DRIVING SMOOTHLY AT 50 MPH IN 1996 SAAB 900 SE TURBO, 99K MILES. ENGINE RPM SUDDENLY BUT SMOOTHLY DROPS TO ZERO AND STOPPED IN A VERY UNSAFE PLACE ON THE HIGHWAY. CAR WOULD NOT RE-START. ABSOLUTELY NO FAULTS OF ANY KIND OCCURRED DURING THE MONTHS LEADING UP TO THIS INCIDENT. THIS CAR'S DIRECT IGNITION CASSETTE WAS REPLACED ONCE …
Read full complaint
DRIVING SMOOTHLY AT 50 MPH IN 1996 SAAB 900 SE TURBO, 99K MILES. ENGINE RPM SUDDENLY BUT SMOOTHLY DROPS TO ZERO AND STOPPED IN A VERY UNSAFE PLACE ON THE HIGHWAY. CAR WOULD NOT RE-START. ABSOLUTELY NO FAULTS OF ANY KIND OCCURRED DURING THE MONTHS LEADING UP TO THIS INCIDENT. THIS CAR'S DIRECT IGNITION CASSETTE WAS REPLACED ONCE ALREADY IN JAN. 2000 BY THE PREVIOUS OWNER. *JB
NHTSA ODI #10141798
100,000 miles · Jul 29, 2005
Electrical System
PRIOR TO DI FAILURE, STARTING IMPAIRMENT AND MISFIRES DETECTED WITH CEL. UPON FAILURE, CAR WOULD NOT RUN AND STEERING WAS LOST. TO CORRECT FAILURE, NEW DI WAS FITTED AFTER IT WAS BROKEN. SYMPTOMS SHOULD HAVE BEEN REASON ENOUGH TO CHANGE IT EARLY. *NM
NHTSA ODI #10130620
72,000 miles · Apr 29, 2003
Electrical SystemFire
ON APRIL 27, 2003, MY SAAB 900 SE HAD AN ELECTRICAL FAILURE WHILE DRIVING WITHIN A MINUTE HAD COMPLETELY DESTROYED THE CAR. THE "CHECK BATTERY" LIGHT CAME ON ALONG WITH THE HAZARD LIGHT. MY WIFE WAS DRIVING THE CAR IN HEAVY TRAFFIC AND JUST ESCAPED THE VEHICLE WHEN IT WAS ENGULFED IN FLAMES. THE POLICE HAD TO CALL ME TO GET THE…
Read full complaint
ON APRIL 27, 2003, MY SAAB 900 SE HAD AN ELECTRICAL FAILURE WHILE DRIVING WITHIN A MINUTE HAD COMPLETELY DESTROYED THE CAR. THE "CHECK BATTERY" LIGHT CAME ON ALONG WITH THE HAZARD LIGHT. MY WIFE WAS DRIVING THE CAR IN HEAVY TRAFFIC AND JUST ESCAPED THE VEHICLE WHEN IT WAS ENGULFED IN FLAMES. THE POLICE HAD TO CALL ME TO GET THE LICENSE PLATE NUMBER AND VIN, AS THEY HAD MELTED. THE CAR HAD 72,000 MILES AND HAD BEEN CHECKED TWICE IN THE PAST YEAR. JUST MONTHS BEFORE IT HAD BEEN COMPLETELY INSPECTED. THE CAR WAS IN SHOW ROOM CONDITION. *JB
NHTSA ODI #10016693
Mileage unknown · Dec 14, 2000
Electrical SystemEquipmentFuel System, Gasoline
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #737809
Mileage unknown · Oct 24, 2000
Electrical SystemEngine And Engine CoolingPower TrainFire
AFTER A 30 MINUTES OF DRIVING VEHICLE WAS PARKED IN A PARKING LOT. SMOKE WAS NOTICED COMING FROM UNDERNEATH THE HOOD AREA BEFORE A FIRE STARTED. FIRE DEPARTMENT WAS ON SITE TO PUT OUT FIRE. SAAB HAS BEEN CONTACTED.*AK VEHICLE TRAVELING, CHECK THE ENGINE LIGHT APPEARED AND STAYED ON THE CAUSE WAS DETERMINED TO BE A SENSOR. …
