NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
60 reportsClear category filter32,062 miles · May 18, 2007
Power Train
THE FAILURE WAS TO THE ARM THAT HELD THE CLUTCH PEDAL IN PLACE ON THE 2004 SATURN ION REDLINE. THE PART BROKE AND THE CLUTCH WAS COMPLETELY INOPERABLE ,AS SUCH THE CAR WAS RENDERED INOPERABLE. 5 MINUTES EARLIER I WAS ON A MAJOR HIGHWAY DOING 60 MPH AT WHICH SPEED I COULD HAVE LOST ALL CONTROL OF THE CAR AND CAUSED A MAJOR AC…
Read full complaint
THE FAILURE WAS TO THE ARM THAT HELD THE CLUTCH PEDAL IN PLACE ON THE 2004 SATURN ION REDLINE. THE PART BROKE AND THE CLUTCH WAS COMPLETELY INOPERABLE ,AS SUCH THE CAR WAS RENDERED INOPERABLE. 5 MINUTES EARLIER I WAS ON A MAJOR HIGHWAY DOING 60 MPH AT WHICH SPEED I COULD HAVE LOST ALL CONTROL OF THE CAR AND CAUSED A MAJOR ACCIDENT IN WHICH LIVES MAY HAVE BEEN LOST. THE DEAL OFFERED TO REPLACE THE PLASTIC ARM WITH ANOTHER PLASTIC ARM. THE PART THAT REPLACED MINE HAD A DIFFERENT PART NUMBER THAN ON THE ORIGINAL CAR, I WAS NOT SURE IF THIS WAS JUST A NEW PART NUMBER OR IF THE PART HAD BEEN REPLACED DUE TO PREVIOUS INCIDENTS. IF THERE WAS ANY HISTORY ON THIS PART I WAS NOT ABLE TO GAIN THE INFORMATION FROM THE DEALER, WHO WAS VERY UNWILLING TO COMPLY. THE DAMAGED PART WAS NOT RETURNED TO ME BECAUSE THEY CLAIMED THEY HAD TO RETURN ALL PARTS COVERED UNDER WARRANTY TO THE MANUFACTURER. *AK
NHTSA ODI #10191169
25,000 miles · Apr 19, 2007
EquipmentPower Train
IT IS BECOMING APPARENT THAT THE CLUTCH MASTER CYLINDER ON THE 2.2L AND 2.4L SATURN ION IS DEFECTIVE. THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS ON MULTIPLE FORUMS ACROSS THE INTERNET. I PERSONALLY HAVE HAD MINE REPLACED ONCE AND IT NEEDS REPLACED AGAIN. MY FEAR IS THAT I WILL BE DRIVING AND THAT IT WILL GO OUT COMPLETELY AND…
Read full complaint
IT IS BECOMING APPARENT THAT THE CLUTCH MASTER CYLINDER ON THE 2.2L AND 2.4L SATURN ION IS DEFECTIVE. THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS ON MULTIPLE FORUMS ACROSS THE INTERNET. I PERSONALLY HAVE HAD MINE REPLACED ONCE AND IT NEEDS REPLACED AGAIN. MY FEAR IS THAT I WILL BE DRIVING AND THAT IT WILL GO OUT COMPLETELY AND NOT ALLOW ME TO SHIFT, POSSIBLY CAUSING AN ACCIDENT. *JB
NHTSA ODI #10188401
56,000 miles · May 20, 2006
Engine And Engine CoolingPower Train
SATURN ION 2004. TWO MAJOR DEFECTS. I PURCHASED THE CAR NEW IN OCTOBER 2004. IN OCTOBER 2005, THE TRANSMISSION FAILED, AND REQUIRED COMPLETE REPLACEMENT. SATURN STATED THERE HAD BEEN MANY CONCERNS ABOUT THE TRANSMISSION, SO REPLACED IT FOR FREE. (MINUS MY INCURRED COSTS OF TRAVEL). SECOND MAJOR DEFECT: MAY 2006, A CYLINDE…
Read full complaint
