← New search

2005 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2005 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

466 reports with mileage · 107 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 265 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

31 crash reports4 fire reports13 injury reports

What owners actually said

573 reports
8,000 miles · Aug 30, 2005
Electrical SystemFire

DT: VEHICLE WAS PARKED OUTSIDE IN THE YARD AND CONSUMER WENT TO THE VEHICLE TO GET SOME PAPERS OUT OF THE GLOVE COMPARTMENT AND SMELLED SMOKE COMING FROM BOTH FRONT AND BACK OF THE VEHICLE. NO FLAMES AT THIS TIME. CONSUMER DID NOT ENTER THE VEHICLE. RAN INSIDE THE HOUSE AND CALLED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT CA…

Read full complaint

DT: VEHICLE WAS PARKED OUTSIDE IN THE YARD AND CONSUMER WENT TO THE VEHICLE TO GET SOME PAPERS OUT OF THE GLOVE COMPARTMENT AND SMELLED SMOKE COMING FROM BOTH FRONT AND BACK OF THE VEHICLE. NO FLAMES AT THIS TIME. CONSUMER DID NOT ENTER THE VEHICLE. RAN INSIDE THE HOUSE AND CALLED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT CAME AND PUT THE FIRE OUT. THE FIRE DEPARTMENT INVESTIGATED THE VEHICLE AND DETERMINED IT WAS AN ELECTRICAL FIRE, AND MOST LIKELY WAS LINKED TO THE BATTERY, WHERE THEY BELIEVED THE FIRE ORIGINATED. NO REPAIRS WERE MADE. THE INSURANCE COMPANY DID NOT DETERMINE IF VEHICLE WAS TOTALED AT THIS TIME. *AK

NHTSA ODI #10134781

20 miles · Aug 19, 2005
Electrical System

DT: CONTACT PURCHASED A SATURN IN MARCH. SHE HAD PROBLEMS GETTING IT STARTED WITHIN THE FIRST FEW WEEKS. 3 MONTHS LATER ON 6-28-05 IT STOPPED SUDDENLY ON THE ROAD. THE CONTACT HAD INITIALLY TROUBLE TO START THE CAR. IT TOOK 3 TRIES TO GET IT STARTED. .SHE TOOK VEHICLE BACK TO THE DEALER, AND THEY COULD NOT DUPLICATE IT. O…

Read full complaint

DT: CONTACT PURCHASED A SATURN IN MARCH. SHE HAD PROBLEMS GETTING IT STARTED WITHIN THE FIRST FEW WEEKS. 3 MONTHS LATER ON 6-28-05 IT STOPPED SUDDENLY ON THE ROAD. THE CONTACT HAD INITIALLY TROUBLE TO START THE CAR. IT TOOK 3 TRIES TO GET IT STARTED. .SHE TOOK VEHICLE BACK TO THE DEALER, AND THEY COULD NOT DUPLICATE IT. ONE MONTH AND ONE DAY LATER IT HAPPENED AGAIN. IT DID START BACK RIGHT AWAY THEN. IT HAS BEEN IN THE REPAIR SHOP FOR 3 WEEKS, AND THEY COULD NOT DUPLICATE THE PROBLEM. SATURN WAS SUPPOSED TO COME AND LOOK AT THE CAR, THEY NEVER CAME. THE CONTACT WAS AFRAID TO GET IN THE CAR AND DRIVE IT. THE DEALERSHIP PROVIDED THE CONTACT A LOANER. THE DEALERSHIP HAD OTHER DEALERSHIPS COME FROM THE AREA TO LOOK AT THE CAR, AND COULD NOT FIND ANYTHING. SATURN OFFERED THE CONTACT AN EXTENDED WARRANTY , BUT SHE DID NOT WANT THE CAR. SHE DID NOT KNOW WHAT GOOD AN EXTENDED WARRANTY WAS IT THE VEHICLE QUIT ON THE HIGHWAY. *AK