Read full complaint
AFTER A 30 MINUTES OF DRIVING VEHICLE WAS PARKED IN A PARKING LOT. SMOKE WAS NOTICED COMING FROM UNDERNEATH THE HOOD AREA BEFORE A FIRE STARTED. FIRE DEPARTMENT WAS ON SITE TO PUT OUT FIRE. SAAB HAS BEEN CONTACTED.*AK VEHICLE TRAVELING, CHECK THE ENGINE LIGHT APPEARED AND STAYED ON THE CAUSE WAS DETERMINED TO BE A SENSOR. THE VEHICLE SLIPS WHILE IN GEAR AND BEFORE GOING INTO GEAR DUE TO LOSS OF FLUID BY LTHE LEAKING TRANSMISSION. *YH
NHTSA ODI #873699
Mileage unknown · Aug 9, 1999
Electrical SystemEngine And Engine CoolingEquipment
REMOTE ALARM SYSTEM FAILED. NLM
NHTSA ODI #547823
Mileage unknown · Jul 1, 1998
Electrical System
ELECTRICAL SYSTEM FAILURE, CAUSING CHECK ENGINE/TRANSMISSION INDICATOR LIGHTS TO FAIL. QCAW
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE INSTRUCTIONS FOR PROPERLY AIMING THE HEADLIGHTING SYSTEM WERE OMITTED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE SENT AIMING INSTRUCTIONS, AND DIRECTIONS FOR AFFIXING THESE INSERTS TO THE OWNER GUIDES. IF AN OWNER SO DESIRES, A DEALER CAN AFFIX THE INSERTS IN THEIR OWNER GUIDE FOR THEM.
CORROSION AROUND THE ZINC-COATED THROTTLE CONTROL LEVER BUSHING CAN CAUSE THE THROTTLE LEVER TO BIND.
Consequence & remedy
Consequence: THIS BINDING CAN RESULT IN THE THROTTLE PLATE NOT RETURNING TO THE CLOSED POSITION WHEN THE THROTTLE PEDAL IS RELEASED AND A SUBSEQUENT LOSS OF THROTTLE CONTROL.
Remedy: DEALERS WILL REPLACE THE ZINC-COATED THROTTLE CONTROL LEVER BUSHING WITH A NICKEL-COATED BUSHING AND BOLT.
DURING STATIC TESTING OF BELT ANCHORAGE POINTS, THE OUTBOARD ATTACHMENT PLATE BEING USED IN THE TESTING DEFORMED AND DETACHED FROM THE SEAT ANCHORAGE. THIS DOES NOT COMPLY WITH FMVSS NO. 209, "SEAT BELT ASSEMBLIES" AND NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE BELT MAY NOT LATCH PROPERLY INCREASING THE RISK OF INJURY TO AN OCCUPANT SHOULD A VEHICLE CRASH OCCUR.
Remedy: DEALERS WILL INSPECT THE SAFETY BELT ASSEMBLIES FOR THE DATE OF MANUFACTURE. ANY ASSEMBLY WITH DATE YEAR 96 WEEK 10 DAY 2 WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP00008 · Defective Water Pump Pulley
Opened Sep 25, 2000 · Closed Nov 19, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
a
SQ98018 · New Wheel Bolts
Opened Oct 9, 1998 · Closed Oct 27, 1998
Status: closed (inferred from source dates) · Wheels
saab issued a tsb informing dealers about a new wheel mounting bolt.If the issue is loosening of the lug nut, this could lead to bolt fatigue and the potential for a wheel separation.
1996 Saab 900 Problems, Complaints & Recalls | Skip That Year
Illustration