SATURN ION 2004. TWO MAJOR DEFECTS. I PURCHASED THE CAR NEW IN OCTOBER 2004. IN OCTOBER 2005, THE TRANSMISSION FAILED, AND REQUIRED COMPLETE REPLACEMENT. SATURN STATED THERE HAD BEEN MANY CONCERNS ABOUT THE TRANSMISSION, SO REPLACED IT FOR FREE. (MINUS MY INCURRED COSTS OF TRAVEL). SECOND MAJOR DEFECT: MAY 2006, A CYLINDER HEAD CRACKED. SATURN HAS AGREED TO "REPLACE" THE CYLINDER HEAD, BUT I HAVE TO PAY FOR $800.00 OF THE REPAIRS. A 2 YEAR OLD VEHICLE SHOULD NOT HAVE THESE TWO MAJOR DEFECTS. THE CAR CURRENTLY HAS 79K MILES. I KNOW THAT "REPLACING" THE CYLINDER HEAD WILL GET THE CAR RUNNING AGAIN, BUT IT WILL NEVER BE THE SAME...AND I STILL OWE 10,000 DOLLARS ON THE CAR. THANK YOU FOR YOUR CONSIDERATION. *NM
NHTSA ODI #10157935
Mileage unknown · Jan 4, 2006
Engine And Engine CoolingPower TrainVehicle Speed Control
MULTIPLE EPISODES WITH THIS CAR OF SUDDEN ACCELERATION ESPECIALLY WHEN PUTTING CAR INTO DRIVE OR REVERSE. ROADSIDE ASSISTANCE HAS HAD TO START CAR FOR ME 2 TIMES. ANOTHER TIME THE CAR STALLED WHILE IDLING 4 TIMES WITHIN 30 MINUTE DRIVE. TONIGHT THE CAR LOST POWER COMPLETELY WHILE I WAS DRIVING. I SEE MULTIPLE COMPLAINTS ON THIS …
Read full complaint
MULTIPLE EPISODES WITH THIS CAR OF SUDDEN ACCELERATION ESPECIALLY WHEN PUTTING CAR INTO DRIVE OR REVERSE. ROADSIDE ASSISTANCE HAS HAD TO START CAR FOR ME 2 TIMES. ANOTHER TIME THE CAR STALLED WHILE IDLING 4 TIMES WITHIN 30 MINUTE DRIVE. TONIGHT THE CAR LOST POWER COMPLETELY WHILE I WAS DRIVING. I SEE MULTIPLE COMPLAINTS ON THIS PAGE FOR THE SAME PROBLEM. SATURN HAS NOT BEEN ABLE TO FIND ANY PROBLEMS ON THEIR COMPUTER. I WOULD LIKE TO FIGHT THIS WITH THE LEMON LAW BUT I AM SO AFRAID TO DRIVE THIS CAR NOW THAT I WANT TO JUST GET RID OF IT AS SOON AS POSSIBLE. *JB
NHTSA ODI #10146924
Mileage unknown · Dec 5, 2005
Power Train
2004 ION 3 QUAD PURCHASED NEW IN 2004 CURRENTLY HAVE 18K MILES ON IT. SO FAR WE HAVE HAD TO REPLACE FRONT STABILIZER BUSHING, HEATER BLOWER MOTOR AND WINDSHIELD WIPERS. ALL HAVE BEEN UNDER WARRANTY. THE ELECTRIC STEERING STILL DOESN'T SEEM CORRECT. SOMETIMES THE CAR PULLS WHEN YOU RAPIDLY ACCELERATE AND IS VERY TOUCHY. I DID RE…
Read full complaint
2004 ION 3 QUAD PURCHASED NEW IN 2004 CURRENTLY HAVE 18K MILES ON IT. SO FAR WE HAVE HAD TO REPLACE FRONT STABILIZER BUSHING, HEATER BLOWER MOTOR AND WINDSHIELD WIPERS. ALL HAVE BEEN UNDER WARRANTY. THE ELECTRIC STEERING STILL DOESN'T SEEM CORRECT. SOMETIMES THE CAR PULLS WHEN YOU RAPIDLY ACCELERATE AND IS VERY TOUCHY. I DID READ THAT GM MADE SOME CHANGES TO THE ELECTRIC STEERING FOR 2005 ION, BUT DEALERSHIP WILL NOT (SAYS CAN NOT) MAKE THE CHANGES TO THE 2004. NOW WE HAVE THE LOSS OF POWER PROBLEM. HAS DONE IT WHEN CAR IS COLD AND HOT, USUALLY WHEN ACCELERATING, BUT ONCE JUST DRIVING 35 MPH. IT'S NOT A STALL JUST LIKE A LOSS OF POWER. CAR DOESN'T SHAKE OR JERK. ALMOST LIKE YOU TOOK YOUR FOOT OFF THE GAS FOR A SECOND. I'VE TAKEN IT BACK TO THE DEALER ONCE FOR THIS AND THE DEALER RESPONSE IS THE SAME AS OTHERS HAVE REPORTED "NO COMPUTER CODES, COULD NOT REPRODUCE, NO PROBLEM FOUND". IT'S AT THE SHOP NOW BECAUSE THE CHECK ENGINE LIGHT CAME ON 12/2 AND WE AGAIN COMPLAINED THAT THE CAR LOST POWER AFTER PICKING IT UP THE LAST TIME. THE LAST TIME IT FAILED MY WIFE WAS TAKING OFF FROM A RED LIGHT AND THE GUY BEHIND ALMOST HIT HER WHEN THE SATURN LOST POWER. LOOSING FAITH IN SATURN'S ENGINEERING. *NM
