IllustrationTHE VEHICLE WOULD INTERMITTENTLY NOT START. THIS MOSTLY OCCURRED IN BELOW FREEZING TEMPERATURE CONDITIONS BUT WOULD ALSO OCCUR IN ABOVE 70 DEGREE TEMPERATURES. THE VEHICLE ALSO STALLED WHILE BEING DRIVEN AND COULD IMMEDIATELY BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE IGNITION SWITCH. *NM
2003 Saturn Ion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Saturn Ion do not stand out strongly from the model-year median of 816.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
8425–50K
12650–75K
8575–100K
114100–150K
57150K+
553 reports with mileage · 204 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 382 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 139 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports4 fire reports22 injury reports
Electrical System complaints
382 reportsDT*: THE CONTACT STATED THE VEHICLE WOULD NOT START RIGHT AWAY IN COOLER WEATHER, FOR AT LEAST 15 MINUTES. THROUGH INTERNET RESEARCH, THE CONTACT BELIEVED THE PROBLEM WAS THE IGNITION SWITCH. AN APPOINTMENT HAD BEEN SCHEDULED WITH A SERVICE DEALER AND THE MANUFACTURER WAS NOTIFIED.
WHEN IT IS COLD OUT AND THE CAR HAS SAT, IT WILL NOT CRANK. I HAVE SEEN INFORMATION THAT IT MAY BE RELATED TO THE BODY CONTROL MODULE $590 FIX, OR THE IGNITION SWITCH $200 FIX. THE PROBLEM APPEARS TO BE TIED TO THE THEFT DETERRENT SYSTEM. IF THE CAR DOES NOTHING, AND I LOCK AND THEN UNLOCK THE CAR IT WILL CRANK FOR 1/2 A SECO…
Read full complaint
WHEN IT IS COLD OUT AND THE CAR HAS SAT, IT WILL NOT CRANK. I HAVE SEEN INFORMATION THAT IT MAY BE RELATED TO THE BODY CONTROL MODULE $590 FIX, OR THE IGNITION SWITCH $200 FIX. THE PROBLEM APPEARS TO BE TIED TO THE THEFT DETERRENT SYSTEM. IF THE CAR DOES NOTHING, AND I LOCK AND THEN UNLOCK THE CAR IT WILL CRANK FOR 1/2 A SECOND THEN STOP. IT WONT CRANK AGAIN UNTIL I LOCK AND UNLOCK THE CAR AGAIN. EVENTUALLY AFTER DOING THIS NUMEROUS TIMES IT WILL START. I KNOW THAT THERE IS A TSB ON THIS PROBLEM BUT BELIEVE THAT IT SHOULD BE A RECALL ITEM FOR EITHER THE BCM, THE IGNITION SWITCH, OR BOTH. *NM
I HAVE BEEN HAVING SOME ISSUES WITH CLUNKING AND GRINDING NOISES WHEN GOING OVER BUMPS OR POTHOLES OR WHILE MAKING TURNS. I TOOK MY 2003 ION 2 TO HAVE THIS CHECKED AND I FOUND OUT THAT THE PROBLEMS WAS BOTH OF MY CONTROL ARM BUSHINGS. MY CAR IS 2 MONTHS OUT OF WARRANTY AND HAS ONLY 38,000 MILES ON IT, SO AT FIRST I THOUGHT THA…
Read full complaint
