NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
382 reportsClear category filter78,500 miles · May 18, 2018
Electrical System
THE IGNITION SWITCH IS NOT WORKING PROPERLY. SOMETIMES, WHEN VEHICLE IS PARKED AND AN ATTEMPT MAKE TO TURN IGNITION TO OFF POSITION, IT WON'T GO. IT SEEMED TO TAKE 10 - 60 SECONDS FOR IT TO RESET AND THEN KEY COULD BE REMOVED. THE LATEST INCIDENT OCCURRED ON 5/12-13/2018. THE VEHICLE WAS PARKED, TRANSMITION IN PARK POSITION, …
Read full complaint
THE IGNITION SWITCH IS NOT WORKING PROPERLY. SOMETIMES, WHEN VEHICLE IS PARKED AND AN ATTEMPT MAKE TO TURN IGNITION TO OFF POSITION, IT WON'T GO. IT SEEMED TO TAKE 10 - 60 SECONDS FOR IT TO RESET AND THEN KEY COULD BE REMOVED. THE LATEST INCIDENT OCCURRED ON 5/12-13/2018. THE VEHICLE WAS PARKED, TRANSMITION IN PARK POSITION, AND AN ATTEMPT MADE TO TURN IGNITION TO THE OFF POSITION. THE KEY COULD NOT BE MOVED. IT DID NOT RESET ITSELF. KEY WAS STUCK IN THE IGNITION, COULD BE TURNED SLIGHTLY TO THE RIGHT, VEHICLE COULD NOT BE RESTARTED. THEN ALL POWER WAS LOST, AS THOUGH THE BATTERY WAS DEAD. THE VEHICLE COULD NOT BE LOCKED OF UNLOCKED WITH THE KEY FOR, HAD TO USE A SECOND KEY TO LOCK AND UNLOCK THE VEHICLE. THIS VEHICLE WAS RECALLED FOR IGNITION SWITCH PROBLEMS IN 2015 AND WAS REPAIRED. THE SAME PROBLEM IS OCCURRING AGAIN. GM TELLS ME THE NEW REPAIR IS NOT GOING TO BE COVERED BY THEM. THE REASON, I'M TOLD, IS BECAUSE THE VEHICLE HAD TO CHECKED INTO THE DEALERSHIP NO LATER THAN 5/17/18. THE VEHICLE WAS TOWED TO THE DEALERSHIP ON THAT DATE. DUE TO SEVERE STORMS IN THE AREA THE TOW TRUCK DRIVER ARRIVED AT THE DEALERS SHIP A FEW MINUTES AFTER THE SERVICE DEPARTMENT CLOSED AND DEPOSITED THE KEY IN THE LOCK BOX. A REP FROM GM WAS SUPPOSED TO HAVE CALLED THE DEALERSHIP ON 5/17/18 BETWEEN 5:45 AND 6:00 TO ALERT THEM THE VEHICLE WAS ON THE WAS AND MIGHT BE A FEW MINUTES LATE AND TO PLEASE ACCEPT THE VEHICLE AND GET IT CHECKED IN. I AM ADVISED BY THE DEALERSHIP THEY RECEIVED NO SUCH CALL. THIS IS GOING TO BE AN EXPENSIVE REPAIR, I DID EVERYTHING THE GM REP ASKED OF ME, I AM 70 YEARS OLD AND HAVE A VERY LIMITED INCOME. I CAN'T BE THE ONLY PERSON THIS HAS HAPPENED TO. PLEASE HELP ME.