NHTSA ODI #10144430
13,200 miles · Sep 18, 2005
Power Train
SHIFTER KNOB IN 04'SATURN ION REDLINE FELL OFF THE COLUMN WHILE SHIFTING 1-2. OCCURRED IN A PARKING LOT, ABLE TO STOP VEHICLE. ALL GEARS LOCKED OUT DUE TO REVERSE LOCKOUT, WAS ABLE TO REPLACE KNOB BY HAND AND UNLOCK GEARS. ALSO HAVE HAD CAP ON SHIFTER KNOB REPEATEDLY FALL OFF WHILE DRIVING, TO NO CONSEQUENCE OTHER THAN INCON…
Read full complaint
SHIFTER KNOB IN 04'SATURN ION REDLINE FELL OFF THE COLUMN WHILE SHIFTING 1-2. OCCURRED IN A PARKING LOT, ABLE TO STOP VEHICLE. ALL GEARS LOCKED OUT DUE TO REVERSE LOCKOUT, WAS ABLE TO REPLACE KNOB BY HAND AND UNLOCK GEARS. ALSO HAVE HAD CAP ON SHIFTER KNOB REPEATEDLY FALL OFF WHILE DRIVING, TO NO CONSEQUENCE OTHER THAN INCONVENIENCE. *NM
NHTSA ODI #10136878
27,539 miles · Sep 9, 2005
Power Train
I FIRST TOOK MY 2004 SATURN 3 ION QUAD COUPE TO THE DEALER WITH A TRANSMISSION PROBLEM. AS I WOULD ACCELERATE THE CAR WOULD LOSE SPEED. I NEVER KNEW WHEN THIS WAS GOING TO HAPPEN. IT HAPPENS AT ANY SPEED. AT THE TIME OF MY FIRST COMPLAINT THERE WAS 27,539. I NOW HAVE 33,020 AND FINALLY AFTER 3 MONTHS AND 12 TRIPS TO THE DEA…
Read full complaint
I FIRST TOOK MY 2004 SATURN 3 ION QUAD COUPE TO THE DEALER WITH A TRANSMISSION PROBLEM. AS I WOULD ACCELERATE THE CAR WOULD LOSE SPEED. I NEVER KNEW WHEN THIS WAS GOING TO HAPPEN. IT HAPPENS AT ANY SPEED. AT THE TIME OF MY FIRST COMPLAINT THERE WAS 27,539. I NOW HAVE 33,020 AND FINALLY AFTER 3 MONTHS AND 12 TRIPS TO THE DEALER THEY ARE PUTTING IN A NEW TRANSMISSION. EVERY TRIP TO THE DEALER RESULTED IN MY BEING TOLD THAT THE COMPUTER SAID NOTHING WAS WRONG WITH MY CAR. THEY KEPT THE CAR FOR A WEEK WHILE THEIR MANAGER DROVE IT TO WORK AND HOME EVERYDAY AND HE SAID THE CAR NEVER ACTED UP ON HIM. I LEFT THE DEALERSHIP AND 2 MILES DOWN THE ROAD IT STARTED ACTING UP. I HAD TO CALL THE SATURN CUSTOMER SERVICE NUMEROUS TIMES ABOUT THE PROBLEM. I WROTE THEM 2 LETTERS AND FINALLY WHEN I SENT THEM LEMON LAW PAPERS AND TOLD THEM THEY COULD BUY IT BACK THEY DECIDED THAT I NEEDED A NEW TRANSMISSION. IN THE 3 MONTHS TRYING TO GET THIS PROBLEM FIXED SATURN REPLACED THE CRUISE CONTROL SWITCH, THE INPUT/OUTPUT SPEED SENSOR AND COVER GASKET, THEN THEY REPLACED THE COVER ASSEMBLY, VARIABLE DRIVE AND DRIVEN PULLEY A AND NOW THE WHOLE TRANSMISSION IS BEING REPLACE. IT IS NOW IN THE SHOP FOR WHO KNOWS HOW LONG AND THEN IT WILL BE FOR SALE. *NM
NHTSA ODI #10135992
17,160 miles · Aug 29, 2005
Power Train
I HAVE A 2004 SATURN ION RED LINE WITH A MANUAL TRANSMISSION (ONLY TRANSMISSION OFFERED). I WAS SHIFTING FROM FIRST TO SECOND GEAR, IN TRAFFIC, AND THE ENTIRE SHIFT KNOB ASSEMBLY CAME OFF IN MY HAND. THE KNOB FELL TO THE DRIVER'S SIDE FLOOR, CAUSING ME TO LOOK DOWN. I WAS ABLE TO STOP THE VEHICLE IN TIME TO AVOID THE CAR IN…
