unknown · Nov 27, 2017
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

POORLY DESIGNED SUNROOF DRAINAGE SYSTEM (SPECIFICALLY DRAIN NIPPLE AT END OF TUBING) CAUSING SEVERE LEAKS TO INSIDE CAB ALONG DRIVER AND PASSENGER FRONT DOORS AND FLOOR. WATER DAMAGE TO POWER WINDOWS, LOCKS, MIRRORS. WATER DAMAGE TO IP TO BODY HARNESS CONNECTOR UNDER FRONT DRIVER SIDE KICK PLATE CAUSING COMPUTER TO PRODUCE FALSE…

Read full complaint

POORLY DESIGNED SUNROOF DRAINAGE SYSTEM (SPECIFICALLY DRAIN NIPPLE AT END OF TUBING) CAUSING SEVERE LEAKS TO INSIDE CAB ALONG DRIVER AND PASSENGER FRONT DOORS AND FLOOR. WATER DAMAGE TO POWER WINDOWS, LOCKS, MIRRORS. WATER DAMAGE TO IP TO BODY HARNESS CONNECTOR UNDER FRONT DRIVER SIDE KICK PLATE CAUSING COMPUTER TO PRODUCE FALSE CHECK ENGINE CODES RELATED TO APP AND FORCING ENGINE INTO REDUCED POWER MODE AT HIGH SPEEDS CREATING POSSIBILITY FOR ACCIDENTS.

NHTSA ODI #11048631

126,000 miles · Jan 26, 2016
Electrical SystemElectronic Stability Control (esc)

I HAVE TO HAVE THE ELECTRICAL COMPUTER REPLACED - THE CAR DROPS TO 1ST GEAR AND DOESN'T MOVE UP, THE DOOR LOCKS LOCK THEN UNLOCK AND CONTINUE TO DO THAT, THE ENGINE LIGHT COMES ON, THE POWER STEERING ALARM COMES ON (BUT I DON'T LOSE POWER STEERING) AND THE SPEEDOMETER STOPS WORKING! THIS HAPPENS WHILE DRIVING WITH NO NOTICE EXC…

Read full complaint

I HAVE TO HAVE THE ELECTRICAL COMPUTER REPLACED - THE CAR DROPS TO 1ST GEAR AND DOESN'T MOVE UP, THE DOOR LOCKS LOCK THEN UNLOCK AND CONTINUE TO DO THAT, THE ENGINE LIGHT COMES ON, THE POWER STEERING ALARM COMES ON (BUT I DON'T LOSE POWER STEERING) AND THE SPEEDOMETER STOPS WORKING! THIS HAPPENS WHILE DRIVING WITH NO NOTICE EXCEPT THE DOOR LOCKS START FIRST THEM THE OTHER ISSUES HAPPEN SIMULTANEOUSLY.

NHTSA ODI #10822333

55,059 miles · Apr 1, 2014
Electrical SystemElectronic Stability Control (esc)

IGNITION LOCKED AND COULD NOT REMOVE KEY TO STOP ENGINE, ONLY WAY TO SHUT OFF ENGINE WAS TO DISCONNECT BATTERY CABLES--CALLED DEALER IN FREDERICK, MD THE VERY NEXT MORNING--HAD TO HAVE MY CAR TOWED TO THE GM DEALER, FREDERICK, MD, THE DEALERSHIP REPAIRED THE PROBLEM AND I WAS CHARGED $512.36 AND I PAID THE INVOICE OF $512.36. …

Read full complaint

IGNITION LOCKED AND COULD NOT REMOVE KEY TO STOP ENGINE, ONLY WAY TO SHUT OFF ENGINE WAS TO DISCONNECT BATTERY CABLES--CALLED DEALER IN FREDERICK, MD THE VERY NEXT MORNING--HAD TO HAVE MY CAR TOWED TO THE GM DEALER, FREDERICK, MD, THE DEALERSHIP REPAIRED THE PROBLEM AND I WAS CHARGED $512.36 AND I PAID THE INVOICE OF $512.36. I RECEIVED A RECALL LETTER ON MARCH 14, 2014 #14V-047 -- I AM REQUESTING THE REIMBURSEMENT IN THE MATTER.

NHTSA ODI #10576630

53,590 miles · Oct 9, 2012
Electronic Stability Control (esc)Steering

I CURRENTLY OWN A '07 SATURN ION AND JUST YESTERDAY MY POWER STEERING DISPLAY LIGHT CAME ON SHORTLY AFTER THAT I WAS UNABLE TO TURN MY STEERING WHEEL LUCKILY I WAS ABLE TO MOVE TO THE SIDE AND CALLED FOR HELP. *TR

NHTSA ODI #10479323

68,000 miles · Aug 20, 2012
Electronic Stability Control (esc)Fuel/propulsion SystemSteering

2007 SATURN ION 3 MANUAL SEDAN 1.) FUEL PUMP DELIVERY SYSTEM RECALL AND HAS BEEN REPAIRED AFTER A SERIOUS FUEL LEAK WAS DETECTED. 2.)PURGE FLOW SOLENOID- ENGINE LIGHT CAME ON AFTER THE PUMP DELIVERY SYSTEM WAS DETECTED BUT WAS NOT REPAIRED BECAUSE IT WAS NOT INCLUDED IN RECALL. CAR GETS VERY LITTLE GAS MILEAGE BECAUSE THE FU…