NHTSA ODI #10133566

9,240 miles · Aug 17, 2005
Electrical System

IGNITION PROBLEMS, CAR WILL NOT START AND THEN STARTS AFTER A WHILE. DEALER IS BLAMING IT ON REMOTE START. *AK

NHTSA ODI #10133257

7,500 miles · Aug 14, 2005
Structure

DOOR PANELS CRACKED DURING EXTREME HEAT CO WORKER POINTED OUT THAT THERE WAS A CRACK ON MY DRIVERS SIDE PASSENGER SIDE AND REAR PASSENGER SIDE DOOR THE CRACK ON THE REAR DOOR EVENTUALLY BECAME A WHOLE CHUNK VEHICLE HAS BEEN IN NO ACCIDENTS. *NM

NHTSA ODI #10132772

1,023 miles · Aug 6, 2005
Power Train

I WAS DRIVING MY VEHICLE AND MY SHIFTER KNOB FELL OFF IN MY HAND. THE SHIFTER FAILED TO GO INTO SECOND AND FOURTH GEAR. I HAD THE CAR TOWED TO THE DEALER AND THE WHOLE SHIFTER SHAFT HAD TO BE REPLACED. *JB

NHTSA ODI #10131772

5,969 miles · Jun 21, 2005
Vehicle Speed Control

WAS DRIVING VEHICLE FROM MY HOUSE TO MY WORK AND I NOTICED SUDDENLY THAT WHENEVER I TOOK MY FOOT OFF THE GAS EVEN SLIGHTLY OR APPLIED MORE PRESSURE TO THE GAS PEDAL THT THE VEHICLE WOULD LOSE POWER AND JERK BACK A LITTLE BIT. I WORK FOR GM AND GET ALOT OF CALLS FROM CUST'S ABOUT CONCERNS, BUT I NEVER THOUGHT I'D ACTUALLY SAY THA…

Read full complaint

WAS DRIVING VEHICLE FROM MY HOUSE TO MY WORK AND I NOTICED SUDDENLY THAT WHENEVER I TOOK MY FOOT OFF THE GAS EVEN SLIGHTLY OR APPLIED MORE PRESSURE TO THE GAS PEDAL THT THE VEHICLE WOULD LOSE POWER AND JERK BACK A LITTLE BIT. I WORK FOR GM AND GET ALOT OF CALLS FROM CUST'S ABOUT CONCERNS, BUT I NEVER THOUGHT I'D ACTUALLY SAY THAT I FOR THE 1ST TIME IN MY LIFE DID NOT FEEL SAFE IN MY VEHICLE, ESPECIALLY KNOWING THAT MY VEHICLE WOULD DIE OR BREAK DOWN AT ANY MOMENT LEAVING ME STRANDED. NOTHING HAS BEEN DONE TO FIX THIS CONCERN, BUT ONE THINGS ARE TAKEN CARE OF AND HOPEFULLY CORRECTED I WILL UPDATE THINGS.

NHTSA ODI #10126136

3,000 miles · Jun 6, 2005
Electrical System

DT: RELAY VAN. THE REAR SLIDING DOORS INTERMITTENTLY OPEN, AND CONSUMER IS CONCERNED IF IT IS IN AN ACCIDENT, CONSUMER COULDN'T GET CHILDREN OUT. THE DEALER CAN NOT DUPLICATE THE PROBLEM, AND HAVE REPLACED THE ALTERNATOR WITH A HIGHER AMPERAGE ONE. THIS HELPED WITH THE LIGHTS DIMMING PROBLEM, BUT NOT THE INDICATOR ALARM SOUNDI…

Read full complaint

DT: RELAY VAN. THE REAR SLIDING DOORS INTERMITTENTLY OPEN, AND CONSUMER IS CONCERNED IF IT IS IN AN ACCIDENT, CONSUMER COULDN'T GET CHILDREN OUT. THE DEALER CAN NOT DUPLICATE THE PROBLEM, AND HAVE REPLACED THE ALTERNATOR WITH A HIGHER AMPERAGE ONE. THIS HELPED WITH THE LIGHTS DIMMING PROBLEM, BUT NOT THE INDICATOR ALARM SOUNDING OR THE REAR DOOR PROBLEM. *TT