Read full complaint
I HAVE A 2004 SATURN ION RED LINE WITH A MANUAL TRANSMISSION (ONLY TRANSMISSION OFFERED). I WAS SHIFTING FROM FIRST TO SECOND GEAR, IN TRAFFIC, AND THE ENTIRE SHIFT KNOB ASSEMBLY CAME OFF IN MY HAND. THE KNOB FELL TO THE DRIVER'S SIDE FLOOR, CAUSING ME TO LOOK DOWN. I WAS ABLE TO STOP THE VEHICLE IN TIME TO AVOID THE CAR IN FRONT OF ME. THE VEHICLE IS THEN DIFFICULT TO SHIFT, AND THE PULL UP FOR REVERSE FEATURE WAS VERY DIFFICULT. THERE ARE A NUMBER OF COMPLAINTS ON HTTP://WWW.SATURNFANS.COM. THE "FIX" IS TO EPOXY THE KNOB BACK ONTO THE SHIFTER BAR AS IT IS A PRESS FIT DESIGN (NO MECHANICAL LOCK OR FASTENERS).*JB
NHTSA ODI #10134682
13,400 miles · Aug 1, 2005
Power Train
WHILE DRIVING APPROXIMATELY 65-70 MPH ON AN INTERSTATE, MY VEHICLE JUST DIED - NO WARNING. THIS WAS THE SECOND TIME IT HAD HAPPENED. THERE IS NO POWER & MUST BE PULLED OFF THE ROAD & RESTARTED. THIS IS A VERY DANGEROUS CONDITION - RAPID DECELERATION ON A CONGESTED HIGHWAY COULD BE FATAL. WHEN I TOOK IT TO THE DEALER, THEY TO…
Read full complaint
WHILE DRIVING APPROXIMATELY 65-70 MPH ON AN INTERSTATE, MY VEHICLE JUST DIED - NO WARNING. THIS WAS THE SECOND TIME IT HAD HAPPENED. THERE IS NO POWER & MUST BE PULLED OFF THE ROAD & RESTARTED. THIS IS A VERY DANGEROUS CONDITION - RAPID DECELERATION ON A CONGESTED HIGHWAY COULD BE FATAL. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME NOTHING SHOWED UP ON THE COMPUTER, THEREFORE NOTHING WAS WRONG WITH THE CAR. TALKING TO THE SATURN CUSTOMER SERVICE REP RETURNED THE SAME RESPONSE. I AM VERY AFRAID TO DRIVE THIS VEHICLE, IT IS A VERY HAZARDOUS CONDITION AND THE CAR IS ONLY ONE YEAR OLD. IT IS A 2004 SATURN ION. THE DEALER REFUSES TO REPLACE ANYTHING BECAUSE "NOTHING IS WRONG. *JB
NHTSA ODI #10130777
3,400 miles · Jul 15, 2005
Power Train
DT: CONSUMER STATES THAT VEHICLE DOES NOT ACCELERATE FROM A STOPPED POSITION. AT DIFFERENT TIMES IT COULD TAKE APPROXIMATELY 10-15 SECONDS TO GO. THIS OCCURS MOSTLY WHILE THE VEHICLE IS STOPPED, AND HAPPENED ONCE WHEN VEHICLE WAS GOING. CONSUMER TOOK VEHICLE TO SATURN DEALER, AND WAS TOLD NOTHING THEY COULD DO UNLESS THE…
Read full complaint
DT: CONSUMER STATES THAT VEHICLE DOES NOT ACCELERATE FROM A STOPPED POSITION. AT DIFFERENT TIMES IT COULD TAKE APPROXIMATELY 10-15 SECONDS TO GO. THIS OCCURS MOSTLY WHILE THE VEHICLE IS STOPPED, AND HAPPENED ONCE WHEN VEHICLE WAS GOING. CONSUMER TOOK VEHICLE TO SATURN DEALER, AND WAS TOLD NOTHING THEY COULD DO UNLESS THEY COULD DUPLICATE THE ACTION. *AK *JB
NHTSA ODI #10126677
Official recalls
8Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jun 8, 2004
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 6, 2004
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
Consequence & remedy
Consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Remedy: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.
Illustration