I HAVE BEEN HAVING SOME ISSUES WITH CLUNKING AND GRINDING NOISES WHEN GOING OVER BUMPS OR POTHOLES OR WHILE MAKING TURNS. I TOOK MY 2003 ION 2 TO HAVE THIS CHECKED AND I FOUND OUT THAT THE PROBLEMS WAS BOTH OF MY CONTROL ARM BUSHINGS. MY CAR IS 2 MONTHS OUT OF WARRANTY AND HAS ONLY 38,000 MILES ON IT, SO AT FIRST I THOUGHT THAT THIS COULD BE UNTRUE. BUT, AFTER INTERNET RESEARCH IT SEEMS THAT MANY 2003 ION DRIVERS HAVE HAD THIS PROBLEM. I CALLED MY SATURN DEALER AND THEY ACTED LIKE THEY HAD NEVER HEARD OF THIS PROBLEM AND COULD DO NOTHING TO HELP ME OR FIX IT. MY OTHER PROBLEM WITH THE CAR, WHICH ALSO SEEMS TO BE A COMMON PROBLEM, IS THAT THE SERVICE ENGINE SOON LIGHT COMES ON INTERMITTENTLY. ONE DAY IT WILL BE ON, AND THE NEXT IT WILL BE FINE. *JB
THIS HAS HAPPENED TWICE IN EXACTLY THIRTEEN MONTHS THE FIRST TIME WAS ON FEBRUARY 3, 2005. I ADJUSTED MY POWER DRIVERS SIDE MIRROR WHILE DRIVING HOME AT NIGHT ON HIGHWAY 61 AND HEARD A POP AND ALL MY LIGHTS INCLUDING HEADLIGHTS AND DASH LIGHTS WENT OUT . MY FOUR WAY SAFETY FLASHERS ALSO WOULD NOT WORK I WAS DRIVING IN COMPLETE…
Read full complaint
THIS HAS HAPPENED TWICE IN EXACTLY THIRTEEN MONTHS THE FIRST TIME WAS ON FEBRUARY 3, 2005. I ADJUSTED MY POWER DRIVERS SIDE MIRROR WHILE DRIVING HOME AT NIGHT ON HIGHWAY 61 AND HEARD A POP AND ALL MY LIGHTS INCLUDING HEADLIGHTS AND DASH LIGHTS WENT OUT . MY FOUR WAY SAFETY FLASHERS ALSO WOULD NOT WORK I WAS DRIVING IN COMPLETE DARKNESS WHILE TRAVELING APPROXIMATELY 67 MPH THIS INCIDENT OCCURRED ALMOST IDENTICALLY LAST YEAR WHILE DRIVING IN TOWN APPROXIMATELY 25 MPH ADJUSTED MIRROR HEARD A POP AND ALL LIGHTS WENT OUT. LUCKILY IN BOTH INCIDENTS NO ONE HIT ME FROM BEHIND DUE TO THE FACT THEY COULDN'T SEE ME UNTIL IT WAS TOO LATE. NO ONE WAS KILLED OR INJURED BUT THAT WAS JUST PURE LUCK .. LAST YEARS INCIDENT I HAD MY CAR TOWED TO SATURN AND THEY DETERMINED THAT THE BCM FUSE WAS BAD THEY REPLACED FUSE. OBVIOUSLY THEY DID NOT GET TO THE ROOT OF THE PROBLEM YOU WOULD THINK YOU CAN ADJUST YOUR POWER MIRROR WITHOUT HAVING ALL LIGHTS SHUT OFF INCLUDING DASH LIGHTS .. ONCE YOU PUT THE VEHICLE INTO PARK YOU CANNOT TURN IT OFF COMPLETELY THE KEY WILL ONLY GO AS FAR AS THE ACCESSORY POSITION AND CANNOT BE REMOVED. THE ENGINE WILL RUN YOU JUST CAN'T MOVE THE VEHICLE. SOMEHOW I DO NOT THINK THEY CORRECTED THE PROBLEM ENTIRELY WHEN THEY REPLACED THE FUSE. IT SEEMS TO ME YOU SHOULD NOT BLOW A BCM FUSE EVERY THIRTEEN MONTHS EXACTLY TO THE DAY. IT IS SUCH A POTENTIALLY FATAL PROBLEM THE CONSEQUENCES ARE TERRIFYING. MY 2003 SATURN ION-3 CAN NOT BE THE ONLY CAR OUT THERE WITH THIS HAPPENING ESPECIALLY TWICE IN THIRTEEN MONTHS. *JB