NHTSA ODI #11096740
Mileage unknown · Apr 4, 2018
Electrical SystemSteering
2003 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH AND POWER STEERING RECALL NOTICES ISSUES. *SMD *CN
NHTSA ODI #10725028
Mileage unknown · Dec 13, 2017
Electrical SystemElectronic Stability Control (esc)Steering
CAR JUST RECENTLY POPPED UP POWER STEERING ONLY HAPPENS WHEN ITS SITS OVER NIGHT AND WHEN I START IT UP IN THE MORNING IT'S VERY STIFF TO TURN BUT IF I DRIVE IT LIKE THAT FOR A LITTLE AND SHUT THE CAR OFF THE STEERING IS FINE. THE DASH LIGHTS FLICKER OFF AND ON AND WHEN DOING SO CAUSES HEAT OR A/C TO CUT OUT AFTER DRIVING IT FOR…
Read full complaint
CAR JUST RECENTLY POPPED UP POWER STEERING ONLY HAPPENS WHEN ITS SITS OVER NIGHT AND WHEN I START IT UP IN THE MORNING IT'S VERY STIFF TO TURN BUT IF I DRIVE IT LIKE THAT FOR A LITTLE AND SHUT THE CAR OFF THE STEERING IS FINE. THE DASH LIGHTS FLICKER OFF AND ON AND WHEN DOING SO CAUSES HEAT OR A/C TO CUT OUT AFTER DRIVING IT FOR ALITTLE BIT. THE KEY LOCKS IN THE IGNITION SWITCH WHEN I GO TO SHUT OFF THE CAR AND I HAVE TO PRESS THE PLUNGER FOR IT TO RELEASE. KEEPS SAYING COOLANT WHEN GOING DOWN THE ROAD EVEN THOUGH THE COOLANT IS WHERE IT NEEDS TO BE. *TR
NHTSA ODI #11054619
69,000 miles · Aug 25, 2017
Electrical SystemSteering
SEVERAL TIMES WHEN I HAVE GONE TO TURN OFF MY CAR THE IGNITION SWITCH WILL NOT RELEASE THE KEY. WHEN THIS HAPPENS I HAVE TO PLACE MY FOOT BACK ON THE BRAKE AND RUN THROUGH THE GEARS WITH MY GEAR STICK. THE IGNITION SWITCH THAT IS CURRENTLY IN MY CAR IS ONE THAT WAS USED TO REPLACE THE FACTORY ONE WHEN THE IGNITION SWITCH RECALL …
Read full complaint
SEVERAL TIMES WHEN I HAVE GONE TO TURN OFF MY CAR THE IGNITION SWITCH WILL NOT RELEASE THE KEY. WHEN THIS HAPPENS I HAVE TO PLACE MY FOOT BACK ON THE BRAKE AND RUN THROUGH THE GEARS WITH MY GEAR STICK. THE IGNITION SWITCH THAT IS CURRENTLY IN MY CAR IS ONE THAT WAS USED TO REPLACE THE FACTORY ONE WHEN THE IGNITION SWITCH RECALL WAS ISSUED. ALSO, RECENTLY MY CAR HAS BEEN SHOWING PROBLEMS WITH THE POWER STEERING. IT HAS GONE OUT MULTIPLE TIMES ON MY SON WHILE HE WAS DRIVING RESULTING IN HIM HAVING TO FIGHT THE CAR TO GET IT TO TURN. I HAVE NEVER HAD A PROBLEM BEFORE AND I HEAR THAT THERE ARE RECALLS FOR BOTH. THESE PROBLEMS HAVE HAPPENED MULTIPLE TIMES AND I DO NOT HAVE EXACT DATES.
NHTSA ODI #11019790
112,246 miles · Jun 22, 2017
Electrical System
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED WITHOUT WARNING AND LOST POWER COMPLETELY. THE VEHICLE VEERED TO THE RIGHT SIDE OF THE ROAD AND CAME TO A ROLLING STOP. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT STATED THAT THE FAILURE OCCURRED ON FOUR SEPARATE OCCASIONS. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED WITHOUT WARNING AND LOST POWER COMPLETELY. THE VEHICLE VEERED TO THE RIGHT SIDE OF THE ROAD AND CAME TO A ROLLING STOP. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT STATED THAT THE FAILURE OCCURRED ON FOUR SEPARATE OCCASIONS. THE VEHICLE WAS REPAIRED IN MAY OF 2014 PER NHTSA CAMPAIGN NUMBER: 14V047000 (ELECTRICAL SYSTEM) AT A UNKNOWN DEALER, BUT THE FAILURE RECURRED. GENERAL MOTORS WAS MADE AWARE OF THE FAILURES AND STATED THAT THE VEHICLE WAS UNDER A TWELVE MONTH WARRANTY, WHICH EXPIRED IN APRIL OF 2015. THE FAILURE MILEAGE WAS 112,246.
NHTSA ODI #11000647
Mileage unknown · May 24, 2017
Electrical System
MY IGNITION SWITCH WOULDNT TURN ONCE THE KEY WAS IN SO I OPENED IT UP TOOK A LOOK AND PUT IT BACK IN. NOW IT TURNS BUT IT TURNS ON AND BACK OFF BEFORE AFTER JIGGLING THE KEY A LITTLE IT WOULD TURN ON. NOW IT DOESNT JUST STARTS AND TURNS OFF.