Read full complaint

2007 SATURN ION 3 MANUAL SEDAN 1.) FUEL PUMP DELIVERY SYSTEM RECALL AND HAS BEEN REPAIRED AFTER A SERIOUS FUEL LEAK WAS DETECTED. 2.)PURGE FLOW SOLENOID- ENGINE LIGHT CAME ON AFTER THE PUMP DELIVERY SYSTEM WAS DETECTED BUT WAS NOT REPAIRED BECAUSE IT WAS NOT INCLUDED IN RECALL. CAR GETS VERY LITTLE GAS MILEAGE BECAUSE THE FUEL TO OXYGEN RATIO BEING OFF. EVERY TIME I GO TO THE GAS STATION I CANNOT GET MY CAR TO START. IT DOESN'T MATTER IF I HAVE HALF OF A TANK OF GAS OR ALMOST ON EMPTY. IT TAKES SEVERAL TRIES AND ONLY STARTS AFTER I REV THE ENGINE BECAUSE THE FUEL TO OXYGEN RATIO AND THE FUEL PUMP FLOODS MY CAR AS SOON AS THE FUEL PUMP IS ENGAGED. I KNOW THAT AFTER THIS HAPPENS SO MANY TIMES THAT IT WILL CAUSE THE STARTER TO BURN UP IN MY CAR. 3.) IGNITION SWITCH- CANNOT TURN KEY ON AS IF THE STEERING WHEEL IS LOCKED/ CANNOT TURN KEY OFF/ TAKE KEY OUT AND CAR IS STILL RUNNING! DISCONNECT BATTERY TO SHUT THE CAR OFF. 4.) ELECTRONIC POWER STEERING- ACTS AS IF THE POWER STEERING HAS A SHORT. WHILE DRIVING WITH SPEEDS AS LITTLE AS 15MPH IN A RESIDENTIAL NEIGHBOR HOOD OR 70MPH ON THE INTERSTATE. THE POWER STEERING LIGHT COMES ON AND ALL POWER STEERING IS LOST AND BECOMES ALMOST IMPOSSIBLE TO DRIVE. AFTER SHUTTING THE CAR OFF AND RESTARTING THE CAR THE POWER STEERING WORKS BUT SHORTLY AFTER IT FAILS AGAIN. THIS HAPPENS EVERY TIME I DRIVE MY CAR. THE FIRST TIME THIS HAPPENED I WAS ON AN EXIT RAMP ON THE INTERSTATE WITH A VERY SHARP CURVE. I COULD BARELY CONTROL THE VEHICLE. NEEDLESS TO SAY MY CHILDREN ARE NO LONGER ALLOWED TO RIDE IN THIS CAR UNTIL IT IS REPAIRED. *TR

NHTSA ODI #10471573

76,000 miles · May 21, 2012
Electronic Stability Control (esc)

I WAS DRIVING ON A HIGHWAY AROUND 6 P.M. ON MY WAY HOME FROM WORK WITH MY 3 YEAR OLD IN THE BACK SEAT WHEN SUDDLENLY I FELT MY STEERING WHEEL JERK. I QUICKLY REALIZED SOMETHING WAS WRONG SO I EXITED THE ROAD AND WENT TO A NEARBY GAS STATION. I SAW THAT MY POWER STEERING LIGHT CAME ON. THIS IA A SERIOUS PROBLEM, AND GM WAS UNWILL…

Read full complaint

I WAS DRIVING ON A HIGHWAY AROUND 6 P.M. ON MY WAY HOME FROM WORK WITH MY 3 YEAR OLD IN THE BACK SEAT WHEN SUDDLENLY I FELT MY STEERING WHEEL JERK. I QUICKLY REALIZED SOMETHING WAS WRONG SO I EXITED THE ROAD AND WENT TO A NEARBY GAS STATION. I SAW THAT MY POWER STEERING LIGHT CAME ON. THIS IA A SERIOUS PROBLEM, AND GM WAS UNWILLING TO FIX THE ISSUE. I HAVE A 100 THOUSAND MILE POWER TRAIN WARRENTY YET THEY SAY THIS PROBLEM IS NOT COVERED. I HAVE HAD OTHER PROBLEMS IN THE PAST WITH THE ELECTRICAL SYSTEM AS WELL AS THE FUEL PUMP. WHY HAS THIS PROBLEM NOT BEEN ADDRESSED? I HAVE SEEN SEVERAL DIFFERENT PEOPLE FROM SEVERAL DIFFERENT RESCOURCES THAT HAVE HAD THE SAME PROBLEM, SO WHY IS THIS DAINGEROUS PROBLEM NOT BEEN DISCLOSED TO GM'S CUSTOMERS? *TT

NHTSA ODI #10459189

Official recalls

5

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

12V459000 · Fuel System, Gasoline:delivery:fuel Pump

Sep 19, 2012

General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

Consequence & remedy

Consequence: Fuel leakage in the presence of an ignition source may result in a fire.

Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.