MY CAR WON'T START! AT LEAST EVERY ONCE IN A WHILE ANYWAY. IT'S A 2003 SATURN ION. I BOUGHT IT USED ON 5/14/05 AND A FEW MONTHS AFTER, WHEN IT STARTED TO GET COLD IN GA., IT WOULDN'T START. AFTER ABOUT 10-30 MINUTES, IT WOULD FINALLY START AS IF THERE WAS NO PROBLEM LEAVING ME FEELING LIKE I WAS GOING CRAZY. I THOUGHT IT MAY BE …
Read full complaint
MY CAR WON'T START! AT LEAST EVERY ONCE IN A WHILE ANYWAY. IT'S A 2003 SATURN ION. I BOUGHT IT USED ON 5/14/05 AND A FEW MONTHS AFTER, WHEN IT STARTED TO GET COLD IN GA., IT WOULDN'T START. AFTER ABOUT 10-30 MINUTES, IT WOULD FINALLY START AS IF THERE WAS NO PROBLEM LEAVING ME FEELING LIKE I WAS GOING CRAZY. I THOUGHT IT MAY BE THE BATTERY, SO I REPLACED THAT (40.00 DOLLARS). IT STILL GAVE ME PROBLEMS THAT VERY NIGHT! I TOOK IT TO THE DEALERSHIP, AND HAD A DIAGNOSTIC CHECK DONE (40.00 DOLLARS), THEY COULDN'T FIND ANYTHING WRONG, AND BASICALLY BLEW ME OFF. DISCOURAGED, I LEFT AND GAVE UP. IT CONTINUED TO ACT UP 2 DAYS LATER, WHICH I JUST DEALT WITH. I TOOK IT TO THE SHOP YESTERDAY FOR A OIL CHANGE AND GUESS WHAT? IT WOULDN'T START WHILE IT WAS THERE. THEY TOLD ME THAT WHILE THEY WERE ABOUT TO TAKE IT TO THE WASH IT WOULDN'T START, AND ASKED ME IF I HAD ANY PROBLEMS. I SAID YEA. THEY SAID THEY WERE SURE THEY'D LOCATE THE PROBLEM THAT DAY. CAME BACK AN HOUR LATER TO TELL ME THAT IT WAS THE TECHNICIAN FAULT, CLAIMING THAT HE HAD LEFT IT IN DRIVE WHILE TRYING TO START IT (HOW WOULD HE GET IT IN DRIVE IF IT WOULDN'T START?) ANYWAY, IT WOULDN'T START THAT NIGHT! AT THIS POINT IM GOING TO GET MY FUTURE FATHER IN LAW INVOLVED SINCE HE IS AN ENGINEER AND HAVE HIM STIR THE PUDDING. OH, AND HE BELIEVES IT A SHORT WITH THE ELECTRICAL SYSTEM SO WE WILL HAVE TO HAVE THEM TO CHECK THAT OUT. *NM
DT*: THE CONTACT STATED WHILE DRIVING ON THE FREEWAY BETWEEN 50-60 MPH, THE VEHICLE LOST ALL ELECTRICAL POWER. THERE IS NO WARNING WHEN THIS OCCURS AND THE STEERING WHEEL ALSO LOCKS UP. THE VEHICLE IS PULLED OVER AND RESTARTED. THE DEALERSHIP REPLACED THE IGNITION SWITCH AND FUEL PUMP. THE CONTACT HAS BEEN OUT OF THE COUNTR…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING ON THE FREEWAY BETWEEN 50-60 MPH, THE VEHICLE LOST ALL ELECTRICAL POWER. THERE IS NO WARNING WHEN THIS OCCURS AND THE STEERING WHEEL ALSO LOCKS UP. THE VEHICLE IS PULLED OVER AND RESTARTED. THE DEALERSHIP REPLACED THE IGNITION SWITCH AND FUEL PUMP. THE CONTACT HAS BEEN OUT OF THE COUNTRY SINCE THE REPAIR, LAST YEAR; THE VEHICLE HAS NOT BEEN DRIVEN SINCE REPAIRS WERE MADE.