NHTSA ODI #10991558
140,000 miles · May 16, 2017
Electrical System
TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE IGNITION FAILED TO TURN OFF AND PREVENTED THE KEY FROM BEING REMOVED. ALSO, THE KEY WAS UNABLE TO START THE IGNITION. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE IGNITION FAILED TO TURN OFF AND PREVENTED THE KEY FROM BEING REMOVED. ALSO, THE KEY WAS UNABLE TO START THE IGNITION. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.
NHTSA ODI #10985941
110,000 miles · Mar 28, 2017
Electrical SystemCrash
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING AND CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER AN UN…
Read full complaint
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING AND CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER AN UNKNOWN RECALL FOR THE IGNITION SWITCH. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. *TT *AS
NHTSA ODI #10969008
141,000 miles · Aug 15, 2016
Air BagsElectrical SystemEngine
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER AND REPAIRED PER A RECALL. AFTER THE REPAIRS, WHIL…
Read full complaint
TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER AND REPAIRED PER A RECALL. AFTER THE REPAIRS, WHILE DRIVING AT VARIOUS SPEEDS, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE AIR BAG AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE RECALL SPECIFICS WERE UNKNOWN. THE FAILURE MILEAGE WAS 141,000. UPDATED 10/19/16*LJ *TR
NHTSA ODI #10895916
114,575 miles · May 9, 2016
Electrical SystemElectronic Stability Control (esc)Vehicle Speed Control
TAKATA RECALLS..I HAVE A 2003 SATURN ION I WAS DRIVING FINE HIT CRUISE CONTROL BUTTON ONCE I WAS AT 55 AN MY CAR MADE A CLICKING SOUND STARTED JERKING LIKE THE CRUISE CONTROL KEEPS COMING ON...I'VE TURNED CAR OFF HIT BRAKES WHICH SHOULD RESET IT BUT IT STILL HAPPENS..THE CAR FEELS LIKE ITS DOWN SHIFTING AN TRYING TO ACCELERATE O…
Read full complaint
TAKATA RECALLS..I HAVE A 2003 SATURN ION I WAS DRIVING FINE HIT CRUISE CONTROL BUTTON ONCE I WAS AT 55 AN MY CAR MADE A CLICKING SOUND STARTED JERKING LIKE THE CRUISE CONTROL KEEPS COMING ON...I'VE TURNED CAR OFF HIT BRAKES WHICH SHOULD RESET IT BUT IT STILL HAPPENS..THE CAR FEELS LIKE ITS DOWN SHIFTING AN TRYING TO ACCELERATE ON ITS ON THE RPMS HUMP REAL HIGH WEN THIS HAPPENS..YOU BE DRIVING DOING 50 MPH AN ALL THE SUDDEN CAR JERKS LIKE ITS TRYING TO STOP U FEEL I T IN GAS PEDAL ALSO...
NHTSA ODI #10863856
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE07011 · Windshied Wiper Linkage Failure
Opened Feb 28, 2007 · Closed Aug 9, 2007
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:linkages
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
PE06006 · Timing Chain Failure
Opened Jan 24, 2006 · Closed Jun 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).
DP05008 · Timing Chain Failure
Opened Dec 20, 2005 · Closed Feb 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ANALYSIS UNDERTAKEN IN RESPONSE TO THE PETITION IDENTIFIED 26 COMPLAINTS ALLEGING TIMING CHAIN FAILURES IN MY 2000-2003 SATURN L-SERIES VEHICLE EQUIPPED WITH THE 2.2L L4 ENGINE.MOST COMPLAINTS OF TIMING CHAIN FAILURE REPORTEDLY RESULTED IN A SUDDEN LOSS OF ENGINE POWER AND STALLING.ODI ALSO NOTED THAT CERTAIN MY 2002-2003 SATURN VUE AND MY 2003 SATURN ION MODEL VEHICLES WITH THE 2.2L ENGINE VEHICLESCOVERED BY A TECHNICAL SERVICE BULLETIN (03-06-01-017) THAT ADDRESSED TIMING CHAIN DESIGN AND SERVICE PROCEDURE CHANGES, EXHIBITED NO COMPLAINTS OF TIMING CHAIN FAILURE.ODI WILL GRANT THE PETITION AND OPEN A PRELIMINARY EVALUATION TO ASSESS THE FREQUENCY, TREND, SCOPE AND SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.REFER TO PE06-006.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.
Illustration