NHTSA ODI #10124386

86 miles · Jun 6, 2005
Electrical System

DT: THE CAR IS LOSING POWER AT 70MPH AND IS SHUTTING ITSELF OFF. THE CAR WAS PURCHASED ON JUNE 3 AND IT WAS RETURNED TO THE DEALER ON JUNE 4 WITH THIS HAPPENING 4 TIMES IN LESS THAN 24 HOURS. THE SALES PERSON SAID "STAY THERE AND I KNOW WHAT IT IS, IT'S HAPPENED BEFORE". THE SALES PERSON DID COME AND PICK UP THE CONSUMER. THE S…

Read full complaint

DT: THE CAR IS LOSING POWER AT 70MPH AND IS SHUTTING ITSELF OFF. THE CAR WAS PURCHASED ON JUNE 3 AND IT WAS RETURNED TO THE DEALER ON JUNE 4 WITH THIS HAPPENING 4 TIMES IN LESS THAN 24 HOURS. THE SALES PERSON SAID "STAY THERE AND I KNOW WHAT IT IS, IT'S HAPPENED BEFORE". THE SALES PERSON DID COME AND PICK UP THE CONSUMER. THE SALES PERSON SAID THAT THE IGNITION WAS DEFECTIVE AND THE CONSUMER'S KEYCHAIN WAS AT FAULT. THE KEYCHAIN WEIGHED ABOUT AN OUNCE OR LESS. THE DEALERSHIP IS IN CONTROL OF THE VEHICLE AT THIS POINT. THERE ARE NO INDICATORS LIGHTS COMING ON IN THE VEHICLE. IT JUST LOSES POWER AND DIES. THIS IS A 2005 SATURN ION 2. THE OWNER HAD A SATURN ION 2 WITHOUT ANTI-LOCK BRAKES AND CHANGED MIND TO UPGRADE TO ONE WITH ABS, NOW SATURN IS NOT SO EAGER TO HELP CONSUMER. THE CAR IS STARTING RIGHT BACK, AFTER IT QUITS. *TT

NHTSA ODI #10124351

7,413 miles · May 27, 2005
Power Train

DT: CONSUMER HAS A 2005 SATURN THAT HAS BEEN IN THE SHOP FOR THE TRANSMISSION. THE TRANSMISSION DROPPED OUT OF GEAR AND SHIFTED BACK INTO GEAR WHILE GOING OVER 40 MPH. THIS CAN CAUSE THE CONSUMER TO BE INVOLVED IN A REAR-END COLLISION. CONSUMER HAS HAD THE CAR IN 3 TIMES FOR TRANSMISSION PROBLEMS. SOMETIMES IT HANGS IN GEAR A…

Read full complaint

DT: CONSUMER HAS A 2005 SATURN THAT HAS BEEN IN THE SHOP FOR THE TRANSMISSION. THE TRANSMISSION DROPPED OUT OF GEAR AND SHIFTED BACK INTO GEAR WHILE GOING OVER 40 MPH. THIS CAN CAUSE THE CONSUMER TO BE INVOLVED IN A REAR-END COLLISION. CONSUMER HAS HAD THE CAR IN 3 TIMES FOR TRANSMISSION PROBLEMS. SOMETIMES IT HANGS IN GEAR AND SHIFTS HARD. *TT

NHTSA ODI #10122331

500 miles · Mar 15, 2005
Electrical SystemFuel System, OtherVehicle Speed Control

CONSUMER COMPLAINED ABOUT ELECTRICAL PROBLEMS. WHILE DRIVING AND LOOKING AT THE DASHBOARD ALL THE GAUGES SHINED, INDICATING THAT NOTHING WAS OPERATING NORMALLY. THE GAS GAUGE/ SPEEDOMETER, AND BATTERY METER, ETC. *AK

NHTSA ODI #10115181

Official recalls

3

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.