WHEN WEATHER TURNS COLD CAR WILL NOT START, AFTER 20 - 30 MINUTES CAR STARTS. AFTER FIRST VISIT TO DEALER WE WERE TOLD THERE WAS NO PROBLEM FOUND, A YEAR LATER AS WINTER RETURNS SO DOES THE PROBLEM AND NOW WE ARE TOLD THAT THE BODY CONTROL MODULE AND THE PASSLOCK SENSOR BOTH NEED TO BE REPLACED. WE HAVE ALSO BEEN TOLD THAT THIS …
Read full complaint
WHEN WEATHER TURNS COLD CAR WILL NOT START, AFTER 20 - 30 MINUTES CAR STARTS. AFTER FIRST VISIT TO DEALER WE WERE TOLD THERE WAS NO PROBLEM FOUND, A YEAR LATER AS WINTER RETURNS SO DOES THE PROBLEM AND NOW WE ARE TOLD THAT THE BODY CONTROL MODULE AND THE PASSLOCK SENSOR BOTH NEED TO BE REPLACED. WE HAVE ALSO BEEN TOLD THAT THIS IS NOT COVERED UNDER WARRANTY OR EVEN THE EXTENDED WARRANTY WE PURCHASED. I HAVE HELD OFF ON REPAIRING AS WE HAVE ANOTHER VEHICLE WE CAN USE AND DID SOME RESEARCH ON THE INTERNET. ALTHOUGH WE HAVE NOT EXPERIENCED ALL THE SYMPTOMS DESCRIBED BY OTHERS, ONE DISTURBING SYMPTOM IS THAT SOME GM VEHICLES EXPERIENCE SUDDEN LOSS OF POWER AND OR STALLING. NOTHING HAS BEEN DONE TO CORRECT THIS PROBLEM YET.
(1) HIGHWAY DRIVING (2) FOUND OUT THE WINDSHIELD WIPERS NO LONGER WORKED ON ANY SETTING AFTER SOME WATER SPLASHED UP ON MY WINDSHIELD. NEARLY HAD AN ACCIDENT FROM INABILITY TO SEE. FOUND OUT AFTER I STOPPED THAT THE TRUNK RELEASE ALSO NO LONGER WORKED. (3) CONTACTED SATURN VIA EMAIL. ACTION IS PENDING. *NM
UNRESOLVE PROBLEM (7/2004 - 7/2005) VEHICLE IS UNSAFE. SUDDENLY STALLS AND STOPS WHILE ON HIGHWAY CREATING HAZARD FOR TRAFFIC FOLLOWING AT 65 MPH. RETURNED TO DEALER SEVERAL TIMES. THEY CAN NOT ISOLATE THE PROBLEM AND CAN NOT REPAIR.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
04V547000 · Exterior Lighting:turn Signal
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
04V003000 · Fuel System, Gasoline
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
04V004000 · Visibility:power Window Devices And Controls
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE07011 · Windshied Wiper Linkage Failure
Opened Feb 28, 2007 · Closed Aug 9, 2007
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:linkages
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
PE06006 · Timing Chain Failure
Opened Jan 24, 2006 · Closed Jun 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).
DP05008 · Timing Chain Failure
Opened Dec 20, 2005 · Closed Feb 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ANALYSIS UNDERTAKEN IN RESPONSE TO THE PETITION IDENTIFIED 26 COMPLAINTS ALLEGING TIMING CHAIN FAILURES IN MY 2000-2003 SATURN L-SERIES VEHICLE EQUIPPED WITH THE 2.2L L4 ENGINE.MOST COMPLAINTS OF TIMING CHAIN FAILURE REPORTEDLY RESULTED IN A SUDDEN LOSS OF ENGINE POWER AND STALLING.ODI ALSO NOTED THAT CERTAIN MY 2002-2003 SATURN VUE AND MY 2003 SATURN ION MODEL VEHICLES WITH THE 2.2L ENGINE VEHICLESCOVERED BY A TECHNICAL SERVICE BULLETIN (03-06-01-017) THAT ADDRESSED TIMING CHAIN DESIGN AND SERVICE PROCEDURE CHANGES, EXHIBITED NO COMPLAINTS OF TIMING CHAIN FAILURE.ODI WILL GRANT THE PETITION AND OPEN A PRELIMINARY EVALUATION TO ASSESS THE FREQUENCY, TREND, SCOPE AND SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.REFER TO PE06-006.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.